Frost Fighter IDH1000 Operation Manual
IDH1000 FEATURES AND OPERATION MANUAL
VERev. 1.2.2 Aug. 20188
Table of Contents
P
age 2
P
age 3-4
P
age 5
P
age 6-8
Page 9
- Fuel Fill Location & Filling Precautions
- Door latches, Compartments and Hitch/Tongue Details
- External Power Connections
- Heater Access Doors and Slide Out System
- Basic Features of Heaters (See heater manual for full operating & servicing information)
Page 10 -
Page 11-12 -
E
ngine/Generator Layout and Identification (See engine manual for engine type specific detailed information)
Rear Compartment Controls & Functions
Page 13 -
Page 14-15 -
Fuel Level Sending Unit
Compartment Lighting Control Timers - Function & Adjustment
Page 16
Page 17
Page 18
Page 19
Page 20
Page
21
- Basic Starting Instructions for the Kubota or Isuzu Diesel Engine
- Isuzu Engine Basic Spare Parts List
- Kubota Engine Basic Spare Parts List
- Location of Rating Plate Information and Serial Number Identification - List of Important Warnings & Precautions
- 120VAC Circuit Wiring Diagram
-
12VDC Circuit Wiring Diagram
-
A
ppendix A
Overall Exterior Dimensions
Fuel Fill Point
The fuel tank is filled at this location on the side of unit near the rear.
Maximum fuel tank capacity is 215 US gal (812 Litres)
Caution: Fill tank only to 7/8 of maximum capacity (approx. 190 US gal./720L)
Refer to rating plate in rear compartment for specific details.
Approximate maximum run time for IDF1000 with full tank is approx. 30 hours.
CAUTION:
Filling the fuel tank too quickly or overfilling the tank can increase the risk of spills,
backsplash or fuel discharging from the tank vent line due to fuel expansion, etc.
Page 2
Positive Lock Access Door Latches
Door Latches in Closed Position Press Bottom of Latches to Open
Page 3
Left front storage compartment access door.
Trailer tongue area i
llustrating various components
Always ensure tow vehicle has sufficient tow ratings and reduce speed when towing
Break-away switch
battery.
Check battery condition
annually
Tongue jack
7 Pin trailer
connector to vehicle
for exterior lights and
electric brakes
Break-away switch
Safety chains
Height adjustable hitch
Pintle or 2-5/16” ball
available
Page 4
External Power Connections
•
120VAC 15A "shore power" inlet to supply engine block heater
and battery charger/maintainer.
•
120VAC 15A GFCI protected auxiliary power
outlet
Page 5
Swing Open Side Access Doors
Access to Heater Discharges
Heater discharge doors have safety interlock switches
and each door must be open in order for the respective
heater to operate.
Access to Heater Controls
Heater inlet doors provide access to the heater
controls and should normally remain open
during operation.
Catches are provided to
secure doors in the open
position
Page 6
Loading...