Frigidaire FGTR2037TD Data Sheet
PERFORMANCE DATA NO LOAD & NO DOOR
OPENINGS AT MID-POINT CONTROL SETTING
Capacitor Run or Induction Run 65°F (18°C) Ambient
Operating Time 25 to 35%
Freezer Temperature 2° to 8°F (-17° to -13°C)
Refrigerator Temperature 35° to 40°F (2° to 4°C)
Low Side Pressure (cut-in) 8 to 16 psig ( 55 to 110 kPa)
Low Side Pressure (cut-out) 1 to 4 psig (7 to 28 kPa)
High Side Pressure (last 1/3 cycle) 110 to 120 psig (758 to 827 kPa)
Wattage (last 1/3 cycle) 95 to 140
Amps (running) 0.9 to 1.3
Base Voltage 115 vac (127 vac max)
DEFROST SPECIFICATIONS
Cabinet Size Thermostat
Cut-in Cut-out Ohms
18’, 20’ & 21’ 9°F (-2°C) 50°F (10°C) 35
15’ & 16’ 29°F (-2°C) 50°F (10°C) 41
Mechanical Timer - Defrost 24 minutes every 10 hours of compressor
run time.
Electronic Timer (ADC) - Defrost up to 24 minutes every 6-72 hours of
compressor run time.
CONDENSER FAN MOTOR
Watts RPM
2.3 1100 CW Opposite Shaft
ICE MAKER SPECIFICATIONS
Electrical 115 vac (127
vac max)
Thermostat Ice maker with
black housing
Ice maker with
white housing
Heater Wattage 165 W
Opens at 52°F
(11°C)
Opens at 48°F
(8.9°C)
60 Hertz
Closes at 12°F
(-11°C)
Closes at 9°F
(-12.8°C)
ICE MAKER CONNECTOR PLUG CONNECTIONS
Wire Number Wire Color
1 Green / Yellow
2 Yellow
3 Black
4 Light Blue
SERVICE DATA SHEET
A06813801
STANDARD - AUTOMATIC DEFROST
TOP MOUNT FREEZER - R134a
IMPORTANT SAFETY NOTE
The information provided herein is designed to assist qualied repair
personnel only. Untrained persons should not attempt to make repairs
due to the possibility of electrical shock. Disconnect power cord before
servicing this appliance.
IMPORTANT
If any green grounding wires are removed during servicing, they must
be returned to their original position and properly secured.
NOTE
Some products come equipped with an Electronic Defrost Control. To
initiate defrost, depress the fresh food light switch 5 times in 6 seconds
(light bulb must be working). To terminate defrost, depress the fresh
food light switch 5 times in 6 seconds.
CAUTION
All electrical parts and wiring must be shielded from torch ame.
DO NOT allow torch to touch insulation; it will char at 200°F
and ash ignite (burn) at 500°F. Excessive heat will distort the
plastic liner.
BLUE
BLUE
DK. BLUE
BLUE
YELLOW YELLOW
BLUE
IMPORTANT
PLEASE RETURN THIS SHEET TO ITS
ORIGINAL LOCATION.
ICE MAKER INFORMATION
Test Cycling: Remove cover by inserting screwdriver in notch at
bottom and prying cover from housing. Use screwdriver to rotate
motor gear counterclockwise until holding switch circuit is completed. All components of ice maker should function to complete
the cycle.
Water Fill Volume:
The water ll adjustment
screw will change the
ll time. One full turn is
equal to 20cc (.68 oz.).
The correct ll is 102 to
130cc (3.4 to 4.3 oz.).
When a water valve is
replaced, the ll volume
must be checked.
I
M
FZ1
C
DEFROST
THERMOSTAT
EFC
DH1
EVAP FAN
FF1
CONTROL BOX
FRONT VIEW
BACK VIEW
MC1
MC1 MC2
C C
INLINE CONNECTOR ABBREVIATION KEY
ABBREVIATION EXPLANATION
6 PIN CONNECTION LEFT OF COMPRESSOR
MC1
IN MACHINE COMPARTMENT
9 PIN CONNECTION RIGHT OF COMPRESSOR
MC2
IN MACHINE COMPARTMENT
9 PIN CONNECTION IN FRESH FOOD
FF1
2 PIN CONNECTION TO COMPRESSOR
CC
3 PIN CONNECTION TO CONDENSER FAN
CFC
2 PIN CONNECTION TO ICE MAKER WATER
WVC
VALVE (GREEN)
ICE MAKER CONNECTION IN FREEZER
IMC
6 PIN CONNECTION IN FREEZER
FZ1
EVAPORATOR FAN CONNECTION IN FREEZER
EFC
DEFROST HEATER CONNECTION IN FRZ LEFT
DH1
OF EVAP FAN
DEFROST HEATER CONNECTION IN FRZ RIGHT
DH2
OF EVAP FAN
COMP
CFC
COND FAN
WVC
DH2
FREEZER DOOR
SWITCH
FRESH FOOD
DOOR SWITCH
MC2/FF1
JST VLR-09 JST VLP-09
1
MOLEX 19-09-2019 MOLEX 19-09-1019
DH1/DH2
BLACK
ORANGE
FACTORY
USE
ONLY
COLD
CONTROL
ORANGE
BLACK
1
CTRL
LIVE
TYCO 1-480702-0 TYCO 1-480703-0
IMC
1
FRESH FOOD COMPARTMENT
LIGHT
LT.BLUE
LT. BLUE
ORANGE
GREEN/YELLOW
BLUE
YELLOW/BLACK
LT.BLUE
LT.BLUE
LT.BLUE
BLACK
LT.BLUE
LT.BLUE
BLUE
FRESH FOOD
GND
YELLOW/BLACK
TYCO 1-480701-0 TYCO 1-480700-0
1
1
EFC/CFC
WVC
TYCO 520935-4
BLACK
LT.BLUE
LT.BLUE
RED
PIN 2
PIN 1
PIN 6
TYCO 1-480705-0 TYCO 1-480704-0
1
BLACK
LT.BLUE
RED
1
MOLEX 43335-2002
BLACK
LT.BLUE
RED
CC
MC1/FZ1
1
GREEN/YELLOW
1
BLACK
LT.BLUE
RED
BROWN
RED
GREEN/YELLOW
BLUE
RED/WHITE
BROWN
LT.BLUE
YELLOW
BLUE
BLACK
PIN 2
PIN 3
PIN 4
PIN 6
PIN 7
PIN 8
PIN 9
MC2
PIN 1
PIN 2
PIN 3
PIN 4
PIN 5
PIN 6
BLACK
LT.BLUE
RED
BROWN
RED
GREEN/
YELLOW
BLUE
RED
BROWN
LT.BLUE
YELLOW
BLUE
BLACK
GREEN/YELLOW
RED
BLUE
BROWN
MACHINE COMPARTMENT
GROUND TO
CABINET
SPLICE
SPLICE
RED
LT. BLUE
BLACK
LT. BLUE
BLACK
LT. BLUE
RED
GREEN/YELLOW
LT. BLUE
YELLOW
BLACK
LT. BLUE
GREEN/YELLOW
LT. BLUE
GREEN/YELLOW
GREEN/YELLOW
GREEN/YELLOW
RED
LT. BLUE
LT. BLUE
LT. BLUE
YELLOW
PIN 2
RED
PIN 1
C C
PIN 2
PIN 3
PIN 1
CFC
PIN 1
PIN 2
WVC
LIVE (NON RIBBED)
NEUTRAL (RIBBED)
GROUND
COMPRESSOR
GROUND TO
COMPRESSOR BASE
CONDENSER
FAN
WATER
VALVE
(ICE MAKER)
MC1
LT. BLUE
LT. BLUE
DOOR
SWITCH
RED
RED
RED
GREEN/YELLOW
BLUE
BROWN
YELLOW/BLACK
PIN 9
PIN 5
PIN 7
PIN 3
PIN 4
FF1
RED
GREEN/YELLOW
BLUE
BROWN
YELLOW/BLACK
YELLOW/BLACK
BLACK
BLUE
BLACK
BROWN
GREEN/YELLOW
BLUE
BROWN
BLACK
SWITCH AND FREEZER LIGHT
RED
GREEN/YELLOW
OPTIONAL FREEZER DOOR
RED/WHITE
BLACK
YELLOW
BROWN
LT.BLUE
BROWN
LT.BLUE
YELLOW/RED
BLACK
BLUE
BLACK
BLUE
PIN 1
PIN 2
PIN 3
PIN 4
PIN 5
PIN 6
FZ1
LT.BLUE
BLACK
GREEN/YELLOW
RED/WHITE
YELLOW
YELLOW/RED
LT.BLUE
BLUE
BROWN
FREEZER
DOOR
SWITCH
FREEZER COMPARTMENT
LT. BLUE
LT. BLUE
YELLOW/RED
GREEN/YELLOW
DEFROST THERMOSTAT
LT. BLUE
YELLOW/RED
YELLOW
PIN 2
BLACK
LT. BLUE
LT. BLUE
GREEN/YELLOW
GREEN/YELLOW
GREEN/YELLOW
LT. BLUE
GREEN/YELLOW
LT. BLUE
RED/WHITE
GREEN/YELLOW
GREEN/YELLOW
BLUE
BLUE
BROWN
ICE MAKER
PIN 3
PIN 4
PIN 1
IMC
COIL COVER GROUND
PIN 1
EVAPORATOR
PIN 3
PIN 2
EFC
DEFROST HEATER
PIN 1
DH2
PIN 1
FAN
DH1
FREEZER LIGHT
LT. BLUE
YELLOW/RED
BLACK
DEFROST
TIMER
CTRL(3)
COMP/EVAP FAN(2)
NEUTRAL (1)
DEF HTR(4)
RED
BROWN
RED
ORANGE
LT.BLUE
BROWN
FRESH FOOD
Wiring Diagram A06001401
Loading...