FRIGIDAIRE FGHN2844LF User Manual

Mounting Plate Screws

Mounting Plate Screw

Motor Gear

Timing

Gear

Water Fill Adjustment

PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0°

CONTROL SETTING

Variable Speed Compressor 65°F (18°C) Ambient 90°F (32°C) Ambient

POWER

ICE MAKER

WATER VALVE

LINE

THERMAL

CUT-OUT

HOLD

SWITCH

THERMOSTAT

SHUT-OFF

SWITCH

WATER FILL

SWITCH

MOLD HEATER

MOLD

MOUNTING

PLAT E

165 W ATTS

MOTOR

NEUTRAL

BLK

BLU

LT. BLU

BRN

RED

GRN/YEL

GRN / YEL

RED

YEL

P-3

P-1

P-2

P-4

ICE MAKER

Operating Time 32 to 40% 100%

Freezer Temperature

Refrigerator Temperature

Low Side Pressure (cut-in)

Low Side Pressure (cut-out)

High Side Pressure

Wattage 40 to 55 60 to 70

Amps (running) .5 to 1.1 .7 to .9

Base Voltage 115 vac (127 vac max)

DEFROST SPECIFICATIONS

Cabinet Size

26’ & 28’ SD, 23’ CD

Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time.

CONDENSER FAN MOTOR

Watts RPM Amps

(Energy Star, some models)

Electrical 115 vac (127 vac max)

Thermostat Opens at 48° F (9° C), Closes at 15° F (-9° C)

Heater Voltage 85 vac

3.1

ICE MAKER SPECIFICATIONS

ICE MAKER CONNECTOR PLUG CONNECTIONS

Wire Number Wire Color Connects to:

1 Green/Yellow Ground

2 Yellow Water Valve

3 Black Line

4 Light Blue Neutral

-6° to 6° F

-21° to -14° C

33° to 46° F

0.5° to 8° C

5 to 12 psig

34 to 83 kPa

-2 to 2 psig

-14 to 14 kPa

85 to 95 psig

586 to 655 kPa

Thermostat Heater

Cut-in Cut-out Watts Ohms

25° F

(-4° C)

1100 CW

Opposite Shaft

47° F

(8° C)

-6° to 6° F

-21° to -14° C

33° to 46° F

0.5° to 8° C

-2 to 2 psig

-14 to 14 kPa

120 to 135 psig

827 to 931 kPa

500 26

0.03 Running

N/A

SERVICE DATA SHEET - 240389644

FREEZER ICE MAKER - AUTOMATIC DEFROST

BOTTOM FREEZER - R134a

IMPORTANT SAFETY NOTE

The information provided herein is designed to assist qualied

repair personnel only. Untrained persons should not attempt to make repairs due to the possibility of electrical shock. Disconnect power cord before servicing this appliance.

IMPORTANT

If any green grounding wires are removed during servicing, they must be returned to their original position and properly secured.

CAUTION

All electrical parts and wiring must be shielded from torch

ame. DO NOT allow torch to touch insulation; it will char at 200°F and ash ignite (burn) at 500°F. Excessive heat will distort the plastic liner.

NOTE



This product comes equipped with an Adaptive Defrost Control (ADC). To activate manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-) keys for 5 seconds. A “d” in the freezer temperature window and “F” in the refrigerator temperature window will display when the heater is activated. To deactivate manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-) keys for 5 seconds. A “d” and “F” will be displayed until the defrost cycle is complete.

IMPORTANT

PLEASE RETURN THIS SHEET TO IT’S ORIGINAL LOCATION

ICE MAKER INFORMATION

Test Cycling

Remove cover by inserting screwdriver in notch at bottom and prying cover from housing. Use screwdriver to rotate motor gear counterclockwise until holding switch circuit is completed. All components of ice maker should function to complete the cycle.

Water Fill Volume

The water ll adjustment screw will change the ll

time. One full turn is equal to 20cc (.68 oz.). The

correct ll is 102 to 130cc (3.4 to 4.3 oz.). When a

water valve is replaced,

the ll volume must be

checked.

242107201 Wiring Diagram Frig FDBF 2500++ V4 non Dispenser

Ice Maker Errors Displayed on “UI” System Error Codes Displayed on “UI” Diagnostic Mode Note: See Service Manual for

ERROR Test Activate: FZ (+) and FZ (-) for

OP or 2 SH or 3 OP or 2 SH or 3 SY EF SY CE SY CF

To initiate manual defrost press and hold, for 5 sec. FF(+) and FF(-), (d) and (f) will be displayed.

Freezer Sensor OPEN Freezer Sensor SHORTED FF Sensor OPEN FF Sensor SHORTED Evaporator Fan Circuit Communication error Communication error

In Manual Defrost

5 sec.

Standard compressor

Defrost heater

FF lighting

FZ lighting

Perfect Temp Drawer

VCC Condensor fan

VCC Compressor

Evaporator fan

De-activate: Hold FF (+) for 5 sec.

complete description.

Damper

Fresh food door

Freezer door

Defrost limit switch

FF Thermistor

FZ Thermistor

Ambient Thermistor

Software version