Freeflow Spas Tropic, Opal, Azure, Tristar Owner's Manual

The Perfect Choice

www.freeflowspas.com

OWNER’S MANUAL

DECEMBER 1, 2009

Fusion Series

Tropic

Azure

Tristar

Opal

DO NOT OPERATE SPA BEFORE READING THIS MANUAL

Failure to read this manual & follow its instructions may result in unsafe operation and or

CAUTION

permanent damage to your portable spa.

TABLE OF CONTENTS

INTRODUCTION

TITLE Page

1. Table of Contents 2

2. Owners Record 3

3. Planning a Location 4

4. A Good Foundation 5
Placing the Hot Tub

5. Important Safety Instructions 6

6. Safety Precautions 7

7. Electrical Requirements 8

8. Controller Reference Guide 9

9. Feature Operations 10

10. Fill and Start-up Instructions 11

11. Adding Start-up Chemicals 12

12. Cleaning or Winterizing 13

13. Spa Maintenance 14

14. Cover Care 15

Spa Light Replacement

15. Troubleshooting Procedures 16

16. Limited Warranty 17

Most cities, counties, states, and countries require permits for exterior construction and electrical
circuits. In addition, some communities have codes requiring residential barriers such as fencing
and/or self-closing gates on the property to prevent unsupervised access to a pool or hot tub by
children. Be sure to check with your local agencies for specific requirements.

2

The Perfect Choice

Owners Record

Locating the Fusion Hot Tub Serial Number:

Label is located on the lower right side of the equipment access panel. You will need the spa model and serial
number to properly register your spa and activate coverage.

DATE PURCHASED:

PURCHASED FROM: PHONE:

TELEPHONE:

SPA MODEL / SERIAL NUMBER:
(located by bar code sticker near equipment access door)

Please read this “Owners Manual” carefully, as it is designed to provide you with the
information you will need to ensure the safe, secure use of your new Fusion Hot Tubs.

IMPORTANT: Fusion Hot Tubs and Freeflow Products, Inc. reserves the right to change

specifications and/or design without notification and without any obligation.

SPA DIMENSIONS

Spa Model Length Width Height Dry Weight
Tropic 75” D (191cm) Round 33” (84cm) 300lbs (136kg)

Azure 80”(203cm) 62” (183cm) 32” (81cm) 335lbs (152kg)
Tristar 72” (183cm) 72” (183cm) 31” (79cm) 295lbs (134kg)
Opal 77” (196cm) 66” (168cm) 29” (74cm) 255lbs (116lg)

3

PLANNING A LOCATION FOR YOUR FUSION HOT TUBS

Consider these things when determining where to place your hot tub.

SAFETY FIRST:

Do not place the hot tub within 10 feet (3m) of overhead power lines. Make sure your hot tub is
positioned so access to the equipment compartment and side panels will not be blocked. Be certain
your installation will meet all city and local safety codes and requirements.

PLANNED USE OF HOT TUB:
How you intend to use your hot tub will help you determine where you should position the hot tub.
For example, will you use it more for recreational or therapeutic purposes? If your hot tub is
mainly for family recreation, leave plenty of room around it for activity and lawn furniture. If you
will use it more for relaxation and therapy, you’ll probably want to create a specific mood around
the tub.

ENVIRONMENT:
If you live in a climate with a snowy winter and hot summer, a place to change clothes or a house
entry near the hot tub is convenient. A warmer climate may require shade from the hot sun.
Consider placement of trees, shrubs, patio cover or perhaps a gazebo structure to provide what you
will need. Indoor installations require adequate ventilation. When the hot tub is in use,
considerable amounts of moisture are produced. This moisture can damage walls and ceiling
surfaces over time. Special paint is available to resist moisture damage. Remember that hot tubs
periodically require drainage, so plan your environment accordingly.

PRIVACY:
Think of your surroundings during all seasons to determine your best privacy options. Consider
the view of your neighbors when you plan the location of your hot tub.

VIEWS:
Think about the direction you will be facing when sitting in your hot tub. Do you have a special
landscape you will find enjoyable? Perhaps there is an area that has a soothing breeze during the
day or a lovely sunset in the evening.

KEEP CLEAN:
Prevent dirt and foliage from being tracked into your hot tub by utilizing concrete for paths and
access areas. Check the location of spill paths from gutters, trees, and shrubs.

SERVICE ACCESS:
Many people choose to install tile or custom wood around their hot tubs. If you are installing your
tub with custom decorative trimming, remember to allow for access to it for service. Should you
need service, a technician may need to remove the tub’s side panels, or access it from beneath. It

4

is always best to design special installations so the hot tub can still be moved, or lifted from the
ground.

A Good Foundation

Your new hot tub needs a good solid foundation. The area your hot tub sits on must be able to
support the tub, the water in it and those who use it. If the foundation is inadequate, it may shift or
settle after the hot tub is in place, causing stress to the shell or components.

BE AWARE:
Damage caused by inadequate or improper foundation support is not covered by the hot tub
warranty. It is the sole responsibility of the hot tub owner to provide a proper foundation for the
hot tub.

Make sure the foundation where the hot tub is placed drains water away from the hot tub. Proper
drainage will keep components dry from rain and wet weather.

If you choose to install your hot tub indoors, pay close attention to the flooring beneath it. Always
remember a hot tub is filled with water. Choose flooring that will not be spoiled or ruined from
water damage. Check with your contractor to verify your flooring can support the weight and
water spills or splashing from your hot tub.

Your hot tub weight must always be considered when installing your hot tub. If you are installing
it on an elevated wood deck or other structure, it is advisable to consult a structural engineer or
contractor to ensure the structure will support the weight.

IT IS STRONGLY RECOMMENDED THAT A QUALIFIED, LICENSED CONTRACTOR

PREPARE THE FOUNDATION FOR YOUR FUSION HOT TUB.

There is a 4” (10cm) minimum depth requirement for a concrete pad.

Placing the Fusion Hot Tub

CHECK THE DIMENSIONS OF YOUR HOT TUB

Compare the hot tub dimensions to the width of gates, sidewalks, and doorways along the delivery
route used to bring the hot tub into your yard. It may be necessary for you to remove a gate or
partially remove a fence in order to provide an unobstructed passageway to the installation
location.
Also, keep in mind—if you are using special equipment to place your hot tub into an area it will be
necessary to include those measurements and weights.

PLANNING A DELIVERY ROUTE:

Check the width of gates, doors and sidewalks to make sure your hot tub will pass through
unobstructed. You may have to remove a gate or part of a fence to allow for adequate width
clearance.
If the delivery route will require a 90-degree turn, check the measurements at the turn to ensure the
hot tub will fit.
Check for protruding gas meters, water meters, A/C units, etc., on your home which will cause
obstructions along the delivery path to your yard.
Check for low roof eaves, over hanging branches or rain gutters that could be an obstruction to
overhead clearances.

5

SPECIAL CIRCUMSTANCES

The use of a crane for delivery and installation is primarily to avoid injury to your hot tub, your
property or to delivery personnel. Our customer service may be able to assist you with the
arrangements. Cranes are not considered “normal delivery”.

Important Safety Instructions

It is the hot tub owner’s responsibility to read and follow all the instructions and precautions described in this
manual. Failure to do so may result in personal injury. Liability rests with the hot tub owner. Please, make
instructions available for reference by all hot tub users. Some warnings labels have been shipped with your new hot
tub BEFORE OPERATING THE SPA: READ AND FOLLOW ALL INSTRUCTIONS. SAVE ALL

INSTRUCTIONS.

1. WARNING: A wire connector is provided on this unit to

connect a minimum No. 8 AWG (8.4mm

2

) solid copper
conductor between this unit and any metal equipment, metal
enclosures of electrical equipment, metal water pipe, or
conduit within 5 feet (1.5m) of the hot tub.

2.DANGER – Risk of Accidental Drowning. Extreme
caution must be exercised to prevent unauthorized access
by children. To avoid accidents, ensure that children cannot

use this hot tub unless they are supervised at all times.

3.DANGER – Risk of injury. The suction fittings in this spa
are sized to match the specific water flow created by the
pump. Should the need arise to replace the suction fittings or
the pump, be sure that the flow rates are compatible.

Never operate spa if the suction fittings are broken or
missing. Never replace a suction fitting with one rated less
than the flow rate marked on the original suction fitting.

4.DANGER – Risk of Electric Shock. Install at lease 5 feet
(1.5m) from all metal surfaces. As an alternative, a spa may
be installed within 5 feet of metal surfaces if each metal
surface is permanently connected by a minimum 8 AWG
(8.4mm) sold copper conductor to the wire connector on the
terminal box that is provided for this purpose.

5.DANGER – Risk of Electrical Shock. Do not permit any
electric appliance, such as a light, telephone, radio or
television, within 5 feet (1.5m) of a spa.

6. WARNING – To reduce the risk of injury:

a. The water in the spa should never exceed 104ºF (40ºC).

Water temperatures between 100ºF (38º C) & 104ºF
(40ºC) are considered safe for a healthy adult. Lower water
temperatures are recommended for young children and
when spa use exceeds 10 minutes.
b. Since excessive water temperatures have a high
potential for causing fetal damage during the early months
of pregnancy, pregnant or possibly pregnant women
should limit spa water temperatures to100°F (38º C).

c. Before entering a spa, the user should measure the
water temperature since the tolerance of water
temperature-regulating devices varies.

d. The use of alcohol, drugs, or medication before or
during spa use may lead to unconsciousness with the
possibility of drowning.
e. Obese persons and persons with a history of heart
disease, low or high blood pressure, circulatory system
problems, or diabetes should consult a physician
before using a spa.
f. Persons using medication should consult a physician
before using a spa since some medication may induce
drowsiness while other medication may affect heart
rate, blood pressure and circulation.
g. Heat stroke is a dangerous condition brought about
by excessive heat. It especially affects the very young,
elderly, individuals under the influence of alcohol or
drugs, and those using certain medications. The
symptoms include: sweating, dizziness, nausea, light­headedness, convulsions, increased pulse rate, shallow
breathing, and in the extreme, unconsciousness. If you
suspect heat stroke, get medical help immediately.
Lay the victim on his back, with the head slightly
elevated for easier breathing, and apply ice packs to
the head.
h. Emergency telephone numbers, such as: hospital,
physician, ambulance, paramedics, and the police
should be readily available and posted next to a close­by telephone.

6