Flymo CCT250 Instruction Manual

CONTOUR

POWER PLUS

CORDLESS

For all customer enquiries or for replacement parts, contact:-



01325 300303

www.flymo.com

[e-mail]

IMPORTANT INFORMATION

Read before use

& retain for future reference

Original Instructions

Carton Contents

IMPORTANT !

Please check the contents of the carton are correct BEFORE assembling your new Flymo product.

IF ANY PARTS ARE MISSING CONTACT:-

Husqvarna UK Ltd. Customer Service Department direct
Telephone : [phone] Fax : [phone]

Safety

If not used properly this trimmer can be dangerous! This trimmer can cause serious injury to the
operator and others, the warnings and safety instructions must be followed to ensure
reasonable safety and efficiency in using this trimmer. The operator is responsible for following
the warning and safety instructions in this manual and on the trimmer.

Explanation of Symbols on your product

Warning

Read the user instructions carefully
to make sure you understand all
the controls and what they do.

Do not use in the rain or leave the
product outdoors while raining

Keep others, including children, pets and
bystanders outside the 10 metre hazard
zone. Stop the trimmer immediately if
you are approached.

The use of eye protection is
recommended to protect against
objects thrown by the nylon line.

Warning

The cutting line continues to rotate after the machine
has been switched off.

General

1. This product is not intended for use by persons (including
children) with reduced physical, sensory or mental
capabilities, or lack of experience and knowledge, unless
they have been given supervision or instruction concerning
the use of the product by a person responsible for their
safety. Children should be supervised to ensure that they
do not play with the product. Local regulations may restrict
the age of the operator.

2. Only use the trimmer in the manner and for the
functions described in these instructions.

3. Never operate the trimmer when you are tired, ill or
under the influence of alcohol, drugs or medicine.

4. The operator or user is responsible for accidents or
hazards occurring to other people or their property.

Battery

Cordless Battery Powered Products require special care.

1. AVOID ACCIDENTAL STARTING. KEEP HANDS AND
FINGERS AWAY FROM THE SWITCH LEVER WHILE
CARRYING THE TRIMMER.

2. Always charge the product indoors and store in a
cool dry place - out of the reach of children.

3. Use only the charger provided with your unit. Use of
any other charger could permanently damage the
battery and the trimmer.

4. Use the charger with standard domestic household
electrical outlets only.

5. Do not abuse the charger or charger cord.

6. Do not use the charger if the charger or charger
cord is damaged.

7. Use the charger indoors only.

8. Do not use the charger outdoors.

9. Store and charge this unit in a cool, dry well ventilated
location and out of the reach of children.

10. Do not charge the battery or use the unit in an
explosive or corrosive environment. Avoid areas
where flammable liquids or gases are present to
avoid creating a fire or explosion.

11. Do not attempt to repair the unit including the battery.
Nylon line replacement and cleaning the unit are the
only items suitable for user maintenance.

12. Do not insert any object into the motor area. Keep
free of debris to avoid overheating.

3
6
0
º

10m

steady handle

guard

wall bracket

Integrated

battery

charger

instruction

manual

fixing plugs

screws

shoulder harness

Wheel

switch lever

lock-off button

tube

trimmer head

13. Do not incinerate or mutilate the battery. Batteries
contain hazardous chemicals. Dispose of properly.

Preparation

1. While using your product always wear substantial
footwear and long trousers.

2. Before using the machine and after any impact, check for
signs of wear or damage and repair as necessary.

3. Inspect the area to be cut before each use. Remove
all objects such as stones, broken glass, nails, wire,
string etc, which can be thrown or become entan­gled in the trimmer head.

4. Before use, inspect the area for wildlife, especially
hedgehogs.

5. Check that the cutting head, spool and cap are fitted
correctly.

Use

1. Use the trimmer only in daylight or good artificial light.

2. Avoid operating your trimmer in wet grass, where feasible.

3. Take care in wet grass, you may lose your footing.

4. On slopes, be extra careful of your footing and wear
non-slip footwear.

5. Do not walk backwards when trimming, you could
trip. Walk, never run.

6. Never operate the trimmer with damaged guards or
without guards in place.

7. Never fit metal cutting elements.

8. Keep hands and feet away from the cutting means at all
times and especially when switching on the motor.

9. Keep cutting head below waist level.

10. Do not lean over the trimmer guard whilst trimming or
edging - objects may be thrown by the cutting line.

11. Beware of cut-off pieces of nylon line ejected during use.

12. If you hit an object, do not use your trimmer until you
are sure that the entire trimmer is in a safe operating
condition.

13. If the trimmer starts to vibrate abnormally, check
immediately. Excessive vibration can cause injury.

Maintenance and storage

1. Keep all nuts, bolts and screws tight to be sure the
trimmer is in safe working condition.

2. Replace worn or damaged parts for safety.

3. Only use the replacement cutting line specified for
this product.

4. Only use replacement parts and accessories
recommended by Husqvarna UK Ltd..

5. To avoid the risk of injury keep fingers and hands clear of
the line cutter on the leading edge of the guard.

6. Clean unit with a dry cloth. Never use metal objects
to clean the unit.

7. Inspect and maintain the trimmer regularly. Any repairs
must be carried out by an authorised repairer.

8. Store the product in a cool, dry place and out of reach of
children. Do not store the product outdoors.

Battery Care

1. If over a period of time the battery quickly runs
down after a full 24 hour charging period, a
replacement battery is needed.

2. There will be some charge present in the battery
but to ensure maximum running time, recharge
your trimmer for 24 hours before use.

3. Permanent connection to the charger in a well
ventilated area will automatically keep your battery
fully charged ready for use.

4. To prevent permanent battery damage, never store
in a discharged condition.

5. Contact your local approved service
centre/dealer/distributor for a replacement battery
and for safe disposal of your old battery.

6. Battery
12 Volt 7 Amp/Hour "High Power"
Sealed for Life No maintenance required

• IMPORTANT

DISPOSE OF YOUR OLD BATTERIES SAFELY

DO NOT CUT OPEN, BURN OR INCINERATE.

Battery Replacement

Should your battery need to be replaced contact your local
approved service centre or dealer who will remove your old
battery and fit a genuine Flymo replacement battery.

To remove the Battery

1. Remove the bolt and nut (as shown in Pic) and remove the

battery cover.

2. Detach the leads from the old battery.

3. Attach the replacement battery

IMPORTANT

The red lead should always be

connected to the red terminal (+)

on the battery. The other lead

should always be connected to

the black terminal (-) on the

battery.

4. Refit the battery cover and secure
with the bolt and nut.

Bench Top Re-charging

The wall bracket can also be used as a "bench top"
stand for re-charging your cordless trimmer.

Winter Storage

1. Fully charge for 24 hours before winter storage.

2. If you are unable to leave your cordless trimmer on
permanent charge, re-charge the battery every 3 to 4
months for a full 24 hour charging period to top up the
battery charge during winter storage.

3. Avoid extended storage without re-charge.

4. Store in a cool dry place.

For further information on Battery replacement

contact Husqvarna UK Ltd. Customer Service direct:-

Telephone: [phone] Fax: [phone]

Battery