Flightcom VENTURE V90SP, VENTURE V90MPH, VENTURE V50SP, VENTURE V50MPH, VENTURE V70SP Operation Manual
...
General Aviation
Flightcom Corporation
7340 SW Durham Road, Portland, OR 97224 USA
www.flightcom.net • e-mail: sales@flightcom.net • 800-432-4342 or 503-684-8229
Flightcom is a registered trademark of Flightcom Corporation.
Specifications subject to change without notice. ©2012 Flightcom Corporation.
P/N: 600-3039-00 Rev. B
MAINTENANCE
Care and Maintenance
• Inspect ear seals and mic muff frequently for wear. Replace at 6 month intervals.
If you see any defect such as holes or cracks in the ear domes, ear seals, or
headband, headset should be immediately repaired or replaced.
• Do not remove the foam speaker cover.
• To ensure proper function, keep the microphone away from excessive moisture.
Do not store headset in high temperature environments or direct sunlight.
• Wipe headset and ear seals with a mild soap and water mixture only. The foam
mic muff may be removed and cleaned in a mild detergent, or replaced by
ordering from Flightcom.
WAR
NIN
G
Never immerse any part
of
t
he Headset
in wat
er
.
To Order Flightcom Accessories:
Call: 1-800-432-4342
V90SP/MPH
V70SP
V50SP/MPH
V30SP
FLIGHTCOM VENTURE
FLIGHTCOM VENTURE
T
M
GENERAL AVIATION HEADSETS
Operation Manual
TM
General Aviation 600-3039-00 manual:Layout 1 2/29/12 9:24 AM Page 1
HEADSET FEATURES
HEADSET A D J U S T M E N T S
WIRIN G D I A GRAM
INSTA LLAT I O N
• Passive Noise Reduction by 24dB
• Stereo/Mono switchable
• Noise-canceling electret microphone
• Adjustable Headband
• Flexible mic boom with slide adjustment for accurate mic positioning
Adjustable
headband
Adjustable
Boom
Volume control
Mic Placement
Place mic no more than 1/8"
from lips. Placement of mic is
critical for proper operation.
W
A
R
NI
NG
If th
e m
icro
p
h
o
n
e is p
o
sitio
ned
incorrectly, you may
experien
ce a red
uctio
n
o
r in
t
erruption in the audio
and
or d
eterio
rat
io
n
in
clarit
y o
f
intercom and radio.
Insert the larger plug into the jack marked “headphone” or “phone”.
• Insert the smaller plug into the jack marked “microphone” or “mic”.
• Set the stereo/mono switch on the cable splitter box to the “M” position.
If connecting to a stereo intercom, set the switch to the “S” position.
• Adjust headband slider and mic boom for proper fit and comfort.
• Place the microphone no more than 1/8” from lips, at the corner of the mouth.
This is critical to the performance of the noise canceling electret microphone.
• Two independent volume controls are provided, one on each ear dome, to adjust
the level of audio. (Single volume on V30SP)
If the aircraft does not have a built-in push-to-talk (PTT) switch, a portable PTT
switch must be installed in order to use the radio. The master gain control located
in the aircraft radio should be optimized by an avionics technician whenever adding
a new model microphone to the system.
Caution:
Bias voltage supplied to the
microphone must come
from voltage and resistance
ranges specified above.
Voltages supplied in excess
of those stated in the
specifications can cause
microphone failure and void
warranty. The mic audio
signal is present between
the ring and barrel of the
mic plug; tip is reserved for
transmit keyline.
Right
Left
Speakers
Mic.
6.3 mm Plug
5.2 mm Plug
M
S
Right
Left
Speakers
Mic.
4
C
o
n
d
u
c
t
o
r
P
l
u
g
TECHNICAL SPEC
- Weight ...............................................17.1oz Avg. (w/o Comm Cable)
- Noise Reduction Rating .........................................................24dB
MICROPHONE
- DC Bias Supply ..................................8 to 16 volts, not polarity sensitive
- Source Resistance ................................................220 to 2200 ohms
MIL SPEC
- Humidity & Temperature per MIL-STD 810F and 810G
- Chemical Exposure per MIL-STD 810F and 810G
SAE
- Salt Spray per J1455, Sec. 4.3
SPECI F I C ATIONS
Model Domes Ear Seals Head Band Pad Head Band Color Boom Headset Bag
V90SP Carbon Fiber ComLeather Wide Chrome Precision Flex Heavy Fabric
V90MPH
1
Thick w/polar fleece
V70SP Carbon Fiber ComLeather Low-profile Black Precision Flex Fabric
w/polar fleece
V50SP Glossy Black PVC Open Air pillow Black Precision Flex Vinyl
V50MPH
1
Cell Foam
V30SP Black PVC Open Ventilated Black Precision Flex None
Cell Foam Low-profile
(Single volume on V30SP)
1
Helicopter headset: uses U174 plug
Helicopter
General Aviation 600-3039-00 manual:Layout 1 2/29/12 9:24 AM Page 2
Loading...