Fisher-Price 74420 User Manual

Monster BIGFOOT

with Action Sounds Dash

™

Owner ’s Manual with Assembly Instructions

Please read this manual and save it with your original sale’s receipt.

For Model 74420

Tools needed for assembly: Phillips Screwdriver, Slotted Screwdriver, Hammer, Safety Scissors.

Three size LR6 “AA” alkaline batteries (not included) needed for sound box.

Use only with Power Wheels®Type H 6 Volt (9.5 Amp/Hr.) Batteries, Power Wheels®30 Amp Fuses

and Power Wheels®Type H 12 Volt Charger (all included).

CAUTION

ELECTRIC TO Y : Not recommended for children under 3 years of age.

As with all electric products, precautions should be observed during

handling and use to prevent electric shock.

Product features may vary from the picture above.

WARNING

• Children can be harmed by small parts, sharp edges and sharp points in the vehicle’s unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, batteries or help in assembly of the vehicle.

• Keep small parts and plastic bags out of children’s reach. Dispose of plastic bags properly.

• Adult supervision is required. Children do not have the judgement necessary to avoid many accidents. Be sure that children operating this vehicle can do so safely and that they are supervised at all times.

• Improper use of this vehicle could lead to a serious or fatal accident. Allow children to play with Monster BIGFOOT

only when you have determined that they can do so safely. Follow

all instructions to help your child enjoy this vehicle as safely as possible.

• Never use near steps, driveways, steep inclines, roadways, alleys, swimming pool areas or other bodies of water.

• Always wear shoes or sneakers when riding in this vehicle.

• Never allow more than one rider.

• The rider should sit on the seat when the vehicle is in operation.

• Hot motor covers. Handle carefully.

• Never alter this vehicle or its electrical system in any way. Alterations could cause a fire resulting in injury and could also ruin the electrical system.

• Use of the wrong type 6 volt battery, fuse or charger could cause a fire or explosion, resulting in serious injury.

• Never add unauthorized parts to the vehicle or use substitute parts. Use only specified Power Wheels

replacement parts.

• Batteries must be handled by adults only.

• Never lift or carry the 6 volt batteries by the wires or connectors. This can damage the 6 volt batteries and possibly cause a fire resulting in injury. Lift and carry the 6 volt batteries by the cases only.

• Never permit a child to handle batteries. The 6 volt batteries are heavy and contain sulfuric acid (electrolyte), and if dropped could result in serious injury. Read the cautions on the back panel of the 6 volt batteries.

• Never allow children to charge the 6 volt batteries. Battery charging must be done by adults only. A child could be injured by the electricity involved in charging the 6 volt batteries.

• Examine the 6 volt batteries, charger and their connectors for excessive wear or damage each time you charge the 6 volt batteries. If damage or excessive wear is detected, do not use the vehicle until you have replaced the worn or damaged part as it could possibly cause a fire resulting in injury.

Throughout this manual you will find important messages in the form of WARNINGS, CAUTIONS, and NOTES.

WARNING

WARNING – SIGNALS SOMETHING THAT

COULD HURT YOUR CHILD OR YOU.

The message explains the hazard and

how you can avoid it.

CAUTION

• Do not operate your vehicle for the first time until you have inserted the 30 amp fuses into the 6 volt batteries and charged the 6 volt batteries for at least 18 hours. Never charge the 6 volt batteries longer than 30 hours.

• After first-time use, charge the 6 volt batteries for at least 14 hours after each use. You do not have to let the 6 volt batteries run down completely before recharging. Never charge the 6 volt batteries longer than 30 hours.

• Use the charger indoors only.

• Read and follow the Battery Care instructions on page 30. Failure to follow the Battery Care instructions may permanently damage your 6 volt batteries and will void your warranty.

• When you purchase replacement 6 volt batteries, you should buy a set. Using an older 6 volt battery with a new 6 volt battery may cause permanent damage to both 6 volt batteries.

• To avoid damaging motors and gears, do not overload the vehicle.

- Never allow more than one child in the vehicle at one time.

- Do not exceed the maximum weight capacity of 65 lbs.

- Do not tow anything behind Monster BIGFOOT

. The extra weight may overload the

vehicle.

• Avoid operating the vehicle in wet or snowy conditions, and do not spray the vehicle with a hose. Do not wash the vehicle with soap and water. Water or moisture in the motors or electrical switches can cause them to corrode, and could cause switch failure.

• Avoid operating the vehicle on sand, loose dirt or gravel. Sand, loose dirt and gravel in the electrical switches or motors can cause them to jam, and could cause switch failure. Use

Monster BIGFOOT

on grass, asphalt or other hard surfaces.

CAUTION

CAUTION – SIGNALS SOMETHING THAT

COULD DAMAGE THE VEHICLE.

The message explains the risk and

how you can avoid it.

NOTE – Is used to highlight useful information.

Table of Contents

A Message to Parents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

B Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

C Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6

D Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8

E First-T ime 6 Volt Battery Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

F Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

G 6 Volt Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26

H Charging the 6 Volt Batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28

I Battery Handling/Care/Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30

J Rules for Safe Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31

K How to Operate Your Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33

L Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35

M Problems and Solutions Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36

N Statement of Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40

O Authorized Service Centers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40

Message to Parents

Thank you for purchasing the Power Wheels

Monster BIGFOOT®with Action Sounds Dash™!

For over 30 years, Power Wheels®has manufactured high-quality, battery-powered vehicles for children. Our goal is to provide your child with an enjoyable and safe driving experience. To help achieve this goal, it is extremely important that you read this entire manual and share the appropriate information with your child.

Monster BIGFOOT

requires adult assembly. Please set aside at least 45 minutes for assembly. Read the assembly instructions carefully and identify all parts before assembly. Refer to the Parts Section beginning on page 6 for parts identification. Save all packaging material until assembly is complete to ensure that no parts are discarded.

In the unlikely event that parts are missing or damaged or if you have any questions about your Power Wheels

vehicle, please call our Consumer Affairs toll-free service lines, open from 8 AM to 6 PM (EST) Monday through Friday.

Please call us at 1-800-348-0751.

Trained customer service representatives are available to take your call in English or French.

¿Habla Español? Si usted tiene alguna pregunta ó necesita asistencia llame gratis 1-800-348-0755 para los Estados Unidos. Tenemos representantes que hablan español para atender su llamada.

We also have a nationwide Authorized Service Center network – with over 300 Authorized Service Centers. Our Authorized Service Centers will repair or replace parts under warranty at no charge. For vehicles beyond warranty, our Authorized Service Centers will perfor m repairs for a minimal charge. For the Authorized Service Center nearest you, please see the Authorized Service Center listing beginning on page 40.

Impor tant Information

• Carefully read this manual for important safety information and operating instructions before using your vehicle.

• Please complete and return the enclosed Registration Card, or call 1-800-348-0751 to register your vehicle by phone.

• Monster BIGFOOT®is designed for use by children 3-7 years.

• Adult assembly is required.

• Monster BIGFOOT®has an adjustable play seat belt. Please note that the adjustable seat belt is designed to be a play feature only and does not function as a protective safety restraint.

• This vehicle uses two Power Wheels®Type H 6 volt-

9.5 Amp/Hr lead batteries with Power Wheels®30 amp fuses and a Power Wheels®Type H 12 volt charger (120 VAC 60 HZ 28W with an output of 12 VDC 1200 mA). Do not substitute any other batteries, fuses or charger.

• Before first-time use, charge the 6 volt batteries for

at least 18 hours. Never charge the 6 volt batteries longer than 30 hours.

• After the first charge, charge the 6 volt batteries a minimum of 14 hours after each use. Never charge the 6 volt batteries longer than 30 hours.

• Do not run down the 6 volt batteries completely before charging.

• Leaving the 6 volt batteries in a discharged condition will ruin them.

• Charge the 6 volt batteries before storing your vehicle.

• Charge the 6 volt batteries at least once per month, even if the vehicle has not been used.

• Do not store the 6 volt batteries in temperatures above 75˚ F or below -10˚ F.

• Even with proper care, the 6 volt batteries will not last forever. The life of the 6 volt batteries depends on how well you follow the Battery Care instructions and the total number of hours the 6 volt batteries are used. Please refer to the Battery Handling/Care/ Disposal instructions on page 30 for detailed information about battery care.

• When you purchase replacement Power Wheels

Type H 6 volt batteries, you should buy them as a set. Using an older 6 volt battery with a new 6 volt battery may result in poor perfor mance and may cause permanent damage to both 6 volt batteries. Remember to charge new 6 volt batteries for at least 18 hours before first use.

• To purchase Power Wheels®Type H 6 volt batteries, Power Wheels®30 amp fuses or a Power Wheels

Type H 12 volt charger, please contact:

- the store where your vehicle was purchased.

- an Authorized Service Center (see Authorized

Service Center list beginning on page 40).

- Power Wheels®Consumer Affairs at 1-800-348-0751.

• While the 6 volt batteries are charging, the charger may become warm to the touch. This is a normal condition and does not indicate a problem.

• Monster BIGFOOT®is suitable for use on grass, asphalt or other hard surfaces. To prevent damage to the motors and switches, do not operate the vehicle on loose dirt, gravel or sand.

• To prevent damage to electrical components, store

Monster BIGFOOT®inside or under a protective

cover during snowy or rainy weather. Do not leave

Monster BIGFOOT®out in the rain or let your child

wash it with soap and water.

• Monster BIGFOOT®has a special circuit-breaker in the wiring to protect the motors and electrical system. If the vehicle is put under extreme load (driving on rough surfaces, too much weight, climbing too steep of an incline), the circuit-breaker will shut the electrical system down for up to 20 seconds. If the system repeatedly shuts down, the driving conditions may be too demanding (ie: too steep or too much weight).

• Metal parts have been coated with a lubricant to protect them during shipment. Wipe all metal parts with a paper towel to remove any excess lubricant.

Seatbelt Set

Parts

Soundbox Cover

Lens Guard – 2

Battery Retainer

If you experience a problem with this product, or are missing a part, please call us

at 1-800-348-0751, rather than return this product to the store.

Please save all packaging material until assembly is complete to ensure that no parts are discarded.

Sound Box

Microphone

Lens – 2

Light Plate – 2

Light Housing – 2

Sport Bar Foot Set

Grille

Steering Wheel Cap

(Long Strap)

(Short Strap)

Taillight Lens Set

(Left)

(Right)

Airscoop

Headlight Lens Set

Sport Bar Bracket Set

Sport Bar Support – 2

12 Volt Charger

6 Volt Batteries

#8 x 1" Screw – 18

#6 x 11/2" Screw – 2

30 Amp Fuse – 3*

Knob

Sport Bar

Not Shown: Label Sheet

Steering Column

Parts

.354 Cap Nut – 3*

All Shown

Actual Size

Vehicle Body

Hood

Seat

Light Rack

T M

*For your convenience, an extra 30 amp fuse

and .354 cap nut have been included.

Steering Wheel

#6 x1/2" Screw – 4

Key

/16" Washer – 2

#6 x

/8" Screw – 2

Tailgate

Par ts Diagram

1 Airscoop 2 Hood 3 Microphone 4 Steering Column 5 Steering Wheel 6 Steering Wheel Cap 7 Cap Nut – 2 8 Sound Box Cover

9 Knob 10 Key 11 Seat 12 Lens Cover – 2

13 Lens – 2 14 Light Plate – 2 15 Light Housing – 2 16 Sport Bar Cover 17 Sport Bar Bracket – 2 18 Sport Bar Support – 2 19 Sport Bar 20 Tailgate 21 Left Taillight 22 Sport Bar Foot – 2 23 Right Taillight 24 Vehicle Body

25 Sound Box 26 Grille 27 Left Headlight Lens 28 Right Headlight Lens 29 6 Volt Battery – 2 30 30 Amp Fuse – 2 31 Battery Retainer 32 Seatbelt Set 33 12 Volt Charger

Not Shown: Label Sheet

Parts

12-VOLT CHARGER

M T

First-Time 6 Volt Battery Charging

WARNING

• Batteries must be handled by adults only.

• Never allow children to charge the 6 volt batteries. Battery charging must be done by adults only. A child could be injured by the electricity involved in charging batteries.

• Use of the wrong type 6 volt battery, fuse or charger could cause a fire or explosion, resulting in serious injury.

• Never permit a child to handle batteries. The 6 volt batteries are heavy and contain sulfuric acid (electrolyte), and if dropped could result in a serious injury. Read the cautions on the back panels of the batteries.

• Never lift or carry the 6 volt batteries by the wires or connectors. This can damage the 6 volt batteries and possibly cause a fire. Lift and carry the 6 volt batteries by the cases only.

• Examine the 6 volt batteries, charger and their connectors for excessive wear or damage each time you charge the 6 volt batteries. If damage or excessive wear is detected, do not use the charger or the vehicle until you have replaced the worn or damaged part.

• Never alter this vehicle or its electrical system in any way. Alterations could cause a fire resulting in injury and could also ruin the electrical system.

CAUTION

• Do not operate the vehicle for the first time until you have inserted 30 amp fuses into the 6 volt batteries and charged them for at least 18 hours. Never charge the 6 volt batteries longer than 30 hours.

• Carefully read the Battery Care instructions to obtain the best battery life. Failure to follow the Battery Care instructions may permanently damage your 6 volt batteries and may void your warranty.

• Use the charger indoors only.

We recommend that you start charging your 6 volt batteries before beginning assembly of your vehicle. Your new 6 volt batteries must be charged for at least 18 hours before you use

your vehicle for the first time.

• Squeeze the Lock-In

connector tabs on the charger connector and plug it into the battery connector .

• Plug the charger into a standard 120 volt wall outlet.

Note: If power flow to the wall outlet is controlled by a switch, make sure the switch is “ON”.

• Before first time use, charge the

6 volt batteries for at least 18 hours. Never charge the 6 volt batteries longer than 30 hours.

Note: The 6 volt batteries must be upright while charging.

Battery Connector

Charger Connector

Lock-In

Connector Tabs

First-Time 6 Volt Battery Charging

• Insert a 30 amp fuse into each 6 volt battery.

Note: The top of the fuse will not be flush with the top of the 6 volt battery when properly installed.

• Stack one battery connector on top of the other and snap them together.

Fuse

Battery Connectors

Charger

E P

S U

P O R

Assembly

Do Not Omit Any Steps. Please set aside at least 45 minutes for assembly.

• Locate the sound box battery compartment.

• Loosen the screw in the battery compartment door with a Phillips screwdriver. The screw will remain in the door.

• Lift the battery compartment door open.

• Insert three size LR6 “AA” alkaline batteries into the battery compartment as indicated on the battery compartment door.

• Close the battery compartment door .

• Tighten the screw with a Phillips screwdriver. Do not over-tighten.

• Place the sound box into the dash pocket in the vehicle body, speaker side down.

Battery Compartment

Battery Compartment Door

IMPORTANT NOTES:

• Do not mix old and new batteries.

• Do not mix different types of batteries: alkaline, standard (carbon-zinc) or rechargeable (nickel-cadmium).

• Remove batteries during long periods of non-use. Always remove exhausted batteries from the product. Battery leakage and corrosion can damage the product.

• Never short circuit the battery terminals.

• Non-rechargeable batteries are not to be recharged.

• Only batteries of the same or equivalent type as recommended in the battery installation instructions are to be used.

• If removeable rechargeable batteries are used, they are only to be charged under adult supervision.

• Rechargeable batteries are to be removed from the product before they are charged.

• Battery chargers used with the product must be examined regularly for damage to the cord, plug, enclosure and other parts. In the event that such damage is found, the product must not be used with the battery charger until the damage has been repaired.

Sound Box

Speaker Side

Dash Pocket

SHOWN ACTUAL SIZE

LR6 “AA”

1.5 x 3

• Insert the tabs on the sound box cover into the slots in the dash near the sound box.

• Lower the bottom of the sound box cover.

• Insert two #6 x 1/2" screws through the sound box cover and into the dash.

• Tighten the screws with a Phillips screwdriver. Do not over-tighten.

Assembly

#6 x 1/2" Screw – 2

Shown Actual Size

• Position the sound box cover as shown. Make sure the three tabs are at the top.

• Fit the knob into the hole in the right side of the sound box cover.

• Fit the key into the hole to the left of the knob.

• Insert a #6 x 3/8" screw into the back of the knob and into the back of the key.

• Tighten the screws with a Phillips screwdriver. Do not over-tighten.

Knob

#6 x 3/8" Screw – 2

Shown Actual Size

Tabs

Key

Sound Box Cover

Tabs

Slots

Sound Box Cover

Sound Box

• Fit the curved end of the steering column into the hole in the front axle.

Please Note: You may need to straighten the vehicle tires and rotate the steering column to fit it into the hole in the front axle.

Steering Column

Slot

Front Axle

Assembly

Helpful Hint: You may want the help of another person to complete assembly steps 6 through 9.

• Wipe the steering column with a paper towel to remove any excess lubricant.

• Carefully lift the front end of the vehicle.

• Insert the straight end of the steering column under the front axle, through the slot in the vehicle body and out through the large hole in the center of the dash.

Steering Column

Hole

Front Axle

“T” End

Hole

• Bend the end of the microphone cord so that it forms a “T”.

• Insert the end of the microphone cord through the hole in the right side of the dash.

• Gently pull on the microphone cord to make sure it is secure in the dash.

• Fit the tab on the back of the microphone into the slot in the dash to secure the microphone.

Microphone

Tab

Slot

Bottom View

Assembly

• Hold the steering column in place and gently lower the vehicle body.

• Position the steering wheel so that the spokes form a “Y” as shown.

• While supporting the steering column, fit the steering wheel onto the steering column.

• Fit a cap nut onto the end of the steering column.

• Tap the cap nut with a hammer to secure it on the steering column.

“UP”

Steering Wheel

Cap Nut

• Align the tab on the steering wheel cap with the slot in the center of the steering wheel.

• Fit the steering wheel cap into the center of the steering wheel.

• Insert two #8 x 1" screws into the steering wheel cap.

• Tighten the screws with a Phillips screwdriver. Do not over-tighten.

Steering Wheel Cap

#8 x 1" Screw – 2

Shown Actual Size

Steering Column

• Fit a cap nut onto the end of the steering column.

• While supporting the steering column, tap the cap nut with a hammer to secure it on the steering column.

Front Axle

Cap Nut

Bottom View

+ 30 hidden pages

Fisher-Price 74420 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual