Page 1
ASSEMBLY INSTRUCTIONS
ITEM 61491, CAST ALUMINUM BENCH
Table of Contents:
General Information...................Page 2
Safety Information……………………Page 2
Preparation................................Page 2
Parts List…………………………………..Page 3
Assembly………………………………….Page 4
Warranty Information………………Page 5
**IMPORTANT NOTICE**
Do NOT return to place of purchase. For customer
Service and warranty issues, please contact our
TOLL FREE HOTLINE: 866-985-7877 or Email: cservice@welltraveled.net.
Hotline hours: Mon – Fri, 9AM to 6PM, EST
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
1
Page 2
ITEM 61491, CAST ALUMINUM BENCH
GENERAL INFORMATION:
Your new bench is made from the finest materials available. It should provide many
years of enjoyment with minimal care.
Keep your bench clean and apply a coat of wax a few times a year. For best results,
clean the bench with warm soapy water and use an outdoor furniture wax. If you use
furniture covers, always make sure the bench is clean and completely dry before
covering as mold may form in dark, wet places. Check the bolts on your bench regularly
to make sure they are tight.
To provide a rust free product this bench is made of Cast Aluminum which is a relatively
soft material. Be careful not to over tighten your hardware. Stripped hardware is not
covered under the manufacturer's warranty. The weight limit for this bench is 225 lbs.
SAFETY INFORMATION:
WARNING
DO NOT stand or allow children to stand on the assembled product.
DO NOT tighten bolts completely until instructed to do so. After final alignment, make
sure all nuts and bolts are securely fastened.
NEVER use a power tool to assemble or tighten your furniture. Perform periodic checks
to make sure the hardware is secure and tighten if needed.
CAUTION
READ all instruction before beginning assembly. Failure to do so may result in faulty
assembly and potential injury. Assemble the item on a soft, non-abrasive surface such as
a carpet or cardboard to avoid damaging the item.
PREPARATION
Before beginning assembly, make sure all parts are present. Compare parts received
with the "Parts List." If any part is missing or damaged, do NOT attempt to assemble the
product. Contact our Customer Service Hotline toll-free at 1-866-985-7877, Mon – Fri,
9AM to 6PM, EST.
2
Page 3
Item
Picture
Description
Qty
Item
Picture
Description
Qty
A
Backrest
Panel
1
G
Washer
(8mm)
8
B
Chair Seat
Panel
1
H
Spring
Washer
(8mm)
8
C
Right Arm
1
I
Nut (8mm)
8
D
Left Arm
1
J
Rubber Cap
(pre-installed)
4
E
Bolt
(8*15mm)
4
K
Wrench
1
F
Bolt
(8*30mm)
4
L
Allen
Wrench
1
ITEM 61491, CAST ALUMINUM BENCH
PARTS LIST
3
Page 4
ITEM 61491, CAST ALUMINUM BENCH
ASSEMBLY
1. Place all parts on a clean, soft, level surface.
2. Attach the Backrest Panel (A) to the Right Arm (C) and Left Arm (D) with
4 - pcs. 8*15mm Bolts (E), 4 - pcs. 8mm Washers (G), 4 - pcs. 8mm Spring
Washers (H, and 4 - pcs. 8mm Nuts (I). Attach the Chair Seat Panel (B) to the
Right Arm (C) and Left Arm (D) with 4 - pcs. 8*30mm Bolts (F), 4 - pcs. 8mm
Washers (G), 4 - pcs. 8mm Spring washers(H), and 4 -pcs. 8mm Nuts (I):
3. Tighten nuts using Wrench. DO NOT OVER TIGHTEN.
4. Adjust the pre-installed Rubber Caps until the bench is level with the ground.
Your bench is now ready for use!
4
Page 5
Distributed By:
Well Traveled Living
716 S 8th Street
Amelia Island, FL 32034
Toll Free: 866-WTL-SUPP
Web: www.wtliving.com
Email: cservice@welltraveled.net
***IMPORTANT NOTICE***
-Do NOT return to place of purchase-
For customer service and warranty issues
contact our Customer Service Center at:
(866)-985-7877 OR
Email: cservice@welltraveled.net
Customer Service Hours: Mon. – Fri. 9:00 a.m. – 6:00 p.m. (EST)
Fire Sense®, Patio Sense®, Mojave Sun ®, and Well Traveled Living® are registered trademarks of Well Traveled Imports, Inc®. All assembly instruction
presentations are the property of Well Traveled Imports, Inc.® and are protected by U.S. copyrights and trademarks. All rights reserved.
5 YEAR LIMITED WARRANTY – Customers in the Continental US
All components are warranted for a period of 5 years after date of purchase by the original owner against
defects in materials and workmanship under normal use. This warranty does NOT cover normal wear and
weathering, assembly and/or maintenance OR use in a commercial application if model is not designated
as a commercial model. At Well Traveled Living’s sole discretion, products under warranty will be repaired
and/or replaced at no charge to the customer. Any returns sent back to Well Traveled Living must be sent
via prepaid freight and in the original retail packaging.
For warranty service contact Well Traveled Living at the address, phone numbers or internet site and
email listed in this owner’s manual. Be sure to have your sales receipt, date of purchase and
catalogue/model numbers available when calling. All warranty service will be coordinated by the Well
Traveled Living’s, Amelia Island, Florida service center.
This warranty is extended only to the original purchaser. Proof of purchase will be required before
warranty service is rendered. The sales receipt is the only valid proof of purchase. This warranty only
covers failures due to defects in materials or workmanship which occur during normal use. Failures and/or
damage which result from accident, negligence, misuse, abuse, neglect, mishandling, alteration or
modification, failure to maintain, improper assembly or maintenance, service by unauthorized agency or
use of unauthorized components or damage that is attributable to acts of God are NOT covered.
***THERE ARE NO EXPRESS WARRANTIES EXCEPT AS LISTED ABOVE***
***PURCHASER ASSUMES ALL RISKS IN THE ASSEMBLY AND OPERATION OF THIS UNIT***
***FAILURE TO FOLLOW WARNINGS AND OPERATIONAL INSTRUCTIONS CONTAINED IN THIS
MANUAL CAN RESULT IN SEVERE PROPERTY DAMAGE AND/OR PERSONAL INJURY***
IN NO EVENT WILL WELL TRAVELED LIVING, OR ITS DIRECTORS, OFFICERS OR AGENTS BE
LIABLE TO THE PURCHASER OR ANY THIRD PARTY, WHETHER IN CONTRACT, IN TORT, OR ON
ANY OTHER BASIS, FOR ANY INDIRECT, SPECIAL, PUNITIVE, EXEMPLARY, CONSEQUENTIAL,
OR INCIDENTAL LOSS, COST, OR DAMAGE ARISING OUT OF OR IN CONNECTION WITH THE
SALE, MAINTENANCE, USE, OR INABILITY TO USE THE PRODUCT, EVEN IF WELL TRAVELED
LIVING OR ITS DIRECTORS, OFFICERS OR AGENTS HAVE BEEN ADVISED OF THE POSSIBILITY
OF SUCH LOSSES, COSTS OR DAMAGES, OR IF SUCH LOSSES, COSTS, OR DAMAGES ARE
FORESEEABLE. IN NO EVENT WILL WELL TRAVELED LIVING, OR ITS OFFICERS, DIRECTORS,
OR AGENTS BE LIABLE FOR ANY DIRECT LOSSES, COSTS OR DAMAGES THAT EXCEED THE
PURCHASE PRICE OF THE PRODUCT.
SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR
CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO
THE PURCHASER.
This limited warranty gives you specific legal rights and you may also have other rights which vary from
jurisdiction to jurisdiction. The provisions of the United Nations Convention on Contracts for the Sales of
Goods shall not apply to this limited warranty or the sale of products covered by this limited warranty.
5
Loading...