Fire Magic 22SC01C61 User Manual

Front view of charcoal grill slide-in unit with Smoker hood and warming rack.
GOURMET STAINLESS STEEL
CHARCOAL GRILL w/ SMOKER HOOD
12 & 14 BUILT-IN SERIES
22 & 24 PORTABLE SERIES
COVERS MODEL NO.’S: 12-SCOXX-XA 22-SCOX-61 14-SCOXX-XA 24-SCOX-61 22-SCOXX-11
FOR YOUR SAFETY
1. Do not store or use gasoline, or other
fl ammable vapors and liquids, including propane cylinders, in the vicinity of this or any other appliance.
BRICK OPENING REQUIREMENTS
Front view of charcoal grill cart unit with Gourmet hood and warming rack.
12 SERIES: 19 3/4" depth, 26 1/4" width, 12" height 14 SERIES: 19 3/4" depth, 32 1/4" width, 12" height
WARNING
Built-in models must be installed in masonry or other type of fi reproof enclosure. The unit is not insulated and therefore must be installed with 18" of side and back clearance from unprotected
combustible materials such as wood, plastic or stucco with wood framing.
Do not install this unit under unprotected fl ammable surfaces. Do not install or use this appliance inside a building, garage, or any other covered area, including recreational vehicles or boats.
Carefully unpack your grill and check the parts. If you have purchased a slide-in, simply slide the unit into your grill opening. Next, fi t the crank handle into the hole on the front right side of the face. Aligning it carefully, screw it into the nut on the frame (see Fig. 1-1). After fi tting, crank the handle to ensure the charcoal lifter moves up and down freely.
Installing the crank handle
Align crank handle
ALIGN CRANK HANDLE WITH NUT & SCREW IN
with nut & screw in
Fig. 1-1
REV 2 - 0711071126
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue, City of Industry, California 91746
1
L-C2-18507
Warming Rack
Stabilizer Bar
Side Bracket (2)
Reinforcement Screws
Barbecue Slots (2)
Hanging Brackets (2)
WARNING
Improper installation, adjustment, alteration, service, or maintenance can cause injury or
property damage. Refer to this manual. For assistance or additional information, consult a
qualifi ed, professional installer, or service agency.
SMOKER HOOD
When it’s not protecting your Fire Magic greatly expand your grilling repertoire. Now you will be able to roast, bake, and smoke foods, adding the special fl avor and tenderness that only slow cooking in a closed oven can produce (see below for installation information).
Installation of your gourmet smoker hood on your Fire Magic® grill couldn’t be simpler. First, remove the cooking grids from the grill. Then place the oven in the grill without the grids, making sure that the left and right side brackets slide into the slots on both sides of the grill. Next insert the reinforcement screws into the bracket on either side of the grill to secure the smoker hood to the unit. Now place the rear portion of the warming rack into the warming rack hanging brackets and slide the stabilizer bar into the allotted space adjacent to the screws used to secure the unit. Finally replace the grids inside the oven. You’re done!
®
gas grill from the elements, your new smoker hood will
Fig. 2-1
Warming rack
Hanging brackets (2)
Stabilizer bar
Side bracket (2)
Grill slots (2)
Reinforcement screws
Maintenance of the gourmet stainless steel charcoal grill w/smoker hood is just as simple. Occasionally apply a few drops of light household oil to the hinges to keep them working smoothly.
®
Clean all surfaces with Fire Magic
foaming grill and grill cleaner or any household oven cleaner,
following the manufacturer’s instructions for porcelain or stainless steel. Never use acid chemicals to clean porcelain or glass surfaces.
For thorough cleaning, the oven handle assembly may be removed (see Fig. 2-2).
Fig. 2-2
For stainless steel restoration and finish maintenance, see the instructions enclosed with
Fire Magic® products for stainless steel.
REV 2 - 0711071126
2
L-C2-18507
USING THE GOURMET STAINLESS STEEL
CHARCOAL GRILL w/SMOKER HOOD
1. Remove the cooking grids and pile your charcoal on the charcoal pan(s). Avoid spillage.
2. Follow the instructions supplied with your charcoal/fuel for lighting.
3. Use the access door to add or spread out your coals while cooking.
4. Turning the crank handle raises or lowers the pan to increase or decrease the grilling heat as
you desire.
WARNING
All surfaces of the charcoal unit become HOT during use. Exercise caution when using this unit,
especially when adding charcoal or cranking the charcoal pan up or down.
EXHAUST REMOVAL
If installed under a patio roof, the grill area should be fully covered by a non-combustible chimney and exhaust hood. An exhaust fan with a rating of 1,000 CFM or more is necessary to effi ciently remove smoke and other cooking by-products from the covered area.
Installation in a fully covered area of any kind is not recommended.
REV 2 - 0711071126
3
L-C2-18507
FIRE MAGIC® STAINLESS-STEEL CHARCOAL GRILL LIMITED WARRANTY
FIVE-YEAR WARRANTY - Fire Magic® stainless steel charcoal grills (excluding the charcoal pan and ash tray) are warranted for fi ve
(5) years from the date of purchase of your Fire Magic
ONE-YEAR WARRANTY - Fire Magic your Fire Magic® charcoal grill.
PLEASE KEEP A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE
This warranty applies to the original purchaser and to single family residential use only. It commences from date of purchase, and is valid only with proof of purchase.
This warranty does not cover parts becoming defective through misuse, accidental damage, electrical damage, improper handling, storage, and/or installation. Product must be installed (and gas must be connected) as specifi ed in the instructions or operator’s manual, by a qualifi ed professional installer. Accessories, parts, valves, remotes, etc., when used must be Peterson Co. product.
This warranty does not apply to rust, corrosion, oxidation, or discoloration, unless the affected component becomes inoperable. It does not cover labor or labor-related charges.
This warranty specifi cally excludes liability for indirect, incidental, or consequential damages. Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above exclusion may not apply to you. This warranty gives you specifi ed legal rights, and you may have other rights that may vary from state to state.
For additional information regarding this warranty, or to place a warranty claim, contact the R.H. Peterson dealer where the product was purchased.
®
charcoal pan and ash trays are each warranted for one (1) year from the date of purchase of
®
charcoal grill.
ROBERT H. PETERSON CO.
Quality Check Date:___________
Orifi ce # (Main):__________ Orifi ce # (Other):__________ Model #: ___________
Model #: ___________ Serial #: ___________
Leak Test: ___________ Serial #: ___________
Inspector: ___________
Burn Test: ___________ Air Shutter: ___________ Gas Type: NAT. / PROPANE Inspector: ___________
Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746
4
Loading...