Page 1
Safety Data Sheet
Dust-Off Special Application Compressed Gas Duster
Section 1. Identification
Product Identifier
Dust-Off Special Application Compressed Gas Duster
Synonyms
DPN, DPNR, DPNJB, DPNRCN, DPNXL, DPNXL2, DPNXLCN
Manufacturer Stock
Numbers
N/A
Product Cas
811-97-2
Recommended use
Dust removal.
Prior to use, read all label instuctions and warnings.
Use only as
directed.
Uses advised against
Do not expose to temperatures above 120 degrees F (49 degrees C) as
overheating could cause can to burst.
DO NOT leave in direct sunlight or enclosed
vehicle.
Keep out of reach of children.
Intentional misuse by deliberately concentrating
and/or inhaling contents may be fatal.
Manufacturer Contact
Address
Falcon Safety Products, Inc.
25 ImClone Drive
Branchburg, NJ, 08876
USA
Phone
Emergency Phone
Fax
(908) 707-4900
(800) 498-7192
N/A
Section 2. Hazards Identification
Classification
GASES UNDER PRESSURE - Compressed gas
Signal Word
Warning
Pictogram
Hazard Statements
Contains gas under pressure; may explode if heated
Precautionary Statements
Page 1 of 6
Page 2
Occupational exposure limits, if available, are listed in Section 8.
Response
N/A
Prevention
N/A
Storage
Protect from sunlight. Store in a well-ventilated place.
Disposal
N/A
Ingredients of unknown
toxicity
0%
Hazards not Otherwise
Classified
Keep out of reach of children.
Intentional misuse by deliberately concentrating
and/or inhaling contents may be fatal.
Liquid contents may cause frostbite on
contact with skin, therefore, do not tilt, shake or turn can upside down before or
during use.
No Data Available
Section 3. Ingredients
CAS
Ingredient Name
Weight %
811-97-2
Ethane, 1,1,1,2-tetrafluoro
-
100 %
Section 4. First-Aid Measures
Eye
Immediately flush eyes with plenty of water for at least 15 minutes. Get immediate
medical attention.
Skin
For liquid contact, warm areas gradually by flushing with lukewarm water.
Do not
rub affected area,
If blistering occurs, apply a sterile dressing.
Seek medical
attention.
Inhalation
Remove to fresh air. If not breathing, give artificial respiration or give oxygen by
trained personnel. Seek immediate medical attention.
Ingestion
Is not considered a potential route of exposure.
Notes to Physician
Because of possible disturbances of cardiac rhythm catecholamine drugs, such as
epinephrine, which may be used in situations of emergency life support, should be
used with special caution.
Section 5. Fire Fighting Measures
Suitable Extinguishing
Media
This material is not flammable.
Use extinguishing measures that are appropriate to
local circumstances and the surrounding environment.
Unsuitable Extinguishing
Media
N/A
Fire fighting instructions
As in any fire, wear self-contained breathing apparatus pressure-demand,
MSHA/NIOSH (approved or equivalent) and full protective gear.
Additional Information
Hazardous decomposition products may include: Hydrogen Flouride, Carbonyl
flouride, Carbon Oxides.
Page 2 of 6
Page 3
Section 6. Accidental Release Measures
Clean-up
Stop release if it can be done safely.
Ventilate area using forced ventilation,
especially close to floor or ground. Evaporation occurs rapidly and vapors are
heavier than air and can collect in low lying areas.
Wear a self-contained breathing
apparatus and appropriate Personal protection. (See Exposure Controls/Personal
Protection section.)
Containment
Water spray may be useful in minimizing or dispersing vapors.
Safeguards (Personnel)
Evacuate personnel to safe areas.
Ventilate the area.
Refer to protective measures
listed in sections 7 and 8.
Section 7. Handling and Storage
Storage Temperature
Do not expose to temperatures above 120 degrees F (49 degrees C) as
overheating could cause can to burst.
DO NOT leave in direct sunlight or enclosed
vehicle.
Handling (Personnel)
Avoid breathing vapors or mist.
Avoid contact with skin, eyes and clothing.
Provide
sufficient air exchange and/or exhaust in work rooms.
For personal protection see
section 8.
Handle in accordance with good industrial hygiene and safety practice.
Section 8. Exposure Controls/Personal Protection
Occupational Exposure
Limits
Ingredient Name
ACGIH TLV
OSHA PEL
STEL
Ethane, 1,1,1,2-tetrafluoro
-
N/A
N/A
N/A
Personal Protective
Equipment
N/A
Skin and body protection
As required by employer code.
If there is risk of skin contact, wear protective
clothing, gloves, etc.
Direct contact with liquid can cause frostbite.
Eye-Face Protection
As required by employer code.
If there is a risk of contact with the eyes or face,
wear safety glasses with side shields.
Engineering Controls
Use with adequate ventilation.
Keep container tightly closed.
Respirators
If respiratory protection is required (large relase, clean-up) wear NIOSH approved
protection as appropriate.
Page 3 of 6
Page 4
Section 9. Physical and Chemical Properties
Physical State
Gas
Color
Clear
Odor
Slight
Ethereal
Odor Threshold
No data
Solubility
Slightly
Partition coefficient Water/n-octanol
N/A
VOC%
N/A
Viscosity
No Data
Specific Gravity
1.24
Density lbs/Gal
N/A
Pounds per Cubic Foot
N/A
Flash Point
None per
ASTM E681
FP Method
None per
ASTM E681
Ph
N/A
Melting Point
N/A
Boiling Point
-
15 degrees
F/-26.5C
Boiling Range
N/A
LEL
N/A
UEL
N/A
Evaporation Rate
>1(Ethyl
Ether=1.0)
Flammability
N/A
Decomposition Temperature
No Data
Auto-ignition Temperature
No Data
Vapor Pressure
70 PSIG @
70 degrees F
Vapor Density
3.5
Section 10. Stability and Reactivity
Stability
Stable under recommended storage conditions.
Conditions to Avoid
Aerosol containers are unstable at temperatures above 120 degrees F/49 degress
C.
Incompatible Materials
Alkali or Alkaline Earth Metals.
Powdered Metal. Powdered Metal Salts.
Hazardous Decomposition
Products
Carbon Oxides, Hydrogen Fluoride, Corbonyl Fluoride, Fluorocarbons
Conditions to Avoid
To avoid thermal decomposition, do not overheat.
Page 4 of 6
Page 5
Section 11. Toxicological Information
Component Analysis - LC50
Ethane, 1,1,1,2-tetrafluoro- Not Available
Component Analysis - Oral
LD50
Ethane, 1,1,1,2-tetrafluoro- Not available
Effects of Acute Exposure Eye
Contact with liquid may cause frostbite
Effects of Acute Exposure Inhalation
Excessive intentional inhalation may cause respiratory tract irritation and central
nervous system effect (headaches, dizziness).
Vapors may cause dizziness or
suffocation.
Sensitization
Non-hazardous by WHMIS/OSHA criteria.
Chronic Effects
Non-hazardous by WHMIS/OSHA Criteria
Mutagenicity
Non-hazardous by WHMIS/OSHA Criteria.
Reproductive Effects
Non-hazardous by WHMIS/OSHA Criteria.
Section 12. Ecological Information
Aquatic Toxicity
1,1,1,2-Tetrafluoroethane - 96h LC50:
Oncorhynchus (rainbow trout) 450mg/l
72 h
EC50: Algae > 118 mg/l 48 h EC50:
Daphnia magna (water flea) 980 mg/l
Section 13. Disposal
Waste Disposal Method
Comply with applicable Federal, State/Provincial, and Local Regulations.
Do not
pierce or burn, even after use.
Contaminated Packaging
Not Available
Section 14. Transport Information
UN Number
3159
UN Proper Shipping Name
1,1,1,2-Tetrafluoroethane
DOT Classification
2.2
Packing Group
N/A
Packaging Exceptions
ORM-D (applicable to containers up to 1L)
Transportation of Dangerous
Goods (TDG - Canada)
Proper Shipping Name: 1,1,1,2-Tetrafluoroethane
Hazard Class: 2.2
UN number:
3159 Packaging Exceptions:
Limited Quantity (containers up to 125ml)
IATA/ICAO ( Air)
Proper Shipping Name: 1,1,1,2-Tetrafluoroethane
Hazard Class:
2.2
UN number:
3159
Maximum net quantity packaging: 75 kg
IMO (Vessel)
Proper Shipping Name: 1,1,1,2-Tetrafluoroethane
Hazard Class: 2.2
UN Number:
3159
Page 5 of 6
Page 6
Section 15. Regulatory Information
TSCA
On the inventory, or in compliance with the inventory.
SARA 313 Regulated
Chemical(s)
This material does not contain any chemical components with known CAS
numbers that exceed the threshold (De Minimis) reporting levels established by
SARA Title III, Section 313.
US Federal Regulations
This product is a "Hazardous Chemical" as defined by the OSHA Hazard
Communication Standard, 29 CFR 1910.1200.
California Prop. 65
This product does not contain a chemical known to the State of California to cause
cancer, birth defects or other reproductive harm.
Canada Domestic
Substances List (DSL)
This product is listed on the DSL inventory list and complies with the inventory
requirements administered by the governing country.
WHMIS Status
Controlled
WHMIS Classification
Class A - Compressed Gas
Section 16. Other Information
Revision Date
5/18/2015
Disclaimer
Information contained herein was obtained from sources considered technically
accurate and reliable.
While every effort has been made to ensure full disclosure of
product hazards, in some cases data is not available and is so stated. Since
conditions of actual product use are beyond control of the supplier, it is assumed
that users of this material have been fully trained according to the requirements of
all applicable legislation and regulatory instruments.
No warranty, expressed or
implied, is made and supplier will not be liable for any losses, injuries or
consequential damages which may result from the use of or reliance on any
information contained in this document.
Prepared By
Falcon Safety Products, Inc.
908-707-4900
Page 6 of 6
Loading...