Fagor REVO-120, PREF-PACK6, DESCALING KIT 8 L, DESCALING KIT 12 L, DESCALING KIT 16 L Technical Information

Fagor Industrial

The best accessory
for our wide range of
dishwashers.

Find out more!

Access the website

407

Foodservice | Dishwashing

Dishwasher
accessories

Water treatment .................................... 409

Baskets .................................................. 411

Water connection:
It is advisable to introduce sanitary water in the dishwashers, with a temperatu­re of 50 - 60 ºC.

Water pressure:
Minimum: 2 bar = 2 kg/cm2
Maximum: 4 bar = 4 kg/cm

Water softener:
All glass / dishwashers should be connected to a treated water supply when the
local supply is over 10 HF / 6 HD.

Any issues derived from a bad installation that don´t meet with the indicated
conditions will not be considered as a warranty.

2

408

Accesories

Water treatment

What you can achieve with treatment of water

Fagor Industrial

Most of the water that comes out of the tap seems perfectly pure,
however it may contain, as already mentioned, invisible contaminants.

Removing these elements has a decisive inuence on water quality.

EXCELLENT WASH X

SAVING DETERGENTS X X

REDUCES GLASS

AND CERAMICS WEAR X

PROTECTS THE MACHINE X X

GOODBYE MANUAL DRYING X

Calcium and magnesium (hardness) are eliminated and the useful

life of the equipment is signicantly extended, reducing maintenance

interventions and the use of detergents and rinse aids.
Aspects that are anything but marginal in the Ho.Re.Ca.

SOFTNER REVERSE OSMOSIS

Water treatment methods

Water treatment occurs mainly in two ways.

SOFTNER
The result obtained by using the water softener is to eliminate the

calcium Ca2+ and magnesium Mg2+ ions, responsible for the hardness
of the water. This effectively prevents the formation of encrustations
which over time reduce the performance of the machines and cause
malfunctions.

REVERSE OSMOSIS

Thanks to the very high degree of ltration that characterizes reverse

osmosis machines, it is possible to obtain water with high quality
characteristics.Water, passing through one or more Membraness, is
deprived not only of the elements that determine its hardness, but also
of all substances contaminants, responsible, for example, for unwanted

odors and avors.

For excellent results and long maintenance intervals, the two
technologies can be combined.

409

Manual water softeners

For hardness bigger than 5 HF / 3 HD.
Manual maintenance required.

Foodservice | Dishwashing

CODE DESCRIPTION CAPACITY OF REGENERATION (*) DIMENSIONS

19004620 DESCALING KIT 8 L. 700 litres between 2 regenerations Ø 185x440 mm

19004690 DESCALING KIT 12 L. 1.050 litres between 2 regenerations Ø 185x560 mm

19004798 DESCALING KIT 16 L. 1.400 litres between 2 regenerations Ø 185x740 mm

(mm)

Reverse osmosis

GREAT ADVANTAGES OF REVERSE OSMOSIS:

- It reduces detergent use by up to 60% and rinse aid by 70-100%.

- It polishes plates, glasses and cutlery, obtaining a mark-free washing result since it does not require drying after the wash.

- It extends the life of glassware and dishes since it reduces corrosion.

- It protects the machinery, extending its life.

General characteristics

Inlet water conditions:

- Type of inlet water: drinking water.

- Inlet water temperature: 5 °C - 35 °C.

- Minimum ow: 400 l/h.

- Supply pressure: 1.5-6 bar.

- Maximum conductivity of inlet

water: 1200 μS / cm.

- Maximum inlet water hardness: up
to 35°f with pH below 8.5 and up to
27°f with pH above 8.5.

- As of 10°dH 15°dH or 27°f, we
recommend installing a water
softening system prior to
osmosis to prevent blockage of the
membrane.

- High-ow reverse osmosis system.

- Vertical or horizontal installation.

- Flow: 120 l/h at 15°C.

- Recovery rate from 25% to 60%.

- Typical rejection rate: 95 %.

- Electrical connection 230V ~
50/60Hz.

- Prelter that reduces and eliminates

water turbidity, chlorine, tastes and

smells. Its nominal ltration rate is 5

microns.

- Easy to install.

- Prelter change alarm.

- Water leak alarm.

- Low-pressure alarm at system
entrance.

- Manual bypass valve.

€

-

-

-

ONLY VALID FOR: AD-505, AD-125, COP-404, COP-504 y COP-144

MODEL CODE FLOW 15ºC

REVO-120 19076763 120 2 230 50 / 60 0,33 145 x 560 x 455

MODEL CODE DESCRIPTION

PREF-PACK6 19076764 Pack of 6 units of rapid-connection cartridges with extruded carbon block lter

(L/H)

NUMBER OF
MEMBRANES

VOLTAGE (V) FREQUENCY (HZ) POWER (KW) DIMENSIONS (mm)

410

€

-

€

-

Fagor Industrial

Baskets for dishes, trays and cutlery

Made of polypropylene.

CT-10

CP-16/18

CT-10 R

CB-7

CP-12

CT-10 + 16 CUCU

MODEL CODE TYPE OF BASKET Ø MAX

(mm)

CAPACITY
PRODUCT

COLOUR DIMENSIONS

(mm)

CT-10 19000484 Standard basket Dishes Grey 500x500x110

€

-

SMALL
BASKET 400

DISHES
ACCESSORY
400

SMALL
BASKET 350

DISHES
ACCESSORY
350

CT-10 R 19085091

19082432 Standard basket Dishes Grey 400x400x110

19084452 400x400x110

19082434 Standard basket Dishes Grey 350x350x110

19084453 350x350x110

Standard basket
with dense base

Dishes and cutlery Brown 500x500x110

CB-7 19000483 Trays for self-service - 7 Orange 500x500x110

CP-16/18 19000487 Dishes

CP-12 19004479 Deep dishes

Ø 230 16 ÷18 (*)
Ø 320 8 ÷ 9 (*)

Ø 230 12 (*)
Ø 320 6 (*)

CU 19000792 Cutlery - 15 (**) Yellow 105x105x130

Notes: (*) It depends of the position of the dishes in the basket.
(**) To guarantee a correct washing of the cutlery, it is not recommended to introduce more units.

411

Orange 500x500x110

Grey 500x500x140

-

-

-

-

-

-

-

-

-

Foodservice | Dishwashing

Baskets for glasses

Made of polypropylene.

Baskets for 16 glasses and cups ø 110 mm

MODEL CODE TYPE OF BASKET Ø MAX

(mm)

H MAX

(mm)

CAPACITY
PRODUCT

COLOUR DIMENSIONS

(mm)

CV-16/105 19000488 Low glasses 110 100 16 Blue 500x500x140

CV-16/155 19000489 Medium glasses 110 150 16 Blue 500x500x190

CV-16/205 19000490 High glasses 110 200 16 Blue 500x500x240

Baskets for 25 glasses and cups ø 85 mm

MODEL CODE TYPE OF BASKET Ø MAX

(mm)

CV-25/105 19000491 Low glasses 85 100 25 Blue 500x500x140

CV-25/155 19000492 Medium glasses 85 150 25 Blue 500x500x190

CV-25/205 19000493 High glasses 85 200 25 Blue 500x500x240

H MAX

(mm)

CAPACITY
PRODUCT

COLOUR DIMENSIONS

(mm)

€

-

-

-

€

-

-

-

Baskets for 36 glasses and cups ø 70 mm

MODEL CODE TYPE OF BASKET Ø MAX

(mm)

CV-36/105 19000494 Low glasses 70 100 36 Blue 500x500x140

CV-36/155 19000495 Medium glasses 70 150 36 Blue 500x500x190

CV-36/205 19000496 High glasses 70 200 36 Blue 500x500x240

H MAX

(mm)

412

CAPACITY
PRODUCT

COLOUR DIMENSIONS

(mm)

€

-

-

-