EZ 2810 Operator Instructions Manual

2810 Shower Panel

WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov.

Operator’s Instructions

EZ Way, Inc.
PO Box 89
Clarinda, IA 51632
1-800-627-8940
www.ezlifts.com

Form 2-326

Rev. 09/13/18

Table of Content

1. Introduction
2 Intended Use, Product description and Technical specification
3 Safety and control instructions
4 Installation Instructions
5 Features and Controls
6 Operating Procedures

6.1 Showering 9

6.2 Cleaning 10

6.3 Calibrating the cleaning to give a mix of approx. 2% 11

7 Options

7.1 Digital thermometer 12

7.2 Mechanical lock for cleaning liquid bottle 13

8 Routine Maintenance
9 Labels on the 2810
10 Maintenance record
11 Training record

3
4
5
5
8
9

12

14
15
16
17

2

1. Introduction

Dear Customer,
Thank you for choosing one of our quality products. We hope you enjoy the 2810 Shower panel.

This manual shall, in conjunction with staff training, ensure that the operator/user is always using and/or
operating the 2810 correctly.

The manufacturer requires that each user has read and understands the entire operating manual and that they
can apply the instructions as specified. This applies to anyone who was not present at the in-service.

This instruction manual should generally be kept easily accessible for every user. Copying the whole manual is
encouraged since its sole purpose is to improve the standard of training and safety.

Please order another copy from us if the instruction manual is lost or unusable, or if it has become illegible over
time.

If you require further information or have any questions please do not hesitate to contact EZ Way.

Please make sure you have read, understood and applied the information on the following pages.

3

2. Intended Use, Product Description and Technical Specifications

Intended use:

The 2810 l is a wall mounted Shower Panel.

The patient is typically a person who is unable to take care of their personal hygiene.

The user is any adult person who is capable of reading and understanding the operating manual and is qualified to
care for dependent persons/patients.

Before using the 2810, the user must read and understand the operating manual.

The 2810 is intended to be used in a showering area together with the EZ 1000 shower chair and EZ 2000, EZ 3000,
EZ 3200, EZ 4000 and EZ 4200 shower trolleys.

Technical Specification

Width 23"
Height
Depth 5"
Recommended mounting

height from floor
Min. Dynamic water

pressure
Max. Dynamic water

pressure

15"

49"

0,15 Bar

5 Bar

4

3. Safety and Control Instructions

The recommended maintenance procedures will
depend on the hardness of your water supply
and it is good practice to establish these routine
instructions on a weekly basis and then adjust the
frequency as your conditions indicate.

• Only qualified staff, who understand all

operating and safety procedures may operate the
Shower Panel.

• Always physically check water temperature

before and during showering and that the
thermoscopic mixer functions properly.

• Read the separate product manual for

calibrating the thermostat.

• Make sure that both valves (2 and 5) on the

front of the Panel are closed after each use.

• Make sure that the bottle (8) is filled with

concentrated cleaning detergent before
cleaning.

• Do not use solvent based cleaning liquids,

iodine based detergent, bromine or methylene
blue or a nonabrasive type cleaner.

• Do not use any cleaning detergent containing

more than 40 % of alcohol.

• After cleaning, rinse with fresh water.

• Clean the strainers on the patient and cleaning

shower heads in hot water and rub it with your
thumb.

• Make sure that hoses, controls, connections and

mixer are free from damages.

• Shower Panel should not be used if defects are

noticed. Prompt service is required.

4. Installation Instructions

Plumbing rough - In

All pipes, fittings, backflow preventors, vacuum
valves, shut-off valves and connections to panel
to be supplied and installed by others to comply
with local building and plumbing codes. The
manufacturer refers to the European standard EN

1717. To prevent backflow, any bathtub, toilet chair
or similar product may not be installed within reach
of the patient shower hose.

The patient shower system has a Rada 215-t3 oem
thermostat, a main valve on the panel front and a
shower handle without on/off trigger.

The Rada 215-t3 oem thermostat has built in filters
and check valves and is factory set to give maximum
38 degrees Celsius. The thermostat shall be installed
to R15 (½”) cold and hot water supply.

We refer to the enclosed Rada 215-t3 oem
thermostat product manual.

The yellow cleaning shower (for cleaning
equipment only) has a main safety valve on the
panel front and a cleaning handle without on/off
trigger.

The cleaning shower shall be installed to a R15
(1/2") cold water supply and if demanded, to a
separate “class A tank”.

The concentrated cleaning liquid is preset to give
about 2 % mixture in the cleaning shower and
the cleaning bottle shall be filled by the cap. See
operating manual.

To eliminate pipe debris it is essential that the hot
and cold supply pipes are thoroughly flushed before
connection to the shower panel.

Recommended mounting height from floor 47".

Important: this product manual is the property of
the customer and must be retained with the product
for maintenance and operational purposes.

5

Installation Instructions

6