Espressomat energy series, torino series, eccobar series, galaxy series Installation And Maintenance Manual

MANUAL FOR INSTALLATION AND MAINTENANCE

Espresso Coffee Machines: H-Series

Energy, Galaxy, Eccobar, Torino, etc

automation 4 espresso

GRUPO 1000 BARCELONA, S.L.U.
C/ Joan Torruella i Urpina 37, Nave 5
08758 Cervelló (Barcelona) - Spain

[e-mail]

Tel. [phone]

Linea Energy

Linea Torino

Linea Galaxy

Linea Venezia Linea Eccobar

INDEX

1- IMPORTANT WARNINGS

1.1.- Security advices

2- PRODUCT DESCRIPTION

2.1.- Product features

2.2.- Technical details

3- USER MANUAL

3.1.- Main components

3.2.- Preparation and start-up

3.3.- Preparation and coffee brewing

3.4.- Hot water spigot

3.5.- Steam wand

3.6.- Cleaning procedures

3.7.- Water softener (not included)

3.8.- Alarm signs

4- INSTRUCTIONS FOR THE TECHNICIAN

4.1.- Description of the internal components

4.2.- Positioning of the machine

4.3.- Connection to water net

4.4.- Connection to electrical net

4.5.- Security valve

4.6.- Vacuum valve

4.7.- Expansion valve

4.8.- Water level inside the boiler

4.9.- Internal insulation

5- PRODUCT CERTIFICATIONS

1- IMPORTANT WARNINGS

IMPORTANT:

Read carefully this instruction manual before you start-up the machine, as it contains important information

concerning the security of the installation, the use and the maintenance of the machine.

1.1.- Security advices

a) Keep this manual close from your working place, so you can take a look at it when necessary.

b) After unpacking the machine, verify all the accessories are there. Don’t let children have access to the

packing materials, such as cardboards, staples, etc. as they are compound of material that might
damage them.

c) Before you start the machine up verify that the electrical parameters indicated on the product label

correspond to those available in the local.

d) The installation of the machine must fulfill local security rules and must be carried out by a high qualified

technician, who at the same time must be authorized to do the job by the manufacturer.

e) The manufacturer will not accept any responsibility for personal and material damages or losses caused

by an incorrect installation of the machine.

f) Security of the machine can be only proven if it has been properly connected to a ground point, always

done accordingly with effect local rules (see paragraph 4.3).

g) It is very important that these basic security measures are always verified by a high qualified technician.

h) The manufacturer will not accept any responsibility for the losses caused by a deficient ground point or

for the absence of it. The machine comes perfectly equipped with a proper ground, and all the ground
points are indicated in the device.

i) Verify that the admissible intensity of the electrical installation is enough for the maximum power of the

machine, which is always indicated on the product label. In case of doubt, get in contact with a high
qualified technician to check if the cable section is enough for the intensity consumption of the machine
when working at its maximum power regime.

j) The way the machine is connected to the electrical net is already set-up. Adaptors should not be used.

k) In case to use extension cords, these must fulfill local security rules, paying special attention to not

overtake its admissible maximum intensity.

l) This machine must be used only for the purpose it was bought for, i.e. the preparation of coffee drinks,

as well as obtaining hot water and steam to heat up milk, shakes or cold water. Any other use must be
considered not appropriate and so could be dangerous. The manufacturer will not accept any
responsibility for possible personal and material damages or losses caused by an inappropriate use of
the machine.

m) Noise level average is under 70 dB, so as this matter is concerned, the machine does not represent a

problem at all for end users. In the contrary, please get in touch with the technician or the manufacturer.

n) When using the machine, some fundamental security rules must be followed:

- Don’t touch the machine with wet wet or humid feet/ hands.

- Don’t use the machine in case you go barefooted.

- Don’t install the machine in places where the cleaning is ade using water streams/jets.

- Don’t pull the electrical cable when disconnecting the machine from the electrical installation.

- Don’t permit the machine to be exposed to climate agents such as rain, ice, sand, etc.

- Don’t expose the machine to extreme temperatures. It can work on the exterior (terraces, etc.) but the
maximum air temperature should not exceed the 50ºC (122ºF) and the minimum should not be lower
than 0ºC (32ºF). Don’t let temperatures lower than 0ºC (32ºF) be in touch with the machine without
emptying first the boiler and pipes of water.

- Don’t let any person use the machine if they have not read carefully the user’s manual before.

- Don’t let people who might have reduced physical, sensorial or mental capacities, or have no
experience with this kind of equipment, use the machine, except in case they have a guidance or
supervision from another person who is responsible or has the right knowledge about the machine and
its security rules.

- Moreover, don’t let children under 8 years old use or manipulate the machine.

- Children over 8 years old, people with reduced physical, sensorial or mental capacities and those that
have no experience with this kind of equipment, will only be able to use the machine in case they have
received a proper training or have the supervision and guidance of a responsible person who has the
right knowledge about the machine and its security rules, so they can understand how dangerous a
machine can be for them.

- Moreover, children must be always supervised to make sure they don’t play with the machine or do any
job in relation to maintenance or cleaning procedures.

- Don’t remove the side panels of the machine to start any maintenance or service operation. Only high
qualified and authorized technician can remove the panels and do the job inside the machine.