Elkay VRCGRNTL8C User Manual

®

SPECIFICATIONS

energy & water efficient

GENERAL

GreenSpec®Listed, energy and water efficient model. Selfcontained, double wall hung electric, refrigerated water cooler. Vandal-resistant unit for use in high demand locations. Flow regulator provides constant stream from 20 to 105 psi water pressure. Rated for indoor and outdoor use.

ADA COMPLIANT

These Water Coolers comply with the requirements of A.D.A. (Americans with Disabilities Act) when properly installed. Also meets the guidelines for children’s environments providing the floor to orifice height is 30" or less and proper clear floor space is provided for parallel approach. (Based on Architectural and Transportation Barriers Compliance Board final ruling.) Check Local and State Codes.

NO LEAD DESIGN

These Water Coolers are certified to be lead-free as defined by the Safe Drinking Water Act. Elkay Water Coolers are manufactured with a waterway system utilizing copper components and completely lead-free materials. These waterways have no lead because all lead materials, such as leaded brass, have been removed. All joints are brazed using silver solder only. No lead solder is permitted. A strainer with an easily cleanable screen is provided to allow trapping and convenient removal of waterborne particulate of 140 microns and larger prior to their entry into the water cooler.

CAPACITIES CHART

**GPH of 50°F

Drinking Water

Room Temperature °F

Model Volt./ Base 70°F 80°F 90°F Rated Load Glass Wt.

Number Hertz Rate (21°C) (27°C) (32°C) Watts Amps Filler Lbs.

VRCGRNTL8C

LVRCGRNTL8FC

**Based on 80°F (27°C) inlet water temperature. Rated watts shown are based on operational (run) time, in accordance with A.R.I.

Standard 1010 conditions. Specific applications will determine the actual watts consumed per hour. Watts consumed will be based on number of people served per hour (usage), ambient temperatures, and inlet water temperature.

1150V/

8.0 9.7 8.8 8.0 260 2.8 – 94

60Hz

1150V/

8.0 9.7 8.8 8.0 260 2.8 Included 98

60Hz

ENERGY-EFFICIENT COOLING SYSTEM

Motor Compressor: High-efficiency, hermetically sealed, reciprocating type, 115 Volt/60 Hz, single phase. Sealed-in lifetime oil supply. Equipped with electric cord and three prong molded rubber plug.

Condenser: Fan cooled, copper tube with aluminum fins. Fan motor is permanently lubricated.

Cooling Unit: Combination tube-tank type. Designed for optimized heat transfer within the evaporator. Fully insulated.

Refrigerant Control: Refrigerant HFC-134a is controlled by accurately calibrated capillary tube for positively trouble-free operation.

Temperature Control: Enclosed adjustable thermostat is factory preset. Requires no adjustment other than for altitude requirements. Easily accessible.

Full Filter/ Ship.

GreenSpec®Listed, High Efficiency

Two Station Wall Mount Water Cooler

Vandal-Resistant, Barrier-Free Access

Model VRCGRNTL8C

CONSTRUCTION

Frame: Galvanized structural steel chassis supports fountain top and cabinet panels.

Fountain Top: Series 300 one piece stainless steel top, polished to a uniform Elkay bright luster finish. Basin has embossed bubbler pad.

Bubbler: Water-efficient, heavy-duty, vandal-resistant bubbler in one-piece construction. Keyed into position to prevent rotation. Meets UL requirements and all sanitary codes.

Cabinet: Cabinet design allows for flush to wall mounting. No recess space is required. Includes bottom cover plate fastened with vandal-resistant screws.

Color Selection: Stainless steel furnished as standard. Protected by Elkay’s 5 Year Limited Warranty on the refrig-

eration system of the unit. Elkay Pressure-Type Water Coolers are designed to operate

on 20 psi (138 KPa) to 105 psi (724 KPa) supply line pressure. If inlet pressure is above 105 psi (724 KPa), a pressure regulator must be installed in the supply line. Any damage caused by reason of connecting this product to supply line pressures lower than 20 psi (138 KPa) or higher than 105 psi (724 KPa) is not covered by the warranty.

STANDARDS

Elkay Electric Air Cooled Water Coolers are listed by Underwriters Laboratories Inc. and comply with both Canadian and U.S. requirements.

These units comply with A.R.I. Standard 1010.

This cooler is certified by WQA to lead-free compliance including NSF/ANSI 61-ANNEX G, AB 1953.

In keeping with our policy of continuing product improvement, Elkay reserves the right to change product specifications without notice. Please visit elkayusa.com for most current version of Elkay

product specification sheets.

Elkay

elkay.com

2222 Camden Court Oak Brook, IL 60523

This specification describes an Elkay product with design, quality and functional benefits to the user. When making a comparison of other producers’ offerings, be certain these features are not overlooked.

(Rev. 10/15) 12-57c

G r e e nS pec®L is ted, H igh E fficienc y

OPERATION OF QUICK CONNECT FITTINGS

SIMPLY PUSH IN

TUBE TO ATTACH TUBE IS SECURED

IN POSITION PUSH IN COLLET

TO RELEASE TUBE

PUSHING TUBE IN BEFORE

PULLING IT OUT HELPS TO

RELEASE TUBE

OP ER ATION OF QU ICK CONNEC T FITTING S

(NOT FURNISHED)

HANGER BRACKET

(173mm)

REDUCE HEIGHT BY 3" FOR INSTALLATION OF CHILDRENS ADACOOLER

18-1/16"

Two S ta ti on Wa ll M o u nt Wa ter C o oler Va nd a l - R e s is ta n t, B a rrier- F ree Ac c es s M odel V R C GR NT L8 C

R O U G H - I N D I M E N S I O N S

1/4" O.D. TUBE WATE R INL ET TO COOLER

NOTE: W ATE R FLO W

SIMPLY PUSH IN

TUBE TO A TTAC H

A B

* ADAREQUIREMENT F = 7/16" BOLT HOLES FOR FASTENING UNIT TO WALL. E = INSURE PROPER VENTILATION BY MAINTAINING 6" (152mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL. D = ELECTRICAL SUPPLY (3) WIRE RECESSED BOX. C = 1-1/2" TRAP NOT FURNISHED B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/2" O.D. DRAIN. 3” (76mm) MAXIMUM OUT FROM WALL. A = RECOMMENDED WATER SUPPLY LOCATION. SHUT OFF VALVE (NOT FURNISHED) TO ACCEPT 3/8" O.D. UNPLATED COPPER TUBE. LEGEND

FINISHED FLOOR (127mm) 5" (511mm)

(313mm) (114mm) 20-1/8"

(351mm)

12-5/16"

(686mm)

4-1/2" (518mm)

(254mm)5"(127mm)

13-7/8"

27"* (89mm) 20-3/8"

10" 3-1/2" B

(476mm) (638mm)

6-3/4" 18-3/4" 25-1/8"

(121mm)

(62mm)

HEIGHT

4-3/4" 2-7/16"

ORIFICE (952mm)

(837mm) 37-1/2"

32-15/16"

C (38mm) 1-1/2"

HEIGHT

(203mm)

RIM

(810mm)

31-7/8"

HEIGHT

ORIFICE (166mm)

(1003mm) 6-1/2"

39-1/2" (35mm)

(35mm) 1-3/8"

1-3/8" (146mm)

(146mm)

(10 HOLES)

(67mm) 5-3/4"

5/16" (8mm)

5-3/4"

2-5/8" (35mm)

(35mm) 1-3/8"

1-3/8" (146mm) (146mm)

(473mm) 5-3/4" 5-3/4"

18-5/8" (459mm) 18-1/16"

5/16" (8mm)

(10 HOLES)

6-1/2"

(166mm)

37-1/2"

(952mm)

20-3/8"

(518mm)

3/8" O.D. TUBE CONNECT COLD W AT ER S UP PLY

DIRECTION

TUBE IS SECURED

IN POSITION

5-3/4"

(146mm)

(127mm)

FINISHED FLOOR

SERVICE STOP

PUSH IN COLLET

TO RELEASE TUBE

PUSHING TUBE IN BEFORE PULLING IT OUT HELPS TO

RELEASE TUBE

1-3/8"

(35mm)

2-7/16"

(62mm)

10"

(254mm)

INS TAL LE R PL EAS E NO TE :

BUILDING W ATE R

INLET

TH IS WATE R C OO LE R H AS B EE N D ES IGN ED AN D B UILT T O P RO VIDE W ATE R TO T HE US E R

IMP OR TANT

WH IC H H AS N OT B E EN ALTE R E D BY MAT ER IA LS IN T HE C O OL ER WAT ER WAY S . TH E G RO UND ING O F EL EC TR IC AL E QU IPM EN T S U CH AS T EL EP HO NE, C OM PU TE RS , E TC . T O WATE R L INE S IS A CO MMO N P RO CE DU RE . T HIS G RO UNDI NG MAY BE IN T HE BU ILDING B UT M AY AL S O OC C UR AWAY F R OM T HE B U ILD ING . THIS GR O UN DING C AN C E LE C TR IC AL FEE DB AC K IN TO A WATE R C O OLE R C R E ATI NG A N EL ECT R OLY SIS W HI CH C RE ATE S A ME TALLIC TA ST E OR C AU SE S AN INCR EASE IN T HE M ETAL C ONT EN T O F T HE WATE R . T HIS C ON DITION IS AVO IDAB LE B Y IN STA LLIN G TH E C OOL ER U SING T HE P ROPE R MATE R IALS AS S HOW N B E LOW.

NO TIC E TH IS WATE R C OOL ER MU ST B E C ONN EC TE D TO T HE WATE R S UP PLY USIN G A DIE LE CT R IC C OUP LIN G. T HE C OOL ER IS F UR NIS HE D W ITH A N ON- ME TALLIC S TR AIN ER W HIC H TH IS R E QUIR E MENT. TH E DR AIN T RAP WHI CH IS P RO VIDE D BY THE INS TALL ER SHOU LD AL SO B E PL AS TIC TO C OM PLETELY IS OL AT E TH E CO OLE R FR OM T HE B UILD ING P LUM BIN G SY S TE M.

MIN IMUM 40 P SI SU PP LY LINE P R ES S UR E RE QU IRE D IN S P EC IAL C IRC UM STA NC ES W HEN B OT H S IDE S OF BIL EV EL AR E IN U SE S IMU LTANEOU S LY TO ENSU RE AD EQU ATE S TR E AM H EIG HT. DOE S NO T A PP LY TO NON -R EF RIG E RATE D UNIT S.

1-1/2"

(38mm)

(459mm)

5-3/4"

(146mm)

(127mm)

5-3/4"

(146mm)

1-3/8"

(35mm)

1-3/8"

(35mm)

3-1/2"

(89mm)

4-1/2"

(114mm)

5-3/4"

(146mm)

18-3/4"

(476mm)

13-7/8"

(351mm)

20-1/8"

(511mm)

(638mm)

HANGER BRACKET

39-1/2"

(1003mm)

ORIFICE HEIGHT

25-1/8"

HEIGHT

32-15/16"

(837mm)

ORIFICE HEIGHT

31-7/8"

(810mm)

*REDUCE HEIGHT BY 3" FOR INSTALLATION OF CHILDRENS ADA COOLER

2-5/8"

(67mm)

RIM

* "72

(686mm)

(203mm)

4-3/4"

(121mm)

18-5/8"

(473mm)

12-5/16" (313mm)

AU S E

ME ET S

6-3/4"

(173mm)

LEGEND A = RECOMMENDED WATER SUPPLY LOCATION. SHUT OFF VALVE (NOT FURNISHED) TO ACCEPT 3/8" O.D. UNPLATED COPPER TUBE.

3” (76mm) MAXIMUM OUT FROM WALL. B = RECOMMENDED LOCATION FOR WASTE OUTLET 1-1/2" O.D. DRAIN. C = 1- 1/2" TRAP NOT FURNISHED D = ELECTRICAL SUPPLY (3) WIRE RECESSED BOX. E = INSURE PROPER VENTILATION BY MAINTAINING 6" (152mm) (MIN.) CLEARANCE FROM CABINET LOUVERS TO WALL. F = 7/16" BOLT HOLES FOR FASTENING UN

ADA REQUIREMENT

E lkay

12-57C

IT TO WALL.

2222 Camden Court Oa k Brook, IL 60523