Elkay SWU1517BI, SWU1515WH Installation manual
COUNTERTOP
UNDERLAYMENT
CABINET
SINK
1/4"
SILICONE CAULK
(NOT FURNISHED)
Installation Instructions
FRAMING MUST
SUPPORT SINK
BOWLS
Elkay Fireclay
Undermount Sinks
CAREFULLY READ THESE INSTRUCTIONS BEFORE YOU BEGIN
ATTENTION INSTALLER
• ELKAY recommends that Fireclay sinks should be installed by a professional experienced installer.
• Before installation, please inspect the sink for damage. Do not install a damaged sink.
• WARNING: Due to the dimensional variation inherent in the fireclay manufacturing process, sink cutout
templates are not provided. Elkay recommends using the actual sink for the countertop cutout. It is recommended that you discuss with your customer the desired finished appearance of the sink and countertop
installation. Elkay is not responsible for improper sink and/or countertop installations.
• It is recommended that you discuss with your customer and agree to what the finished effect will be. Elkay
is not responsible for improper sink or countertop installations.
• Elkay Fireclay undermounts must be fastened to solid surface countertops only (i.e., granite).
• Elkay is not responsible for sink and countertop if damaged during installation.
• Fireclay sinks are heavy, please arrange for assistance to move or position.
• Follow all local plumbing and building codes.
Fireclay Farmhouse Apron Undermount Sink Only
• A custom sink base cabinet is required.
• Proper installation requires a coordinated effort including advanced dialog between the designer (or
• Elkay recommends providing the cabinet maker with the actual sink to be installed prior to cabinet fabrication.
• It is required that a support frame be constructed inside the cabinet for adequate support of the sink as
• Warning: The support frame and proper support for the sink must sufficiently support 300 lbs. This is the
• Templates are not included however it is recommended that the sink countertop cutout provide a reveal into
customer), the cabinet maker, the countertop fabricator and the sink installer during the design and installation phase.
shown in Figure 1.
approximate weight of the sink when full.
the sink bowl opening as shown in Figure 2.
FIGURE 1
FIGURE 2
COUNTERTOP
UNDERLAYMENT
CABINET
SINK
1/8" OVERHANG
RECOMMENDED
SILICONE CAULK
(NOT FURNISHED)
Installation Instructions
Fireclay Undermount Sinks
• Elkay recommends providing the cabinet maker
with the actual sink to be installed prior to cabinet
fabrication.
• It is required that a support frame be constructed
inside the cabinet for adequate support of the sink
as shown in Figure 1.
• Warning: The support frame and proper support for
the sink must sufficiently support 300 lbs. This is
the approximate weight of a sink when full.
• Templates are not included however it is recommended that the sink countertop cutout provide a
1
/8" overhang into the sink bowl opening as shown
in Figure 3. Do not reduce this1/8" dimension since
the bowl shape and overall size will have dimensional variation.
Care and Cleaning Guide
Elkay Fireclay was created for a lifetime of easy care.
Just follow the simple guidelines listed below.
Routine Care
Most dirt & stains:
Use soapy water or vinegar-based cleaner and a
sponge and towel dry.
Water marks:
Wipe with damp cloth and towel dry.
Difficult Stains:
50/50 water/bleach solution or non-abrasive cleaners.
Follow cleaning manufacturer’s instructions, rinse
thoroughly and towel dry.
FIGURE 3
Preventing Damage
Avoid exposing Elkay Fireclay to strong chemicals,
such as paint removers, oven cleaners, etc. If contact
occurs, quickly flush the surface with water. Do not use
a straight or undiluted bleach solution.
Do not set hot pans directly into sinks
Run cold water when pouring boiling water into sinks.
Do not use any abrasive cleaning products, scouring
pads or steel wool.
Do not use caustic solutions containing ammonia or
alkalis.
Elkay warrants to the original purchaser of an Elkay Fireclay sink that Elkay
will, at its option, replace or repair, without charge, such product if it fails due
to a manufacturing defect for a period of 1 year of normal residential use.
Product replacement does not include transportation cost or labor installation cost. This warranty covers only Fireclay undermount sinks installed in a
conventional solid surface countertop and applies to residential installations
only. Elkay reserves the right to examine product in question and its installation prior to replacement.
WASTE FITTINGS AND ACCESSORIES ARE NOT WARRANTED
This warranty applies to sinks purchased after April 1st 2008 as shown on
the purchaser’s dated receipt. Our warranty does not cover product failure
or damage caused by the use of optional Elkay accessories, abusive treatment, misuse, environmental factors, normal wear including surface dulling
and scratches, improper care and cleaning, use of aggressive and abrasive
cleaners, damage due to handling or failure to follow the recommended procedures for installation, care and maintenance as detailed in the installation
and care guide provided with every sink. This warranty is extended only to the
original consumer purchaser of the product. This warranty does not cover
shipping costs, labor costs, or any other charges for such items as installation or replacement of the sink, diagnosis or replacement of any faucet or
component part, or any other expense or loss.
Elkay
2222 Camden Court
Oak Brook, IL 60523
ELKAY LIMITED FIRECLAY SINK WARRANTY
OTHER WARRANTY CONDITIONS ON SINKS
©2008 Elkay
Printed in U.S.A.
elkayusa.com
All incidental or consequential damages are specifically excluded. No
additional warranties, express or implied are given, including but not
limited to, any implied warranty of merchantability or fitness for a particular purpose.
Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations on how long an implied warranty lasts, so the
above limitations or exclusions may not apply to you.
This warranty gives you specific legal rights, and you may also have other
rights which vary from state to state.
TO OBTAIN SERVICE UNDER WARRANTY
1. Write to: Elkay Manufacturing Company
Attention: Consumer Services
2222 Camden Court
Oak Brook, IL 60523
2. Include a letter containing the following information:
a. Date of purchase and installation
b. Proof of Purchase (copy of original dated invoice)
c. Description of nature of defect
d. Model number or description of model and/or component part if
possible.
(4/08) PART NO. 74180572
Loading...