Elkay LK2478CR Installation Manual

INSTALLATION / OWNER'S MANUAL

Single Handle Kitchen Faucet With Spray

Model # LK2478CR

WARNING: Please carefully read and properly follow the instructions for installation found in this manual.

STEPS:

(2) 1/2 in Supply Lines

Wrench

SAVE FOR CONSUMER

Turn off water before pr oceeding! Remove index(1). With valves in "close d" position,unscrew fastener (2) and remove handle (3) from valve stem (4).

CARE AND CLEANING INSTRUCTIONS

Congratulations on your purchase of an Elkay product. Although your product is extremely durable, attention should be given to the care, cleaning and maintenance of this product. Cleaning agents and abrasives may cause damage, which may result in oxidation and discoloration.

By following these simple guidelines for proper care and cleaning, it will give you years of enjoyment:

TO CLEAN: Simply wipe gently with a damp cloth and blot dry with a soft towel. A common rule of thumb is: when you dry off, dry off your product.

· Avoid build-up of soap, toothpaste or mineral deposits, as

these tend to have an adverse effect on the appearance of the product.

· NEVER use cleaning products of any kind on this product -

especially those containing ammonia, bleach or alcohol - or those with any form of abrasive.

ScrewdriverGroove joint pliers

Sealant Tape

Plumber's Putty

CARTRIDGE REPLACEMENT

Shut off water supply.Re move handle(refer to step

1).Loosen bonnet (1) and cap ( 2) by turning it counter-clockwi se and lift out the cartridge (3).Inspect the rubber valve seat (4) inside body (5).Tightly bonnet (1) and cap (2).R einstall the handle.

FOR CARE AND MAINTENANCE:

·The water in certain areas of the world can be very caustic -

standing water around the product can cause damage. Be sure to remove standing water with a dry, soft cloth as soon as possible.

·For polished brass finishes, as often as once a week, you

can apply a paste wax or special, non-abrasive, brass coating (DO NOT APPLY POLISH).

·Before applying a protective coating, gently brush the entire

fixture using a soft tooth brush. This will remove any dirt or deposit build-up.

·These simple steps will add temporary protective coating to

your faucet and extend the life of the finish. Failure to follow care and cleaning will void your warranty.

For additional information, please visit elkayusa.com .

Shut off water supply at angle stop. Remove old faucet. Clean sink surface in preparation for new faucet.

Install faucet into sink by leading all hoses down center through center hole. From underside, sl ide channel washer onto threaded rods . Secure with nuts.

For models with spr ay ( fits 4 - hole sinks ):Insert spr ay support through

far right - hand hole on sink. Screw

hold - down nut onto shank and hand

tighten.

(B)

(A)

Make connections to water lines. Use 1/2" I.P.S. faucet connections (1) or use supplied coupling nuts (3) with 3/8" O.D.ball-no se riser(2). Use wrenches to tigh ten connections. Do not overtighten.

For models with spray Insert spray hose down through support and sink. Attach spr ay hose to spray hose nipple. Tig hten with wrench.

Important: After installation is completed, remove aerator. Turn on water supply and allow both hot and cold water to run for at l east one minute each. While water i s running, check for leaks. Repl ace aerator.

WARRANTY

Elkay warrants that all parts and finishes of the Elkay Residential brand faucets are free from defects in materials and workmanship for the life of the product, if purchased after 1 996. This warranty extends to the original consumer purchaser of the product only.

If the product should leak or drip du ring normal use, Elkay will provide,

free of charge, a replacement cartridge . For other defects in material or workmanship, Elkay will, at its option, supply replacement pa rts (or if no longer available a comparable produ ct). Elkay reserves the right to examine product in question a nd its installation prior to replacement.

What is not covered:

1. Damage caused by accident, negligence, misuse, abuse, improper installation or operation or failure to follow care or installation instructions enclosed with your product.

2. Damage occurring during shipment of the product (claims must be presented to the carrier).

3. Normal wear and tear.

4. Labor charges, costs of removal and reinstallation, and any damages to other property.

5. All industrial, commercial and business use whose purchasers are hereby extended a limited lifetime on mechan ical parts and 5 years on finish.

What you must do to obtain warranty service: 6245 Shiloh Rd, Suite B, Alpharetta, GA 30005 or call 866-237-3907 . Please provide date of pu rchase and installation, description of nature of the defect, and model number ordescription of model and/or component part.

Elkay

elkayusa.com

ELKAY LIMITED LIFETIME WARRANTY

RP50054 Set Screw

RP10042 Index

RP30021* Areator

RP70037 Diverter

RP50040 Thread Rod

RP50036 Mounting Nut

RP56002 Coupling Nut

RP36048* Spray

THIS LIMITED WARRANTY IS EXPRESSLY IN LIEU OF ANY OTHER WARRANTIES, EXPRESSED IMPLIED, ARISING BY LAW OR OTHERWISE, INCLUDING WITHOUT LIMITATION, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. THIS LIMITED WARRANTY MAY NOT BE ALTERED, VARIED, OR EXTENDED, EXCEPT BY A WRITTEN INSTRUMENT EXECUTED BY ELKAY. THE REMEDY OF REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS LIMITED WARRANTY IS EXCLUSIVE. IN NO EVENT SHALL THE MANUFACTURER BE LIABLE FOR ANY CONSEQUENTIAL OR INCIDENTAL DAMAGES TO ANY PERSON, WHETHER OR NOT OCCASIONED BY NEGLIGENCE OF ELKAY, INCLUDING WITHOUT LIMITATION DAMAGES FOR LOSS OF USE, COSTS PROPERTY DAMAGE OR OTHER MONETARY LOSS.

Some states do not allow the exclusion or limitation of incidental or consequential damages or limitations on how long an implied warranty

lasts, so the above limitations or exclusions may not apply. This warranty gives you specific legal rights and you may a lso have other rights which vary from state to state.

This warranty covers product installed in the United States and Canada

REPLACEMENT PARTS

RP13163* Handle

RP70138 Bonnet

RP80108* Cap

RP70107 Cam RP70108 Cam washer

RP22007 Cartridge

RP22008 Seat&Spring

RP60032 O-ring

RP64070 Washer

Model # LK2478CR (Rev. date: 10/2010)