Electrolux EW28BS71IS, EW23BC71IS Wiring Diagram

SERVICE DATA SHEET

242047002

ICE & WATER - AUTOMATIC DEFROST

BOTTOM FREEZER - R134a

IMPORTANT SAFETY NOTE

The information provided herein is designed to assist qualified repair personnel only.

Untrained persons should not attempt to make repairs due to the possibility of electrical

shock. Disconnect power cord before servicing this appliance.

IMPORTANT

If any green grounding wires are removed during servicing, they must be returned to

their original position and properly secured.

CAUTION

All electrical parts and wiring must be shielded from torch flame. DO NOT allow

torch to touch insulation; it will char at 200°F and flash ignite (burn) at 500°F.

Excessive heat will distort the plastic liner.

NOTE

This product comes equipped with an Adaptive Defrost Control (ADC). To activate manual

defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-)

keys for 5 seconds. A “d” in the freezer temperature window and “F” in the refrigerator

temperature window will display when the heater is activated. To deactivate manual

defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down (-)

keys for 5 seconds. A “d” and “F” will be displayed until the defrost cycle is complete.

PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0° CONTROL SETTING

Type A with Run/Start Capacitor 65°F (18°C) Ambient 90°F (32°C) Ambient

Operating Time 90 to 100% 100%

Freezer Temperature -5° to 2° F (-20° to -17° C) -1° to 3° F (-18° to -16° C)

Refrigerator Temperature 34° to 39° F (1° to 4° C) 34° to 39° F (1° to 4° C)

Low Side Pressure -2 to 6 psig ( -14 to 41 kPa) -2 to 6 psig (-14 to 41 kPa)

High Side Pressure (last 1/3 cycle) 85 to 105 psig (586 to 724 kPa) 120 to 135 psig (827 to 931 kPa)

Wattage (last 1/3 cycle) 30 to 50 50 to 70

Amps (running) .4 to .8 .7 to .9

Base Voltage 115 vac (127 vac max)

DEFROST SPECIFICATIONS

Cabinet Size

Thermostat Heater

Cut-in Cut-out Watts Ohms

26’ & 28’ SD, 23’ CD 25° F (-4° C) 47° F (8° C) 500 26.5

Electronic Timer - (ADC) Defrost 24 minutes every 6-96 hours of compressor run time.

CONDENSER FAN MOTOR

Watts RPM Amps

3.1 1100 CW Opposite Shaft 0.03 Running

ICE MAKER SPECIFICATIONS

Electrical 115 vac (127 vac max)

Thermostat Opens at 48° F ( 9° C), Closes at 15° F ( -9° C)

Heater Voltage 85 vac

ICE MAKER CONNECTOR PLUG CONNECTIONS

Wire Number Wire Color Connects to:

1 Green/Yellow Ground

2 Yellow Water Valve

3 Black Line

4 Light Blue Neutral

IMPORTANT

PLEASE RETURN THIS SHEET TO IT’S ORIGINAL LOCATION.

FREEZER ICE MAKER INFORMATION

(Where Applicable)

Test Cycling: Remove cover by inserting screwdriver

in notch at bottom and prying cover from housing. Use

screwdriver to rotate motor gear counterclockwise until

holding switch circuit is completed. All components of ice

maker should function to complete the cycle.

Water Fill Volume: The water ll adjustment screw

will change the ll time. One full turn is equal to 20cc

(.68 oz.). The correct ll is 102 to 130cc (3.4 to 4.3 oz.).

When a water valve is replaced, the ll volume must be

checked.

T

U

R

N

Mounting

Plate

Screws

Mounting

Plate

Screw

Motor

Gear

Timing

Gear

Water Fill

Adjustment

POWER

ICE MAKER

I

CE MAKER

ICE MAKER

WATER VALVE

LINE

THERMAL

CUT-OUT

HOLD

SWITCH

THERMOSTAT

SHUT-OFF

SWITCH

WATER FILL

SWITCH

MOLD HEATER

MOLD

MOUNTING

PLATE

165 WATTS

MOTOR

NEUTRAL

BLK

BLK

BLK

BLK

BLU

C

C

C

NO

NO

NO

NC

NC

NC

LT. BLU

LT. BLU

BRN

RED

GRN/YEL

GRN / YEL

RED

RED

YEL

YEL

YEL

P-3

P-1

P-2

P-4

ICE MAKER

Ice Maker Errors Displayed on “UI” Diagnostic Mode Note: See Service Manual for

complete description.

ERROR Test

Activate: Hold FF (+) and FZ (+) for 5 sec.

None 52C

Ice tray thermistor temperature displayed - OK, OP open, SH short

55C

Water valve test

57C

Fan test, on or off

58C

Ice level sensor switch test

63C

Harvest motor system test

De-activate: Hold FF (+) for 5 sec.

System Error Codes Displayed on “UI” Diagnostic Mode Note: See Service Manual for

complete description.

ERROR Test Activate: FZ (+) and FZ (-) for 5

sec.

OP or 2

Freezer Sensor OPEN

1

Standard compressor

22

Damper

SH or 3

Freezer Sensor SHORTED

2

Defrost heater

23

Fresh food door

OP or 2

FF Sensor OPEN

3

FF lighting

24

Freezer door

SH or 3

FF Sensor SHORTED

8

Water valve,water disp.

26

Defrost limit switch

SY EF

Evaporator Fan Circuit

9

FZ lighting

28

Dispenser paddle

SY CE

Communication error

10

Auger motor

36

Ice door

SY CF

Communication error

11

Cube/crush solenoid

29

FF Thermistor

41

Perfect Temp Drawer

30

FZ Thermistor

12

VCC Condensor fan

33

Ambient Thermistor

To initiate manual defrost press and hold, for 5 sec. FF(+) and FF(-), (d) and (f) will

be displayed.

38

VCC Compressor

0-

Software version

dF

In Manual Defrost (See Note)

15

Evaporator fan

De-activate: Hold FF (+) for 5 sec.

242155401 Wiring Diagram

ELUX FDBF 2500++ V5 with dispenser/GEN2 IM w/PTD