Easy UPS UPSSMV750CAI Service Manual

User Manual Easy UPS

SMV Series 750, 1000, 1500, 2000, 3000 VA

Important Safety Messages

SAVE THESE INSTRUCTIONS - This section contains important instructions that should be followed
during installation and maintenance of the UPS and batteries.

Read these instructions carefully and look at the equipment to become familiar with the device before

trying to install, operate, service or maintain it. The following special messages may appear throughout

this document or on the equipment to warn of potential hazards or to call attention to information that

clarifies or simplifies a procedure.

The addition of this symbol to either a “Danger” or “Warning” safety label indicates that an

electrical hazard exists which will result in personal injury if the instructions are not followed.

This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey

all safety messages that follow this symbol to avoid possible injury or death.

DANGER

DANGER indicates a hazardous situation which, if not avoided, will result in death or serious
injury.

W ARN I NG

DANGER indicates a hazardous situation which, if not avoided, will result in death or serious
injury.

CAUTION

CAUTION indicates a hazardous situation which, if not avoided, could result in minor or moderate
injury.

NO T ICE

NOTICE is used to address practices not related to physical injury.

Product Handling Guidelines

<18 kg
<40 lb

18-32 kg
40-70 lb

32-55 kg
70-120 lb

>55 kg
>120 lb

Safety and General Information

General safety

Ÿ Adhere to all national and local electrical codes.

Ÿ This UPS is intended for indoor use only. To prevent the risk of fire or electric shock, install in a

temperature and humidity controlled indoor area, free of conductive contaminants.

Ÿ Mains socket outlet that supplies the UPS shall be installed near the UPS and shall be easily

accessible.

Ÿ UPS must be connected to an earthed mains socket outlet.
Ÿ CAUTION This UPS is designed to satisfy all of requirement of PCs only.
Ÿ CAUTION Risk of electric shock, do not remove the chassis cover. Servicing should be performed

by Qualified Engineer.

Battery safety

CAUTION

HYDROGEN SULPHIDE GAS AND EXCESSIVE SMOKE

Ÿ Replacethebatteryatleastevery5years.

Ÿ ReplacethebatteryimmediatelywhentheUPSindicatesbatteryreplacementisnecessary.
Ÿ Replacebatteryattheendofitsservicelife.
Ÿ Replacebatterieswiththesamenumberandtypeofbatteriesasoriginallyinstalledinthe

equipment.

Ÿ ReplacethebatteryimmediatelywhentheUPSindicatesabatteryover-temperaturecondition,

orUPSinternalover-temperature,orwhenthereisevidenceofelectrolyteleakage.Poweroff
theUPS,unplugitfromtheACinput,anddisconnectthebatteries.DonotoperatetheUPS
untilthebatterieshavebeenreplaced.

Failure to follow these instructions can result in injury

Ÿ Servicing of user replaceable batteries should be performed or supervised by personnel

knowledgeable about batteries and required precautions. In this case batteries are not user
replaceable.

Ÿ When replacing battery the UPS must be OFF, and its AC inlet unplugged.
Ÿ CAUTION Do not dispose of batteries in a fire. The batteries may explode.
Ÿ CAUTION Risk of explosion if battery is replaced by an incorrect type. Dispose of used batteries

according to the instructions.

Ÿ Do not open or mutilate batteries. They contain an electrolyte that is toxic and harmful to the skin

and eyes.

Ÿ CAUTION A battery can present a risk of electrical shock and high short circuit current. The

following precautions should be observed when working on batteries.
a. Remove watches, rings or other metal objects.
b. Use tools with insulated handles.
c. Wear rubber gloves and boots.
d. Do not lay tools or metal parts on top of batteries.
e. Disconnect the charging source prior to connecting or disconnecting battery terminals.
f. Determine if battery is inadvertently grounded. If inadvertently grounded, remove source from

ground. Contact with any part of a grounded battery can result in electrical shock. The likelihood
of such shock can be reduced if such grounds are removed during installation and maintenance.

2

Easy UPS SMV Series 750, 1000, 1500, 2000, 3000VA

Ÿ CAUTION The UPS contains internal batteries and may present a shock hazard even when

disconnected from AC power.

Ÿ CAUTION Risk of electric shock, Battery Circuit is not isolated from AC input, hazardous voltage

may exist between battery terminals and ground. Test before touching.

Radio Frequency Warning

This is a category C2 UPS product. In a residential environment, this product may cause radio
interference, in which case the user may be required to take additional measures.

Inventory

USB cable

Software, User documentation

Optional

Model

SMV750CAI
SMV1000CAI
SMV1500CAI
SMV2000CAI

SMV3000CAI

a) IEC C14 plug to C13 plug

c) SCHUKO plug to IEC C19 plug

Cable

a x 1
b x 1

a x 1
c x 1

Easy UPS SMV Series 750, 1000, 1500, 2000, 3000VA

b) SCHUKO plug to IEC C13 plug

3