Operation Manual for Electric Golf Car
Thanks for purchasing our electric golf cars. This manual contains
information for proper operation and maintenance and care of your golf
car. A thorough understanding of this manual will help you to obtain
maximum enjoyment from this golf car. Please keep it properly for
future reference.
Index
Our golf car is environment-friendly and suitable for use in golf course, and it
also can be used as people mover or utility car in vacation villages, villa areas,
resort hotels, private residential areas, tourist scenic spots, or any other place
where this type of golf car is allowed.
Please always learn whether there is any restriction in the area where you
intend to use the golf cars to avoid any unpleasant experience.
WARNING!
1 . OVERVIEW
Our golf car is designed for simple operation, however, please make sure to
observe following safe operation instructions:
BEFORE OPERATING THE GOLF CAR:
ALWAYS read this first before you start driving the golf car.
ONLY authorized people should drive this golf car, from the driver's side
ONLY
Drive the golf car ONLY in areas where the golf car is allowed to use by
law or local regulations and the conditions are safe to do so.
DO NOT allow more than the designed people on the golf car.
DO NOT overload the golf car in any case, otherwise the motor may be
damaged, the car may also lose control and/or the driver and passengers
will be positioned in danger.
DO NOT operate the golf car while under the influence of alcohol or drugs,
otherwise, their affect on vision and judgment put the driver and passenger
in danger.
DO NOT make the car climb any slope beyond its gradeability.
DO NOT overtake other vehicles at crossroads, in blind areas or in any
dangerous areas.
WHILE OPERATING THE GOLF CAR
Keep your entire body inside the golf car, keep seated and hold on while
the golf car is moving.
Do not start the golf car until all occupants are securely seated.
Keep your hands on the steering wheel and your eyes on the path you are
going.
Always back up slowly, and watch the back carefully.
Avoid starting or stopping suddenly.
2. SAFE OPERATION INSTRUCTIONS
1
1
2
2
5
6
16
1. Overview
2. Safe Operation Instructions
3. Technical Data
4. Controls
5. Operation
6. Maintenance
7. Main Trouble and troubleshooting
8. Periodic Maintenance Charts
9. STORAGE
10. Wiring Diagram
14
16
12
Avoid turning the steering wheel too sharply at higher speed.
Always drive slowly up or down on the incline. Do not make any
modification or addition which may affect the capacity or safety
Children are not allowed to play in the car. Children should be seated
between adults and protected by them when the car is moving.
The data below have been confirmed by an independent authority lab.
3. TECHNICAL DATA
10)Hand brake (optional)
11)Battery Receptacle
Controller Cover
8)Tow/Run Switch
9)Turn Signal And Horn Switch
1) Power key
2) Forward/reverse switch
3) Accelerator pedal
4) Service brake pedal
5) Park brake pedal
6) Steering wheel
7) Battery power meter
8) Tow/Run switch
9) Turn signal and horn switch
10) Hand brake (optional)
11) Battery receptacle
12) Headlight switch
2) Functions of Controls
The power key is used to switch on the electrical system of the golf car.
To engage the motor and drive the golf car, Insert the key and turn it clockwise
to the ON position.
To engage the 12V accessory system (including the headlight, turn signal,
taillight, brake light and horns) at the same time driving the golf car, turn the
key clockwise to one more position of LIGHT.
To switch the power off, turn the key counterclockwise to OFF position.
This switch is a three-position switch, depressing the upper part gets the golf
car move forwards while depressing the lower part gets the golf car move
backwards, and the middle is neutral.
This switch must be fully depressed into the proper position, or
Power key
Forward/reverse switch
WARNING!
4. CONTROLS
1)Schematic Figure of controls
6)Steering wheel
9)Turn Signal And
Horn Switch
1)Power Key
2)Forward/Reverse
Switch
7)Battery Power
Meter
12)Headlight switch
4)Service Brake Pedal
5)Park Brake Pedal
3)Accelerator Pedal
1)Power Key
2)Forward/Reverse
Switch
3)Accelerator Pedal
4)Service Brake Pedal
5)Park Brake Pedal
6)Steering wheel
7)Battery Power Meter
12)Headlight switch
9)Turn Signal And
Horn Switch
06 type dashboard 08 type dashboard
Technical Data Of Hunting Buggy
ITEMS
Hunting Buggy 2+2 Hunting Buggy 4+2
Voltage (V)
Battery Setup
Dimensions (mm) (L x W x H)
Range (km/h) based on flat road at a speed of 20km/h
Maximum Speed (km/h) for Gear Ratio of 12.49:1
Maximum Speed (km/h) for Gear Ratio of 10.25:1
Minimum Turning Diameter (m)
Maximum Loading Capacity (Kg)
Maximum Gradeability
Noise (dB)
Maximum Brake Distance (V=20km/h)
48V
8pcs x 6V
2500x1300x1900
> 75
32
36
9
300
28%
70
< 4
48V
8pcs x 6V
3500x1300x1900
> 70
32
36
12
450
28%
70
< 4
ITEMS
Two Passengers Four Passengers Six Passengers
Voltage (V)
36V 48V 36V
48V
36V
48V
Battery Setup
6pcs x 6V 6pcs x 8V 8pcs x 6V 6pcs x 6V
6pcs x 8V
8pcs x 6V 6pcs x 6V
6pcs x 8V
8pcs x 6V
Dimensions (mm)
(L x W x H)
2350*1180*1750 3150*1180*1850 3800*1200*1870
Range (km/h) based
on flat road at a
speed of 20km/h
> 60 > 60 > 80 >55 > 55 > 75 >50 >50 > 70
Maximum Speed
(km/h) for Gear Ratio
of 12.49:1
21
25 for 3KW motor
32 for 4KW motor
25 for 3KW motor
32 for 4KW motor
21
25 for 3KW motor
32 for 4KW motor
25 for 3KW motor
32 for 4KW motor
21
25 for 3KW motor
32 for 4KW motor
25 for 3KW motor
32 for 4KW motor
Maximum Speed
(km/h) for Gear Ratio
of 10.25:1
25
27 for 3KW motor
36 for 4KW motor
27 for 3KW motor
36 for 4KW motor
25
27 for 3KW motor
36 for 4KW motor
27 for 3KW motor
36 for 4KW motor
25
27 for 3KW motor
36 for 4KW motor
27 for 3KW motor
36 for 4KW motor
Minimum Turning
Diameter (m)
Maximum Loading
Capacity (Kg)
Maximum
Gradeability
25% 25% 25% 20% 20% 20% 20% 20% 20%
Noise (dB)
70
70
70
Maximum Brake
Distance (V=20km/h)
< 4
< 4
< 4
7 7 7
9 9 9
12 12 12
150 150 150 300 300 300 450 450
450
Technical Date Of Golf Car
Loading...