Dowco Rally Pack Universal Luggage User Manual

The Rally pack Motorcycle Backpack
system consists of:

Jumbo Backpack
Roll Bag
Vinyl Liner
Attachable Bungee Net

Installation:
Jumbo Backpack

Open horizontal hook & loop straps on the rear of the bag.
Place Jumbo Backpack on luggage rack.
Loop the straps around the sissy bar/backrest in a way that

is secure.
Locate the 2 long straps and attach them to the lower D-

rings on the front of the bag.
Loop these straps around the directional indicator bar or

other secure mounting location below the bag, and then
attach the other ends to the lower D-rings on the back of the
bag; the clips can be individually tightened by pulling on the
loose ends.

Excess strap material should be knotted.

CAUTION - allowing straps to hang loose may cause damage
to packs, painted finishes or they may become
entangled in the wheel or chain.

Note:

Backpack may be carried on the shoulders while not riding
by connecting the long straps to the 4 D-rings on the back of
the bag.

Roll Bag

If Roll Bag is to be used separately from the Backpack

Open horizontal hook & loop straps on the rear of the bag.
Place roll bag on luggage rack.

Loop the straps around the sissy bar/backrest in a way that
is secure.

Locate the 2 long straps and attach them to the lower D­rings on the front of the bag.

Loop these straps around the directional indicator bar or
other secure mounting location below the bag, and then
attach the other ends to the lower D-rings on the back of
the bag; the clips can be individually tightened by pulling
on the loose ends.

Excess strap material should be knotted.

4 Piece Universal Luggage System
Installation Instructions

Printed in China
form # 142293-00
Revised: 09/17/08

4230 Clipper Drive Manitowoc, WI 54220 U.S.A
email: [e-mail]
www.dowcopowersports.com
Fax: [phone]
Phone: [phone]

This system is recommended for use with a sissy
bar/backrest and luggage rack combination which is
permanently attached to the motorcycle.

Do not exceed the manufacturers recommended load
capacity.

Consult your owner’s manual for tire
inflation pressures and gross axle weight rating.
Failure to follow recommended weight loading
capacities may affect handling. This could result in
property damage, injury and possibly death.

POWERSPORTS ACCESSORIES

®

CAUTION - allowing straps to hang loose may cause
damage to packs, painted finishes or they may become

entangled in the wheel or chain.

If Roll Bag is to be used with the Backpack

Install Backpack using previous directions.
Place the Roll Bag above the Backpack.
Use the 4 short straps to connect the corresponding D-

rings in each of the 4 corners. The clips can be individu­ally tightened by pulling on the loose ends.

For added security, there are also two side straps on the
Roll Bag that loop through clips on the Backpack.

CAUTION - allowing straps to hang loose may cause
damage to packs, painted finishes or they may become
entangled in the wheel or chain.

Vinyl Liner

May be used with either the Backpack or the Roll Bag.

CAUTION - do not cut or puncture the liner.

Bungee Net

May be used for additional storage of clothing or other
articles which may need to be accessible during riding.
Place articles on top of packs and secure with net by
attaching hooks to the “D” rings provided.

CAUTION - hooks are under tension and may become
dangerous when unfastened. Use extreme care when
removing.

Care & Cleaning

Use mild household detergent and soft brush to remove
dirt or road grime. Rinse thoroughly and dry before
using. Do not put in washer or dryer, dry-cleaning is not
recommended.

Printed in China
form # 142293-00
Revised: 09/17/08

4230 Clipper Drive Manitowoc, WI 54220 U.S.A
email: [e-mail]
www.dowcopowersports.com
Fax: [phone]
Phone: [phone]