Dometic 57908.321, 57908.521, 57912.321, 57912.531, 57912.621 User Manual
...
ANALOG DUCTED INSTALLATION INSTRUCTIONS
|
|
|
|
|
|
|
|
|
|
|
|
RECORDTHISUNITINFORMATIONFORFUTUREREFERENCE: |
|
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Model Number |
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Serial Number |
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Date Purchased |
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
600 Series PENGUIN |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
579 Series BRISK AIR |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
590 Series QUICK COOL |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
591 Series HEAT PUMP |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
595 Series QUICK COOL |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
Roof Top Air Conditioner/Heat Pump |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
USED WITH |
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
Part No. 3107541 and 3107546 |
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
Analog Relay Kit |
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
WITH REMOTE ANALOG THERMOSTAT |
|
|
|
|
|
||||||||||
USA |
|
|
|
|
|
|
|
|
|
|
|
DUCTED |
|
|
|
|
|
|
|
|
|
||||
SERVICEOFFICE |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
The Dometic Corp. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
509 So. Poplar St. |
|
|
|
|
|
|
THIS UNIT IS DESIGNED FOR OEM INSTALLATION |
|
|
|
|
||||||||||||||
LaGrange, IN 46761 |
|
|
|
|
|
|
|
|
|
|
|||||||||||||||
260-463-4858 |
|
|
|
|
ALL INITIAL INSTALLATIONS MUST BE APPROVED BY THE SALES DEPT. |
|
|||||||||||||||||||
CANADA |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
! WARNING |
|
|
|
|
|
! |
AVERTISSEMENT |
|
|
||||||||
Dometic Dist. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
866 Langs Dr. |
|
|
|
This manual must be read and un- |
|
Lire et comprendre ce manuel avant de |
|
||||||||||||||||||
Cambridge, Ontario |
|
|
|
|
|
||||||||||||||||||||
|
|
|
|
procéderàl'installation,àdesréglages, |
|
||||||||||||||||||||
CANADA N3H 2N7 |
|
|
|
derstood before installation, adjust- |
|
|
|||||||||||||||||||
519-653-4390 |
|
|
|
|
|
de l'entretien ou |
des réparations. |
|
|||||||||||||||||
|
|
|
|
|
|
ment, service, or maintenance is per- |
|
|
|||||||||||||||||
For Service Center |
|
|
|
|
L'installation de cet appareil doit être |
|
|||||||||||||||||||
|
|
|
formed. This unit must be installed |
|
|
||||||||||||||||||||
Assistance |
Call: |
|
|
|
|
effectuée par un réparateur qualifié. |
|
||||||||||||||||||
800-544-4881 |
|
|
|
|
by a |
qualified |
service technician. |
|
|
||||||||||||||||
|
|
|
|
|
Toute modification de cet appareil peut |
|
|||||||||||||||||||
|
|
|
|
|
|
Modification of this product can be |
|
|
|||||||||||||||||
|
|
|
|
|
|
|
être extrêmement dangereuse et |
|
|||||||||||||||||
|
|
|
|
|
|
extremely hazardous and could re- |
|
|
|||||||||||||||||
|
|
|
|
|
|
|
entraîner des blessures ou dommages |
|
|||||||||||||||||
|
|
|
|
|
|
sult in personal injury or property |
|
|
|||||||||||||||||
|
|
|
|
|
|
|
matériels. |
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
damage. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
C |
US |
|
|
|
|
|
|
|
|
|
|
|
|
|
MODELS |
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
57908.321 |
57915.422 |
57915.631 |
59516.603 |
59530.601 |
|
|||||||||||||
|
|
|
|
|
|
|
|
|
|
57908.521 |
57915.426 |
57915.731 |
59516.606 |
59530.631 |
|
||||||||||
INSTALLATION |
57912.321 |
57915.521 |
59016.521 |
59516.631 |
59530.632 |
|
|||||||||||||||||||
57912.531 |
57915.522 |
59016.621 |
59528.601 |
600312.321 |
|
||||||||||||||||||||
INSTRUCTIONS |
57912.621 |
57915.526 |
59516.331 |
59529.531 |
600312.421 |
|
|||||||||||||||||||
57912.622 |
57915.531 |
59516.336 |
59529.601 |
600315.321 |
|
||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
57912.631 |
57915.536 |
59516.501 |
59529.631 |
600315.326 |
|
||||||||||
|
|
|
|
|
|
|
|
|
|
57915.331 |
57915.621 |
59516.531 |
59530.531 |
600315.421 |
|
||||||||||
|
|
|
|
|
|
|
|
|
|
57915.336 |
57915.622 |
59516.536 |
59530.532 |
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
57915.421 |
57915.626 |
59516.601 |
59530.536 |
|
|
|
|
||||||||
REVISION |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Form No. 3107163.101 |
|
6/03 |
|
Important: These instructions |
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
(Replaces3107163.093) |
|
|
must stay with unit. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
(French3108062.071) |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
Owner read carefully. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
©2003 Dometic Corporation |
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
LaGrange, IN 46761 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
1
ANALOG DUCTED INSTALLATION INSTRUCTIONS
SAFETY INSTRUCTIONS
This manual has safety information and instructions to help users eliminate or reduce the risk of accidents and injuries.
RECOGNIZE SAFETY INFORMATION
! |
This is the safety-alert symbol. When you see this symbol in this manual, be alert to the potential for personal injury.
Follow recommended precautions and safe operating instructions.
UNDERSTAND SIGNAL WORDS
1. GENERAL INFORMATION
A.Product features or specifications as described or illustrated are subject to change without notice.
B.This air conditioner is designed for:
1.Installation on a recreational vehicle during the time the vehicle is manufactured.
2.Mounting on the roof of a recreational vehicle.
3.Connection to an air distribution system located in the ceiling/roof cavity of the recreational vehicle.
4.Roof construction with rafters/joists on minimum of 16 inch centers.
5.Minimum of 2.00" and maximum of 5.50" distance between roof to ceiling of recreational vehicle. Alternate installation methods will allow for roofs more than 5.50" thick.
C.The ability of the air conditioner to maintain the desired inside temperature depends on the heat gain of the RV. Some preventative measures taken by the occupants of the RV can reduce the heat gain and improve the performanceoftheairconditioner.Duringextremelyhigh outdoor temperatures, the heat gain of the vehicle may be reduced by:
1.Parking the RV in a shaded area
2.Using window shades (blinds and/or curtains)
3.Keeping windows and doors shut or minimizing usage
4.Avoiding the use of heat producing appliances.
A signal word , WARNING OR CAUTION is used with the safety-alert symbol. They give the level of risk for potential injury.
indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
indicates a potentially hazardous situation which, if not avoided may result in minor or moderate injury.
CAUTION used without the safety alert symbol indicates, a potentially hazardous situation which, if not avoided may result in property damage.
Read and follow all safety information and instructions.
Operation on High Fan/Cooling mode will give optimum or maximum efficiency in high humidity or high outside temperatures.
Starting the air conditioner early in the morning and giving it a "head start" on the expected high outdoor ambient will greatly improve its ability to maintain the desired indoor temperature.
For a more permanent solution to high heat gain, accessories like A&E outdoor patio and window awnings will reduce heat gain by removing the direct sun. They also add a nice area to enjoy company during the cool of the evening.
D. Condensation
Note: The manufacturer of this air conditioner will not be responsible for damage caused by condensed moisture on ceilings or other surfaces. Air contains moisture and this moisture tends to condense on cold surfaces. When air enters the RV, condensed moisture may appear on the ceiling, windows, metal parts, etc. The air conditioner removes this moisture from the air during normal operation. Keeping doors and windows closed when this air conditioner is in operation will minimize condensed moisture on cold surfaces.
2
SPECIFICATIONS
|
MODEL |
NOMINAL |
ELECTRICAL |
COMPRESSOR |
COMPRESSOR |
FAN MOTOR |
FAN MOTOR |
SCFM-HIGH |
TOTAL |
REFRIGERANT |
MINIMUM |
AC CIRCUIT |
INSTALLED |
MINIMUM |
|
NO. |
CAPACITY |
RATING |
RATED LOAD |
LOCKED |
RATED LOAD |
LOCKED |
SPEED |
STATIC |
R-22 (OZ) |
WIRE SIZE* |
PROTECTION |
WEIGHT |
GENERATOR |
|
|
(BTU/HR) |
|
AMPS |
ROTOR |
AMPS |
ROTOR |
MAX/MIN |
MAX/MIN |
|
|
*** USER |
(POUNDS) |
SIZE** |
|
|
COOLING |
|
|
AMPS |
|
AMPS |
|
“ W. C. |
|
|
SUPPLIED |
|
1 UNIT/ 2 UNITS |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
57908.321 |
7,180 |
115VAC, |
6.9 |
36.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
12 AWG |
20Amp |
75 |
2.5 KW / 4.0 KW |
|
57908.521 |
7,100 |
60 HZ., 1PH. |
6.6 |
34.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
17.0 |
Copper |
20Amp |
75 |
2.5 KW / 4.0 KW |
|
57912.321 |
11,000 |
|
9.5 |
53.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
15.5 |
up to 24’ |
20Amp |
94 |
2.5 KW / 4.0 KW |
|
57912.531 |
11,000 |
|
8.0 |
53.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
18.5 |
|
20Amp |
94 |
2.5 KW / 4.0 KW |
|
57912.621 |
11,000 |
|
8.5 |
48.3 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
|
20Amp |
94 |
2.5 KW / 4.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
57912.622 |
11,000 |
|
8.5 |
48.3 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
18.0 |
|
20Amp |
94 |
2.5 KW / 4.0 KW |
|
57912.631 |
11,000 |
|
8.5 |
48.3 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
18.0 |
|
20Amp |
94 |
2.5 KW / 4.0 KW |
|
57915.331 |
13,500 |
|
11.4 |
58.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
15.5 |
|
20Amp |
100 |
3.5 KW / 5.0 KW |
|
57915.336 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
100 |
3.5 KW / 5.0 KW |
|
57915.421 |
13,500 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
13.5 |
|
20Amp |
100 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
57915.422 |
13,500 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
14.5 |
|
20Amp |
100 |
3.5 KW / 5.0 KW |
|
57915.426 |
13,500 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
13.5 |
|
20Amp |
100 |
3.5 KW / 5.0 KW |
|
57915.521 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
57915.522 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
57915.526 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
57915.531 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
57915.536 |
13,500 |
|
12.1 |
59.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
| <![if ! IE]> <![endif]>3 |
57915.621 |
13,500 |
|
11.0 |
54.4 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
57915.622 |
13,500 |
|
11.0 |
54.4 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
|
|
|
||||||||||||
|
57915.626 |
13,500 |
|
11.0 |
54.4 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
57915.631 |
13,500 |
|
11.0 |
54.4 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
16.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
57915.731 |
13,500 |
|
11.3 |
56.0 |
2.5 |
5.8 |
325 / 250 |
0.55 / 0.90 |
15.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
59016.521 |
15,000 |
|
12.9 |
71.0 |
2.5 |
6.0 |
350 / 250 |
0.40 /1.1 0 |
26.5 |
|
20Amp |
101 |
3.5 KW / 5.0 KW |
|
59016.621 |
15,000 |
|
12.9 |
77.0 |
2.5 |
6.0 |
350 / 250 |
0.40 / 1.10 |
26.5 |
|
20Amp |
101 |
3.5 KW / 5.0 KW |
|
59516.331 |
15,000 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.40 / 1.10 |
29.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
59516.336 |
15,000 |
|
12.7 |
60.0 |
2.0 |
5.6 |
325 / 250 |
0.40 / 1.10 |
29.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
59516.501 |
15,000 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.40 / 1.10 |
31.0 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
59516.531 |
15,000 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.40 / 1.10 |
26.5 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
59516.536 |
15,000 |
|
11.5 |
50.0 |
2.5 |
5.8 |
325 / 250 |
0.40 / 1.10 |
29 |
|
20Amp |
94 |
3.5 KW / 5.0 KW |
|
59516.601 |
15,000 |
|
12.9 |
77.0 |
2.5 |
6.0 |
350 / 250 |
0.40 / 1.10 |
31.0 |
|
20Amp |
102 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
59516.603 |
15,000 |
|
12.3 |
77.0 |
2.0 |
5.6 |
325 / 250 |
0.40 / 1.10 |
29.5 |
|
20Amp |
102 |
3.5 KW / 5.0 KW |
|
59516.606 |
15,000 |
|
12.9 |
71.0 |
2.0 |
6.0 |
325 / 250 |
0.40 / 1.10 |
31.0 |
|
20Amp |
102 |
3.5 KW / 5.0 KW |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
*For wire lengths over 24 ft. consult the National Electric Code for proper sizing.
**Dometic Corporation gives GENERAL guidelines for generator requirements. These guidelines come from experiences people have had in actual applications When sizing the generator, the total power usage of your recreational vehicle must be considered. Keep in mind generators lose power at high altitudes and from lack of maintenance.
***CIRCUIT PROTECTION: Time Delay Fuse or HACR Circuit Breakers Required.
<![endif]>INSTRUCTIONS INSTALLATION DUCTED ANALOG
ANALOG DUCTED INSTALLATION INSTRUCTIONS
|
<![if ! IE]> <![endif]>MINIMUM |
<![if ! IE]> <![endif]>GENERATOR |
<![if ! IE]> <![endif]>SIZE** |
<![if ! IE]> <![endif]>UNITS2UNIT/ 1 |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
|
<![if ! IE]> <![endif]>INSTALLED |
<![if ! IE]> <![endif]>WEIGHT |
<![if ! IE]> <![endif]>(POUNDS) |
|
<![if ! IE]> <![endif]>92 |
<![if ! IE]> <![endif]>94 |
<![if ! IE]> <![endif]>94 |
<![if ! IE]> <![endif]>94 |
<![if ! IE]> <![endif]>94 |
|
<![if ! IE]> <![endif]>CIRCUITAC |
<![if ! IE]> <![endif]>PROTECTION |
<![if ! IE]> <![endif]>USER*** |
<![if ! IE]> <![endif]>SUPPLIED |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
|
<![if ! IE]> <![endif]>MINIMUM |
<![if ! IE]> <![endif]>SIZE*WIRE |
|
|
<![if ! IE]> <![endif]>12AWG |
<![if ! IE]> <![endif]>Copper |
<![if ! IE]> <![endif]>upto24’ |
|
|
|
<![if ! IE]> <![endif]>REFRIGERANT |
<![if ! IE]> <![endif]>(OZ)22 -R |
|
|
<![if ! IE]> <![endif]>16.5 |
<![if ! IE]> <![endif]>18.5 |
<![if ! IE]> <![endif]>19.0 |
<![if ! IE]> <![endif]>18.5 |
<![if ! IE]> <![endif]>19.0 |
|
<![if ! IE]> <![endif]>TOTAL |
<![if ! IE]> <![endif]>STATIC |
<![if ! IE]> <![endif]>MAX/MIN |
<![if ! IE]> <![endif]>.C .W “ |
<![if ! IE]> <![endif]>0.41/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
| <![if ! IE]> <![endif]>SPECIFICATIONS |
<![if ! IE]> <![endif]>HIGH-SCFM MOTORFAN |
<![if ! IE]> <![endif]>SPEED LOCKED |
<![if ! IE]> <![endif]>MAX/MIN ROTOR |
<![if ! IE]> <![endif]>AMPS |
<![if ! IE]> <![endif]>5.6 325/250 |
<![if ! IE]> <![endif]>5.6 325/250 |
<![if ! IE]> <![endif]>5.6 325/250 |
<![if ! IE]> <![endif]>5.8 325/250 |
<![if ! IE]> <![endif]>5.6 325/250 |
|
<![if ! IE]> <![endif]>MOTORFAN |
<![if ! IE]> <![endif]>LOADTED RA |
<![if ! IE]> <![endif]>AMPS |
|
<![if ! IE]> <![endif]>2.0 |
<![if ! IE]> <![endif]>2.0 |
<![if ! IE]> <![endif]>2.0 |
<![if ! IE]> <![endif]>2.5 |
<![if ! IE]> <![endif]>2.0 |
|
<![if ! IE]> <![endif]>COMPRESSOR |
<![if ! IE]> <![endif]>LOCKED |
<![if ! IE]> <![endif]>ROTOR |
<![if ! IE]> <![endif]>AMPS |
<![if ! IE]> <![endif]>45.6 |
<![if ! IE]> <![endif]>49.0 |
<![if ! IE]> <![endif]>53.0 |
<![if ! IE]> <![endif]>53.0 |
<![if ! IE]> <![endif]>53.0 |
|
<![if ! IE]> <![endif]>COMPRESSOR |
<![if ! IE]> <![endif]>LOADTED RA |
<![if ! IE]> <![endif]>AMPS |
|
<![if ! IE]> <![endif]>6.0 |
<![if ! IE]> <![endif]>6.9 |
<![if ! IE]> <![endif]>7.8 |
<![if ! IE]> <![endif]>8.0 |
<![if ! IE]> <![endif]>7.8 |
|
<![if ! IE]> <![endif]>ELECTRICAL |
<![if ! IE]> <![endif]>RATING |
|
|
<![if ! IE]> <![endif]>115VAC, |
<![if ! IE]> <![endif]>60HZ.,1PH. |
|
|
|
|
<![if ! IE]> <![endif]>NOMINAL |
<![if ! IE]> <![endif]>CAPACITY |
<![if ! IE]> <![endif]>(BTU/HR) |
<![if ! IE]> <![endif]>COOLING |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
|
<![if ! IE]> <![endif]>MODEL |
<![if ! IE]> <![endif]>.NO |
|
|
<![if ! IE]> <![endif]>59528.601 |
<![if ! IE]> <![endif]>59529.531 |
<![if ! IE]> <![endif]>59530.531 |
<![if ! IE]> <![endif]>59530.532 |
<![if ! IE]> <![endif]>59530.536 |
| <![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>2.5KW/4.0KW |
<![if ! IE]> <![endif]>2.5KW/4.0KW |
<![if ! IE]> <![endif]>2.5KW/4.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
<![if ! IE]> <![endif]>3.5KW/5.0KW |
| <![if ! IE]> <![endif]>93 |
<![if ! IE]> <![endif]>94 |
<![if ! IE]> <![endif]>94 |
<![if ! IE]> <![endif]>95 |
<![if ! IE]> <![endif]>101 |
<![if ! IE]> <![endif]>96 |
<![if ! IE]> <![endif]>102 |
<![if ! IE]> <![endif]>96 |
| <![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>15Amp |
<![if ! IE]> <![endif]>20Amp |
<![if ! IE]> <![endif]>20Amp |
<![if ! IE]> <![endif]>20Amp |
<![if ! IE]> <![endif]>20Amp |
<![if ! IE]> <![endif]>20Amp |
| <![if ! IE]> <![endif]>19.0 |
<![if ! IE]> <![endif]>19.0 |
<![if ! IE]> <![endif]>18.0 |
<![if ! IE]> <![endif]>16.5 |
<![if ! IE]> <![endif]>16.0 |
<![if ! IE]> <![endif]>15.5 |
<![if ! IE]> <![endif]>17.0 |
<![if ! IE]> <![endif]>15.5 |
| <![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.40/1.10 |
<![if ! IE]> <![endif]>0.12/0.65 |
<![if ! IE]> <![endif]>0.12/0.65 |
<![if ! IE]> <![endif]>0.12/0.65 |
<![if ! IE]> <![endif]>0.12/0.65 |
<![if ! IE]> <![endif]>0.12/0.65 |
| <![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>325/250 |
<![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>335/250 |
<![if ! IE]> <![endif]>335/250 |
| <![if ! IE]> <![endif]>5.6 |
<![if ! IE]> <![endif]>5.6 |
<![if ! IE]> <![endif]>5.8 |
<![if ! IE]> <![endif]>8.8 |
<![if ! IE]> <![endif]>8.8 |
<![if ! IE]> <![endif]>8.8 |
<![if ! IE]> <![endif]>8.8 |
<![if ! IE]> <![endif]>8.8 |
| <![if ! IE]> <![endif]>2.0 |
<![if ! IE]> <![endif]>2.0 |
<![if ! IE]> <![endif]>2.5 |
<![if ! IE]> <![endif]>3.1 |
<![if ! IE]> <![endif]>3.1 |
<![if ! IE]> <![endif]>3.1 |
<![if ! IE]> <![endif]>3.1 |
<![if ! IE]> <![endif]>3.1 |
| <![if ! IE]> <![endif]>48.3 |
<![if ! IE]> <![endif]>48.3 |
<![if ! IE]> <![endif]>48.3 |
<![if ! IE]> <![endif]>53.0 |
<![if ! IE]> <![endif]>50.0 |
<![if ! IE]> <![endif]>60.0 |
<![if ! IE]> <![endif]>60.0 |
<![if ! IE]> <![endif]>50.0 |
| <![if ! IE]> <![endif]>8.0 |
<![if ! IE]> <![endif]>8.0 |
<![if ! IE]> <![endif]>8.5 |
<![if ! IE]> <![endif]>9.5 |
<![if ! IE]> <![endif]>10.7 |
<![if ! IE]> <![endif]>12.4 |
<![if ! IE]> <![endif]>12.4 |
<![if ! IE]> <![endif]>11.5 |
| <![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>N/A |
<![if ! IE]> <![endif]>11,000 |
<![if ! IE]> <![endif]>11,000 |
<![if ! IE]> <![endif]>13,500 |
<![if ! IE]> <![endif]>13,500 |
<![if ! IE]> <![endif]>13,500 |
| <![if ! IE]> <![endif]>59530.601 |
<![if ! IE]> <![endif]>59530.631 |
<![if ! IE]> <![endif]>59530.632 |
<![if ! IE]> <![endif]>600312.321 |
<![if ! IE]> <![endif]>600312.421 |
<![if ! IE]> <![endif]>600315.321 |
<![if ! IE]> <![endif]>600315.326 |
<![if ! IE]> <![endif]>600315.421 |
|
<![if ! IE]> <![endif]>actualapplications |
<![if ! IE]> <![endif]>highaltitudesand |
|
| <![if ! IE]> <![endif]>Forwirelenghtsover24ft.consulttheNationalElectricCodeforpropersizing. |
<![if ! IE]> <![endif]>DometicCorporationgivesGENERALguidelinesforgeneratorrequirements.Theseguidelinescomefromexperiencespeoplehavehadin |
<![if ! IE]> <![endif]>Whensizingthegenerator,thetotalpowerusageofyourrecreationalvehiclemustbeconsidered.Keepinmindgeneratorslosepowerat |
<![if ! IE]> <![endif]>fromlackofmaintenance. CIRCUITPROTECTION:TimeDelayFuseorHACRCircuitBreakersRequired. |
| <![if ! IE]> <![endif]>* |
<![if ! IE]> <![endif]>** |
|
<![if ! IE]> <![endif]>*** |
4
ANALOG DUCTED INSTALLATION INSTRUCTIONS
2. PRECAUTIONS
! WARNING
Improper installation may damage equipment, could endanger life, cause serious injury and/or property damage.
A.Read Installation and Operating instructions carefully before attempting to start your air conditioner/heat pump installation.
B.Dometic Corporation will not be liable for any damages or injury incurred due to failure in following these instructions.
C.Installation must comply with the National Electrical Code and any State or Local Codes or regulations.
D.DO NOT add any devices or accessories to this air conditioner/heat pump except those specifically authorized by Dometic.
E.This equipment must be serviced by qualified personnel and some states require these people to be licensed.
3. CHOOSING LOCATION FOR THE AIR CONDITIONER/HEAT PUMP
This air conditioner/heat pump is specifically designed for installation on the roof of a recreational vehicle (RV).
A.For One Unit Installation:
Theairconditioner/heatpumpshouldbemountedslightly forward of center (front to back) and centered from side to side.
B.For Two Unit Installations:
Install one air conditioner/heat pump one-third and one airconditioner/heatpumptwo-thirdsfromfrontofRVand centered from side to side.
It is preferred that the air conditioner/heat pump be installed on a relatively flat and level roof section measured with the RV parked on a level surface; however,
1.Up to an 8° slant to either side or front-to-back is acceptable on 600 Series Air Conditioners/heat pump.
2.Up to a 15° slant to either side or front-to-back is acceptable on 579, 590, 591 or 595 Series Air conditioners/heat pump.
AFTER LOCATION HAS BEEN SELECTED:
a.Check for obstructions in the area where air conditioner/heat pump will be installed. See FIG. 1.
b.The roof must be designed to support 130 pounds when the RV is in motion. Normally 200 pound static load design will meet this requirement.
CAUTION
It is the responsibility of the installer of this air conditioner/heat pump system to ensure structural integrity of the RV roof. Never create a low spot on the roof where water will collect. Water standing around the air conditioner/heat pump may leak into the interior causing damage to the product and the RV.
FIG. 1 AIR CONDITIONER/HEAT PUMP DIMENSIONS (On Top of |
||
Vehicle) |
|
600 SERIES |
579, 590, 591 & 595 SERIES |
|
|
KEEP THIS AREA FREE OF OBSTRUCTIONS |
|
|
7-5/8” |
|
|
5-1/4” |
14-7/8” |
REAR |
|
|
|
|
|
OF |
14-1/4" x 14-1/4” |
|
UNIT |
(±1/8) OPENING |
|
|
7-5/8” |
|
|
|
18" |
|
|
|
5 |
ANALOG DUCTED INSTALLATION INSTRUCTIONS
4. AIR DISTRIBUTION SYSTEM SIZING & DESIGN
The Installer of this air conditioner/heat pump system must design the air distribution system for their particular application. Several requirements for this system MUST be met for the air conditioner/heat pump to operate properly. These requirements are as follows:
A.The duct material must meet or exceed any agency or RVIA Standard that may be in existence at the time the RV is produced.
B.All discharge air ducts must be properly insulated to prevent condensation from forming on their surfaces or adjacent surfaces during operation of the air conditioner/heat pump. This insulation must be R-7 minimum.
C.Ducts and their joints must be sealed to prevent condensation from forming on adjacent surfaces during operation of the air conditioner/heat pump.
D.Return air openings must have 40 square inches minimum free area including the filter.
E.Return air to the air conditioner/heat pump must be filtered to prevent dirt accumulation on air conditioner/heat pump cooling surface.
CAUTION
It is the responsibility of the installer to insure the ductwork will not collapse or bend during and after the installation. Dometic Corporation will not be liable for roof structural or ceiling damage due to improperly insulated, sealed or collapsed ductwork.
AIR DISTRIBUTION
DUCT SIZING & DESIGN CHART
Return Air Cover Model |
3105007.XXX |
3308120.XXX |
|
3105935.XXX |
Genesis Air Filtration System |
|
|
|
Roof Cavity Depth |
2.0 In. Min. - 5-1/2 In. Max. |
2.0 In. Min. - 5-1/2 In. Max. |
|
|
|
Duct Cross Sectional Area |
21.0 Sq. In. Min. |
32.0 Sq. In. Min. |
|
|
|
Duct Size |
|
|
Depth |
1-1/2 In. Min. - 2-1/2 In. Max. |
2.0 In. Min. - 2-1/2 In. Max. |
Width |
7.0 In. Min. - 10.0 In. Max. |
8.0 In. Min. - 10.0 In. Max. |
Total Duct Length |
15.0 Ft. Min. - 40.0 Ft. Max. |
15.0 Ft. Min. - 40.0 Ft. Max. |
Duct Length (short run) |
1/3 Total Duct Length |
1/3 Total Duct Length |
|
|
|
Register Requirements |
|
|
Number Required Per Run |
4 Min. |
4 Min. |
Register Free Air Area |
14.0 Sq. In. |
14.0 Sq. In. |
Distance From Duct End |
5.0 In. Min. - 8.0 In. Max. |
5.0 In. Min. - 8.0 In. Max. |
Distance From Elbow |
15.0 In. |
15.0 In. |
|
|
|
Total System Static Air Pressure |
0.55 - 0.90 In. W.C. 579 Series |
0.55 - 0.90 In. W.C. 579 Series |
Blower at High Speed, |
0.40 - 1.10 In. W.C. 590, 591, 595 Series |
0.40 - 1.10 In. W.C. 590, 591, 595 Series |
Filter & Grill In Place |
0.12 - 0.65 In. W.C. 600 Series |
0.12 - 0.65 In. W.C. 600 Series |
|
|
|
Note: Duct sizes listed are inside dimensions.
6
Loading...