DOLLAMUR FLEXI-Roll Setup, Care And Handling

FLEXI-Roll®

Fitness, Gymnascs & Cheer Carpet

Setup, Care and Handling

CAUTION: This booklet is for the FLEXI-Roll series of Dollamur mats only. If you have the
Standard non-FLEXI-Roll series of Dollamur mats, please consult the appropriate booklet.
Please read all Care and Warning BEFORE installing mats.

www.dollamur.com

Part #: FRM-GYM Revised: 04-04-2017

WARNING
For Your Safety

We urge you to carefully read and consider the product safety warning section that
follows. It is included to increase your awareness of the precautions that must be
enforced in your gymnasium or sports facility to reduce the possibility of injury.

Any activity involving motion, height, speed, rotation, and/or physical contact creates
the possibility of serious injury, including paralysis and even death from landing or
falling on the neck, head, back or other parts of the body. This mat DOES NOT
eliminate this hazard. Users assume a risk of serious injury in using this product.
Users should strictly adhere to the following guidelines at all times:

1. Use this mat ONLY with proper training and under the supervision of a

qualied instructor. Use of this mat without proper supervision, proper spotting

equipment and/or trained spotters can be DANGEROUS and SHOULD NOT
be undertaken or permitted.

2. Always allow enough space to properly and safely perform the chosen
maneuvers.

3. Perform all maneuvers so as to avoid contact with instructors, bystanders, or
other users, and to avoid going outside the perimeter of this mat.

4. Inspect the mat prior to use and after any use. Inspect for damage, defects

or wear, including tears and attening of the energy absorbing material.

Damaged product should be repaired or replaced immediately. If in doubt, do
not use this product.

5. Mats can move during use. Before each use, always check the mat for proper
positioning and ensure mat is safely secured together. Read the owner manual
before initial use.

6. Under no circumstances should this mat be used as a landing mat.

7. Know your own limitations and the limitations of this product. Follow
progressive learning techniques and always consult an instructor.

8. Frequently clean mats according to the Dollamur MAINTENANCE WARNING
guidelines on Page 3 of this Guide.

Dollamur Sport Surfaces

1734 East El Paso Street, Ste. 110 | Fort Worth, TX 76102-6770

817-534-3344 | 800-520-7647

www.dollamur.com

2

FLEXI-Roll® Setup, Care and Maintenance

MAINTENANCE WARNING

The carpet surface of the mat should be cleaned like normal carpet. Vacuum to remove all loose
particles. Stains may be treated with a non-abrasive (no bleach) carpet cleaning solution. Spot test
a cleaner on a small area before using it to remove a stain. Contact your Dollamur representative
tor additional cleaning and disinfecting methods.

TEMPERATURE WARNING

Unlike conventional mats, the FLEXI-Roll® series requires a minimal temperature acclimatization
period after transport or storage. Once the mat is shipped or taken out of storage, it is immediately

ready for assembly in an open area. When tting to a custom area, allow 2 hours for the mat to relax

before cutting to size. The rolls should be used only after they have reached room temperature.

Dollamur mats are recommended for indoor use only and exposure to direct sunlight could damage

the mat and void the warranty..

DAMAGE TO ROLLS

Due to the way the FLEXI-Roll® mat is stored, with the foam on the outside protecting the carpet,
use care when transporting and storing the rolls. The mats should be stored away from any potential
puncture risk and should be handled cautiously when transporting through doorways and around

other obstacles. Mats should be stored upright on a smooth, at surface. Should your rolls incur

minor damage due to misuse or vandalism, contact your Dollamur representative for assistance.

ACCESSORIES

Hook Fastening Rolls

Fastening rolls are available in 4” wide by 42’ long and
are used to secure more than one carpeted Dollamur
mat.

SKU:COLORS:

BLK

NVY

LGY

GRN

RED

PRP

CGY

TEL

RED

PRP

PNK

CGY

Hook Fastening Boundary
Rolls

Rolls are available in 2” by 42’ long
for carpeted gymnastics mats,
used to mark out of bounds area.
Available only in white.

Colors:
SKU:

V-242-WHT Boundary Roll Hook
42’ Roll x 2” Wide - White Only

WHT

V-442-ccc Fastening Roll Hook
42’ Roll x 4” Wide

TEL

Storage Straps

ACC-STRAP-BLK-10

BLK

3

FLEXI-Roll® Setup, Care and Handling

Thank you for purchasing a Dollamur Mat. We appreciate your business and
value you as a customer. Please read all instructions carefully and follow all
handling guidelines for proper setup, removal and storage. Please contact
your sales representative or Customer Service if you have any questions.

Proper Handling

If rolling a strapped mat to a storage area, turn the mat so that you

1

2

continue rolling the same direction the FLEXI-Roll was rolled up.

A two-wheeled dolly is
an easy way to transport
rolls.

4

1

FLEXI-Roll® Setup Guidelines

Take care in removing packaging
from each roll. Using a sharp
object such as a utility knife can
damage mat if it cuts through
packaging material. Once the
outer packaging has been carefully

Fig. 1

removed from each roll, the mats
should be placed on their side

(g. 1).

Unfasten the straps around the

2

3

4

mat (g. 2). Store straps for future

use. DO NOT discard.

Unroll the mats so that the carpet

side is now facing up (g. 3).

Notice the way the mats are rolled,
carpet side facing in. This is how
the mats should be rolled for
storage and transport.

Once all of the rolls have been
rolled out, push them together to

form one large mat surface (g. 4).

Fig. 2

Fig. 3

DO NOT kick the edge of the rolls
to position them.

Fig. 4

5

5

FLEXI-Roll® Setup Guidelines

Always grab the edge of the roll
with your hands and push it into
place slowly to avoid damaging the

edges of the mat (g. 5).

After the individual rolls have been

6

lined up side by side, eliminating
any gaps, center Dollamur Hook
& Loop Mat Fastener over each

seam (g. 6) and secure it rmly to

the carpet.

FLEXI-Roll® Storage Guidelines

Remove all hook & loop. Roll

1

the mats back up, carpet side
in. Begin rolling by folding one

section over to form a triangle (g.

7). Make sure to keep the mat
tight.

Fig. 5

Fig. 6

Fig. 7

6

2

Keep the edges square (g. 8).

Avoid coning of the roll by moving
slowly as the mat is rolled.

Fig. 8

FLEXI-Roll® Storage Guidelines

Storage Guidelines (cont.)

Afx straps approximately 18

3

inches from the edges of the mat.
Roll the mat until it is in the middle

of the straps (g. 9).

You can now secure the straps

Fig. 9

4

5

around the mat (g. 10). If rolling

to a storage area, turn the roll
so that you continue rolling the
same direction the FLEXI-Roll was
rolled up. See Page 4 for proper
handling.

Fig. 10

If coning does occur, stand the

mat up on end (g.11). Make sure

the straps are secured before
standing the mat on end.

Fig. 11

6

Shake the mat gently back and
forth until its edges line up

(g. 12).

Fig. 12

7

DOLLAMUR LIMITED WARRANTY

Dollamur Sport Surfaces (“Dollamur”) offers a limited warranty on all of its products (“Dollamur
Warranty”). The Dollamur Warranty period for each type of product is as follows:

Dollamur Product Type

Custom Vinyl Sports Mats

Swain Martial Arts Mats

GymTurf Indoor Sports Turf

Carpet-bonded Sports Mats

Dollamur warrants that its products will be free from defects in materials or workmanship with proper
installation and normal use and care for the warranty period stated above.

The Dollamur Warranty is only valid if:

• The mat was received and installed in full accordance with the Care & Handling Manual provided
with the mat delivery and available online at www.dollamur.com; and,

• The mat has been subjected to normal use for which the mat was intended, and the mat has
been cared-for on a regular basis per the Care & Handling Manual instructions; and,

• The mat has not been subjected to vandalism, misuse, neglect, accident, extended improper

storage, nor has the mat been altered in any way.

5-Year Limited Warranty

• 100% replacement in years 1, 2, 3

• 50% replacement in year 4

• 25% replacement in year 5

10-Year Limited Warranty

• 100% replacement in years 1, 2, 3

• 50% replacement in year 4

• 40% replacement in year 5

• 30% replacement in year 6

• 20% replacement in year 7

• 10% replacement in years 8, 9, 10

3-Year Limited Warranty

• 100% replacement in year 1

• 66.7% replacement in year 2

• 33.3% replacement in year 3

3-Year Limited Warranty; 100% replacement

Warranty Period

8

The Dollamur Warranty is subject to normal wear and tear of the mat with normal use. The Warranty
does not cover any cosmetic changes to the mat, such as scuff marks, denting or compression from
handling or storage, and any fading or marring of the mat.

The FLEXI-Connect® system falls fully under the Dollamur Warranty; except, however, the Dollamur
Warranty does NOT cover damage to the FLEXI-Connect® system due to improper handling of the
mat.

Return and replacement freight of any valid warranty claim is covered as follows:

• Dollamur will pay 100% of the return and/or replacement freight if the valid warranty claim is

made during the rst year after the mat was purchased;

• Dollamur will pay 50% of the return and/or replacement freight if the valid warranty claim is
made during the second or third years after the mat was purchased;

• The customer is responsible for paying all return and/or replacement freight after the third year
following the date the mat was purchased.

Dollamur reserves the exclusive right to consider all warranty claims submitted by its customers and

to make warranty claim decisions on a case-by-case basis in its sole discretion.

© Dollamur Sport Surfaces 2017