Dixon 8000G User Manual
ZTR®
8000G SERIES
OPERATORS MANUAL
2003
IMPORTANT - READ CAREFULLY
The Dixon® ZTR® Mower is both easy and fun to operate.
However, any power mower must be operated properly to be
safe. It is not a toy or a recreational vehicle. Before you
start to use the mower, read the operators manual carefully
and become completely familiar with the controls.
The information contained in this manual applies to all
Dixon® ZTR® 8000 Series (Gas Version) Commercial
Mowers. Your Dixon dealer will gladly answer any questions.
See your dealer for warranty service, parts and repairs.
INDEX
Page
Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Warranty Policy. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Controls. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14-18
Operation Instructions. . . . . . . . . . . . . . . . . . . 19-26
Care & Maintenance. . . . . . . . . . . . . . . . . . . . . .27-38
Standard Service Parts List. . . . . . . . . . . . . . . . . . . .39
Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . .40-41
8000 Series (Gas)
Part No. 13637-xxxx
3
SAFETY
RIDING LAWN MOWERS,
IF IMPROPERLY OPERATED,
CAN CAUSE SERIOUS INJURY OR DEATH.
The most common causes of injury to the operator or bystander...
BLADE CONTACT
TIP OVER
RUN OVER
BACK OVER
...read and understand this manual to prevent injuries.
4
SAFETY
Safety Alert Symbol
When you see this symbol,
BE ALERT to the potential for injury.
Follow recommended safety precautions
and safe operating practices.
DANGER
(highlighted in red)
indicates an imminently hazardous
situation which, if not avoided, will
result in death or serious injury.
WARNING
(highlighted in orange)
indicates a potentially
hazardous situation which, if not
avoided, could result in death or
serious injury.
CAUTION
(highlighted in yellow)
indicates a potentially
hazardous situation which, if not
avoided, may result in minor or
moderate injury. It may also be used
to alert against unsafe practices.
5
Failure to observe the following safety
instructions could result in serious injury or death.
GENERAL OPERATION:
Read, understand, and follow all instructions in the manual
and on the mower before starting.
Only allow responsible adults, who are familiar with the
instructions, to operate the mower.
Clear the area of objects such as rocks, toys, wire, etc.,
which could be picked up and thrown by the blade.
Be sure the area is clear of other people before mowing.
Stop mower if anyone enters the area.
NEVER carry passengers.
SAFETY
Do not mow in reverse unless absolutely necessary. Always
look down and behind before and while backing.
Be aware of the mower discharge direction and do not point
it at anyone.
Do not operate the mower without either the entire grass
catcher or the deflector in place.
Slow down before turning.
Never leave a running mower unattended. Always turn off
blades, set parking brake, stop engine and remove key before
dismounting.
6
SAFETY
GENERAL OPERATION (continued):
Turn off blades when not mowing.
Stop engine before removing grass catcher or unclogging
chute.
Mow only in daylight or good artificial light.
Do not operate the mower while under the influence of
alcohol or drugs.
Watch for traffic when operating near or crossingroadways.
Use extra care when loading or unloading the mower into a
trailer or truck. Do not ride the mower when loading and
unloading.
Always wear safety goggles or safety glasses with side
shields when operating mower.
Data indicates that operators, age 60 years and above, are
involved in a large percentage of riding mower-related
injuries. These operators should evaluate their ability to
operate the riding mower safely enough to protect
themselves and others from serious injury.
Follow the manufacturers recommendation for wheel
weights and counterweights.
•Maintain or replace safety & instruction labels as needed.
WARNING:
The engine exhaust from this product contains chemicals known to the State of
California to cause cancer, birth defects or other reproductive harm.
7
SLOPE OPERATION:
SAFETY
Slopes are a major factor related to loss-of-control and tip-over accidents,
If you cannot back up the slope or if you feel uneasy on it,
DO
which can result in severe injury or death.
All slopes require extra caution.
do not mow it!
Mow across the slope with your Dixon ZTR - never up or down.
Remove obstacles such as rocks, tree limbs, etc.
Watch for holes, ruts or bumps. Uneven terrain could overturn the
mower. Tall grass can hide obstacles.
Use slow speed. Tires may lose traction on slopes even though the
brakes are functioning properly.
Use extra care with grass catchers or other attachments. These can
change the stability of the mower.
Keep all movement on the slopes slow and gradual. Do not make
sudden changes in speed or direction.
Avoid starting or stopping on a slope. If tires lose traction, disengage
the blades and proceed slowly down the slope.
If front wheels lift off the ground, pull the levers back to stabilize the
mower.
DO NOT
Do not turn on slopes unless necessary, and then, turn slowly and
gradually downhill, if possible.
Do not mow near drop-offs, ditches, or embankments. The mower
could suddenly turn over if a wheel is over the edge of a cliff or ditch,
or if an edge caves in.
Do not mow on wet grass. Reduced traction could cause sliding.
Do not try to stabilize the mower by putting your foot on the ground.
Do not use grass catcher on steep slopes.
8
SAFETY
CHILDREN:
Tragic accidents can occur if the operator is
not alert to the presence of children.
Children are attracted to lawn mowers and the mowing activity.
NEVER assume children will stay where they were last seen.
Be alert to avoid accidents.
Keep children out of the mowing area and under the
watchful care of another responsible adult.
Be alert and turn mower off if a child enters the area.
Before and during backing, look BEHIND and DOWN for
small children.
Never carry children. They may fall off and be seriously
injured or interfere with safe mower operation.
Never allow children to operate the mower.
Use extra care when approaching blind corners, shrubs,
trees, or other objects that may obscure vision.
9
SAFETY
SERVICE:
Use extra care in handling gasoline and other fuels. They are
flammable and vapors are explosive.
Use only an approved container.
Never remove fuel cap or add fuel with engine running.
Allow engine to cool before refueling.
Do not smoke while refueling.
Never refuel the mower indoors.
Never store the mower or fuel container inside a building
where there is an open flame.
If fuel is spilled on clothing, change clothing immediately.
To prevent fire and explosion caused by static electricity:
Never fill containers inside a vehicle or on a truck
or trailer bed with a plastic liner. Always place
containers on the ground away from your vehicle
before filling.
10
When practical, remove fuel-powered equipment
from the truck or trailer and refuel it on the
ground. If this is not possible, then refuel such
equipment on a trailer with a portable container,
rather than from a fuel dispenser nozzle.
If a fuel dispenser nozzle must be used, keep the
nozzle in contact with the rim of the fuel tank or
container opening at all times until fueling is
complete. Do not use a nozzle lock-open device.
SAFETY
SERVICE (continued):
Never run a mower inside a closed area. The exhaust fumes are
toxic.
Keep nuts and bolts tight, especially blade attachment bolts, and
keep equipment in good condition.
Never tamper with safety devices. Check their proper operation
regularly.
Keep mower free of grass, leaves, or other debris buildup. Clean
up oil or fuel spillage. Allow mower to cool before storing.
Stop and inspect the equipment if you strike an object. Repair,
if necessary, before restarting.
Never make adjustments or repairs with the engine running
unless otherwise specified.
Grass catcher components are subject to wear, damage and
deterioration, which could expose moving parts or allow objects
to be thrown. Frequently check components and replace with
original equipment parts, when necessary.
Mower blades are sharp and can cut. Wrap the blade(s) or wear
gloves, and use extra caution when servicing them.
Batteries contain sulfuric acid. To prevent burns avoid contact
with skin, eyes and clothing. To prevent a fire or explosion keep
sparks and open flames away from battery.
Before disconnecting the negative (-) ground cable, make sure all
switches are OFF.
11
DIXON INDUSTRIES, INC.
a BLOUNT company
Airport Industrial Park
P.O. Box 1569
Coffeyville, Ks 67337- 0945
620-251-2000
Fax 620-251-4117
DIXON LIMITED WARRANTY POLICY - COMMERCIAL MODELS
8000 Series
WARRANTY: Home Owner Application: This Dixon Warranty term is for a period of three (3)
years from date of purchase. Commercial Application: Dixon mowers used for commercial
application are warranted for one (1) year from the date of purchase or 750 hours whichever
comes first. Commercial use is specified as use other than, or in addition to, mowing at owners
primary place of residence.
DIXON ZTR MOWERS ARE WARRANTED AGAINST DEFECTS IN MATERIALS
AND WORKMANSHIP AND PROVIDES FOR REPLACEMENT OR REPAIR OF
PARTS INCLUDING LABOR COSTS. THIS WARRANTY IS SUBJECT TO THE
1. Warranty applies only to original retail purchaser of new & unused mowers & accessories.
2. All Dixon warranty must be accomplished by authorized Dixon dealers and in accordance with Dixon
warranty policy and allowances. All warranty claims must be approved by Dixon Industries, Inc.
3. Battery warranty: Limited to 90 days from date of purchase.
4. Accessories Warranty (Grass Catchers, Snow Blades, Covers, etc.): Limited to 90 days from date of
purchase.
5. Warranty does not apply to damage in transit or incidents of misuse, negligence, accidents, or
alteration. The use of parts or components other than those supplied by Dixon Industries, Inc. VOIDS
ALL WARRANTY.
6. The following items are not covered by this warranty policy:
a. Pick up and delivery charges for transportation of mower to and from an authorized Dixon
b. Routine maintenance or adjustments.
c. Belts/cutting blades/hydrostatic filters.
d. Engines - All engines used on Dixon ZTR mowers are warranted by the individual engine
e. Any costs or expense of providing substitute equipment while repair work is being
7. There is no other express warranty. Implied warranties, including those of merchantability and fitness
for a particular purpose, are limited to the same duration of the express warranty, and to the extent
permitted by law any and all implied warranties are excluded. Liabilities for consequential damages
under any and all warranties are excluded.
WARRANTY VALIDATION: At the time of sale, selling dealer must review each portion of this
warranty document, complete the information section below, secure customers signature &
send copy to Dixon Industries, Inc.
DATE OF PURCHASE____________________MODEL___________________S/N_______________
_____________________________________ ______________________________________
Owners Name Dealership
_____________________________________ ______________________________________
Address Address
______________________________________ _______________________________________
dealers place of business.
manufacturer.
performed on a warranted mower.
_____________________________ ______________________________
Owners Signature Dealers Signature
FOLLOWING CONDITIONS AND LIMITATIONS:
Blue/Customer Yellow/Dealer White/Dixon Ind.
12
SPECIFICATIONS
8000 Series (Gas Version)
CHASSIS: 11 GA - rectangular tube, 7 GA reinforcement
SEAT: Designed for operator comfort with padded back & arm
MOWER DECK: 2 decks are available. Both decks are made of 10 GA
BLADE DRIVE: "V" Belt with Electric clutch
DRIVE SYSTEM: Each rear wheel is independently driven by a HydroGear BDP-
ENGINE: 25HP Kohler Command, 4-Cycle, V-Configuration, Overhead
STARTING SYSTEM: Electric by key switch operation with safety interlocks on
TIRES: Front 13-6.5x6
RECOMMENDED Front 16-20 lbs.
TIRE PRESSURE: Rear 8-14 lbs.
rests. Seat is adjustable fore & aft. Seat back tilts. Mounted
on operator suspension system with damper.
fabricated welded construction with 1/4 " reinforcement
plate. 3 blades combine for either a 60" or 72" cut width. Deep
deck with discharge tunnel. Cut height approximately 1.5" to
6" via 10 position lift handle.
10A pump and White CE wheel motor.
Valve, Air-Cooled, Gasoline, Horizontal Shaft, Aluminum Head
and Crankcase with Cast Iron Liners, Full Pressure
Lubrication/Full Flow Filter, Pulse-type Fuel Pump, Fixed Jet
Carburetor, Electronic Ignition, In-Line Fuel Filter, Dual Element
Air Cleaner.
parking brake, blade drive clutch and control levers.
Rear 23-10.5x12
CAPACITIES: Fuel - 11 gallons (approx)
Hydrostat oil system - 4 quart with in-line 40 micron filter
Hydrostat oil recommendation - SAE 20W50 motor oil
Engine - 2 quart. SAE 10W30 motor oil
DIMENSIONS: Width 73.5"(60" Deck), 85.5"(72" Deck)
NOTE: Additional information provided in service instructions under the individual component.
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE.
Height 54"
Length 87"
Weight 1020 lbs.(60" Deck), 1054 lbs.(72" Deck)
13
CONTROLS
CONTROL LEVERS
Note: For access to the seat, move control levers to neutral position and
swing them outward.
TO GO FORWARD:
•From neutral position, gently push both control levers forward.
•To increase speed, move levers further forward.
TO GO BACKWARD:
•From neutral position, gently pull both control levers toward you.
TURNING:
•Turning is controlled by moving one control lever slightly forward or
rearward of the other.
•To turn left, move left lever rearward of the right lever.
•To turn right, move right lever rearward of the left lever.
•To turn on mowers own axis (zero turning radius), stop and move one
lever to reverse position and the other to forward position.
BRAKING:
•To brake mower, move both levers in direction opposite of travel.
LEFT TURN OPPOSITE
Note: The pressure required to operate the mower is very light.
14
Loading...