SAFETY DATA SHEET
Mr. Muscle Oven and Grill Cleaner
Version Number: 2 Preparation date: 2015-01-13
1. IDENTIFICATION
Product name:
Product Code:
SDS #:
Recommended use:
Uses advised against:
Manufacturer, importer, supplier:
Consumer Branded Professional Products
Diversey, Inc.
8310 16th Street
Sturtevant, Wisconsin 53177-1964
Phone: (888) 352-2249
Emergency telephone number:
Mr. Muscle Oven and Grill Cleaner
991206
MS0800125
• Industrial/Institutional
• Oven and Grill Cleaner
Uses other than those identified are not recommended
Canadian Headquarters
Diversey, Inc. - Canada
3755 Laird Road
Mississauga, Ontario L5L 0B3
Phone: 1-800-668-3131
1-800-851-7145 (U.S.); 1-651-917-6133 (Int'l)
2. HAZARDS IDENTIFICATION
Classification for the undiluted product
Skin corrosion/irritation Category 1B
Serious eye damage/eye irritation Category 1
Flammability Extremely flammable aerosol, Category 1
Metal Corrosion: Category 1
Signal Word: Danger
Precautionary Statements
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED. CAUSES SEVERE SKIN BURNS
AND SERIOUS EYE DAMAGE. MAY BE CORROSIVE TO METALS.
Causes burns/ serious damage to mouth, throat and stomach. Avoid contact with eyes, skin and clothing. Keep away from heat, hot surfaces,
sparks, open flames and other ignition sources. No smoking. Do not spray on an open flame or other ignition source. Keep container tightly closed.
Keep only in original container. Do not pierce or burn, even after use. Do not incinerate. Do not breathe spray. Wash affected areas thoroughly after
handling. Wear chemical–splash goggles, long chemical-resistant gloves and protective footwear when spraying and wiping. Do not spray towards
face. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF
ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes. IF INHALED: Remove person to
fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. Wash contaminated clothing
before reuse. Absorb spillage to prevent material damage. Store in corrosive-resistant container with a resistant inner liner. Protect from sunlight.
Store in a well-ventilated place. Do not expose to temperatures exceeding 50 °C (122 °F) which may cause bursting. Dispose of in accordance with
all federal, state and local applicable regulations.
Mr. Muscle Oven and Grill Cleaner
1 of 5
Health hazards not otherwise classified (HHNOC) - Not applicable
Physical hazards not otherwise classified (PHNOC) - Not applicable
Classification for the diluted product @ RTU
This product is intended to be used neat.
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Ingredient(s) CAS # Weight %
Diethylene glycol butyl ether 112-34-5 10 - 20%
Sodium hydroxide 1310-73-2 3% - < 5%
Butane 106-97-8 1% - < 3%
Isobutane 75-28-5 1% - < 3%
Monoethanolamine 141-43-5 1% - < 3%
*Exact percentages are being withheld as trade secret information
4. FIRST AID MEASURES
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Most Important Symptoms/Effects: No information available.
Immediate medical attention and special treatment needed Not applicable.
Aggravated Medical Conditions: Individuals with chronic respiratory disorders such as asthma, chronic bronchitis, emphysema, etc., may be
more susceptible to irritating effects.
Diluted Product:
This product is intended to be used neat.
Eyes: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Skin: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Inhalation: No specific first aid measures are required
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Specific methods:
Suitable extinguishing media:
Specific hazards:
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
Use water spray to keep fire-exposed containers cool Aerosol Product - Containers may rocket or
explode in heat of fire
Dry chemical, water spray, foam.
NFPA 30B Level 1 Aerosol. Aerosol product - Containers may rocket or explode in heat of fire.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions:
Environmental precautions
and clean-up methods:
Mr. Muscle Oven and Grill Cleaner 2 of 5
Remove all sources of ignition. Put on appropriate personal protective equipment (see Section 8.).
Prevent product from entering drains. Soak up with inert absorbent material. Sweep up and shovel into
suitable containers for disposal. Use a water rinse for final clean-up.
7. HANDLING AND STORAGE
Handling: Avoid contact with skin, eyes and clothing. Avoid breathing vapors or mists. ALWAYS WEAR LONG CHEMICAL-RESISTANT
GLOVES, CHEMICAL-SPLASH GOGGLES AND PROTECTIVE FOOTWEAR WHEN SPRAYING AND WIPING. Do not spray toward face. Wash
hands and arms after use. Do not spray on or let spray contact pilot light, electrical connections, switches, light bulbs, heating elements,
receptacles, or thermostats. Spray may cause electric short. Do not let product contact floor coverings, linoleum, aluminum, copper, chrome,
painted surfaces or plastics. Do not use on continuous or self-cleaning ovens. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage:
Protect from freezing. Keep out of the reach of children. Pressurized container: protect from sunlight and do not expose to temperatures exceeding
50 degrees C or 120 degrees F. Exposure to heat may cause bursting. Do not pierce or burn, even after use. Store in a cool, dry, well ventilated
area away from heat or open flame.
Aerosol Level (if applicable) : Level 1
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Exposure Guidelines:
Ingredient(s) CAS # ACGIH OSHA
Diethylene glycol butyl ether 112-34-5 10 ppm (TWA) -
Sodium hydroxide 1310-73-2 2 mg/m3 (Ceiling) 2 mg/m3 (TWA)
Isobutane 75-28-5 1000 ppm (STEL) -
Butane 106-97-8 1000 ppm (STEL) -
Monoethanolamine 141-43-5 6 ppm (STEL)
.
3 ppm (TWA)
3 ppm (TWA)
6 mg/m3 (TWA)
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels Respiratory protection is not required if good ventilation is maintained.
Personal Protective Equipment
Eye protection:
Hand protection:
Skin and body protection:
Respiratory protection:
Hygiene measures:
Chemical-splash goggles.
Long chemical-resistant gloves.
Protective footwear. If major exposure is possible, wear suitable protective clothing and footwear.
In case of insufficient ventilation wear suitable respiratory equipment. A respiratory protection program
that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements must be followed whenever
workplace conditions warrant a respirator's use.
Handle in accordance with good industrial hygiene and safety practice.
Diluted Product:
This product is intended to be used neat.
Personal Protective Equipment
Eye protection:
Hand protection:
Skin and body protection:
Respiratory protection:
Hygiene measures:
Chemical-splash goggles.
Long chemical-resistant gloves.
Protective footwear. If major exposure is possible, wear suitable protective clothing and footwear.
In case of insufficient ventilation wear suitable respiratory equipment. A respiratory protection program
that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements must be followed whenever
workplace conditions warrant a respirator's use.
Handle in accordance with good industrial hygiene and safety practice.
9. PHYSICAL AND CHEMICAL PROPERTIES:
Physical State: Aerosol Color: Tan
Evaporation Rate: No information available Odor: Citrus
Odor threshold: No information available. Boiling point/range: Not determined
Melting point/range: Not determined Decomposition temperature: Not determined
Autoignition temperature: No information available Solubility: Completely Soluble
Solubility in other solvents: No information available Relative Density (relative to water): 1.049
Density: 8.75 lbs/gal 1.049 Kg/L Vapor density: No information available
Bulk density: No information available Vapor pressure: No information available.
Flash point: 19 °F -7 °C Partition coefficient (n-octanol/water): No information available
Dilution Flash Point: 19 °F -7 °C Viscosity: No information available
Elemental Phosphorus: 0 % by wt. VOC: 7.9 % *
pH: 13
Dilution pH: 13 @ RTU Flammability (Solid or Gas): Not applicable
Metal Corrosion: Not determined
Mr. Muscle Oven and Grill Cleaner 3 of 5
VOC % by wt. at use dilution 7.9 % *
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
10. STABILITY AND REACTIVITY
Reactivity:
Stability:
Hazardous decomposition products:
Materials to avoid:
Conditions to avoid:
Not Applicable
The product is stable
None reasonably foreseeable.
Strong oxidising agents. Strong acids.
Keep away from open flames, hot surfaces and sources of ignition.
11. TOXICOLOGICAL INFORMATION
Information on likely routes of exposure:
Skin contact, Inhalation, Eye contact, Ingestion
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Numerical measures of toxicity
ATE - Oral (mg/kg):
ATE - Dermal (mg/kg):
ATE - Inhalatory, mists (mg/l):
ATE - Inhalatory, vapors (mg/l):
>5000 mg/kg
>5000 mg/kg
>20 mg/L
>50 mg/L
12. ECOLOGICAL INFORMATION
Ecotoxicity: No information available.
Persistence and Degradability: No information available.
Bioaccumulation: No information available.
13. DISPOSAL CONSIDERATIONS
Waste from residues / unused products: This product, as sold, if discarded or disposed, is a hazardous waste according to Federal regulations
(40 CFR 261.4 (b)(4)). Dispose in compliance with all Federal, state, provincial, and local laws and regulations.
Contaminated Packaging: Do not re-use empty containers.
RCRA Hazard Class (undiluted product): D001 Ignitable Waste, D002 Corrosive Waste
14. TRANSPORT INFORMATION
DOT/TDG/IMDG: Please refer to the Diversey HazMat Library, only available through Internet Explorer, http://naextranet.diversey.com/dot/, for up
to date shipping information.
DOT (Ground) Bill of Lading Description:
IMDG (Ocean) Bill of Lading Description:
LTD. QTY.
UN1950, AEROSOLS, 2.1, LTD. QTY.
15. REGULATORY INFORMATION
Mr. Muscle Oven and Grill Cleaner 4 of 5
International Inventories at CAS# Level
All components of this product are listed on the following inventories: U.S.A. (TSCA), Canada (DSL/NDSL).
U.S. Regulations
California Proposition 65: This product is not subject to the reporting requirements under California's Proposition 65.
RIGHT TO KNOW (RTK)
CERCLA/ SARA
SARA 311/312 Hazard Categories
Ingredient(s) CAS # MARTK: NJRTK: PARTK: RIRTK:
Water 7732-18-5 - - - -
Diethylene glycol butyl ether 112-34-5 - X - -
Sodium hydroxide 1310-73-2 X X X X
Butane 106-97-8 X X X -
Isobutane 75-28-5 X X X -
Monoethanolamine 141-43-5 X X X -
Ingredient(s) CAS # Weight % CERCLA/SARA RQ (lbs) Section 302 TPQ (lbs) Section 313
Diethylene glycol butyl ether 112-34-5 10 - 20% X
Sodium hydroxide 1310-73-2 3% - < 5% 1000
Ingredient(s) CAA HAP CAA ODS CWA Priority Pollutants
Diethylene glycol butyl ether X
Immediate:
Delayed:
Fire:
Reactivity:
Sudden Release of Pressure:
Ingredient(s) CAS # NPRI
Diethylene glycol butyl ether 112-34-5 X
X
X
X
16. OTHER INFORMATION
NFPA (National Fire Protection Association)
Rating Scale: (Low Hazard) 0 - 4 (Extreme Hazard)
Health 3
Flammability 4
Instability 0
Version Number: 2
Preparation date: 2015-01-13
Reason for revision:
Prepared by:
Additional advice:
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Mr. Muscle Oven and Grill Cleaner 5 of 5
Not applicable
NAPRAC
• NFPA 30B Level 1 Aerosol
• Contains an added fragrance, see "Odor" heading in section 9 for specific description
Loading...