Page 1
SAFETY DATA SHEET
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based
Disinfectant
Version Number: 1 Preparation date: 2014-10-09
1. IDENTIFICATION
Product name:
Product Code:
SDS #:
Recommended use:
Uses advised against:
Manufacturer, importer, supplier:
US Headquarters
Diversey, Inc.
P.O. Box 19747
Charlotte, NC 28219-0747
Phone: 1-888-352-2249
SDS Internet Address: https://sds.sealedair.com
Emergency telephone number:
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant
04329, 04331, 04332, 3062637, 3062768, 5019317, 5271416
MS0800549
• Disinfectant
• This product is intended to be diluted prior to use
Uses other than those identified are not recommended
1-800-851-7145 (U.S.); 1-651-917-6133 (Int'l)
2. HAZARDS IDENTIFICATION
Classification for the undiluted product
Acute oral toxicity Category 4
Skin corrosion/irritation Category 1B
Serious eye damage/eye irritation Category 1
Flammability Combustible liquid, Category 4
Signal Word: Danger.
Precautionary Statements
CAUSES SEVERE SKIN BURNS AND SERIOUS EYE DAMAGE. HARMFUL IF SWALLOWED. COMBUSTIBLE LIQUID.
Causes burns/ serious damage to mouth, throat and stomach. Avoid contact with eyes, skin and clothing. Keep container tightly closed. Do not
breathe spray. Wash affected areas thoroughly after handling. Do not eat, drink or smoke when using this product. Wear chemical-splash goggles,
chemical-resistant gloves and protective footwear. Keep away from flames and hot surfaces. No smoking. Store in a well-ventilated place. Keep
cool. IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or water. IF
ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes. IF INHALED: Remove person to
fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing for at least 15 minutes. Immediately call a Poison Center (1-800-851-7145) or physician. Wash contaminated clothing
before reuse. In case of fire: Use CO2, dry chemical, or foam to extinguish. Dispose of in accordance with all federal, state and local applicable
regulations. SUPPLEMENTAL INFORMATION:. Mix only with water. DO NOT MIX WITH BLEACH OR ANY OTHER PRODUCT OR CHEMICAL.
Virex II 256 One-Step Disinfectant
Cleaner and Deodorant; Quat Based
Disinfectant
1 of 6
Page 2
Can react to release chlorine gas.
Health hazards not otherwise classified (HHNOC) - Not applicable
Physical hazards not otherwise classified (PHNOC) - Not applicable
Percentage of unknown Acute Toxicity
1.23001
Classification for the diluted product @ 1:256
This product, when diluted as stated on the label, is not classified as hazardous according to OSHA 29CFR 1910.1200 (HazCom 2012-GHS) and
Canadian Hazardous Products Regulations (HPR) (WHMIS 2015-GHS).
Precautionary Statements
None required.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Classified Ingredients
Didecyl dimethyl ammonium chloride 7173-51-5 5 - 10%
n-alkyl dimethyl benzyl ammonium chloride 68424-85-1 5 - 10%
Ingredient(s) CAS # Weight %
Ethyl alcohol 64-17-5 3% - < 5%
Tetrasodium salt of EDTA 64-02-8 1% - < 3%
Lauryl dimethyl amine oxide 1643-20-5 1% - < 3%
Sodium sesquicarbonate 533-96-0 1% - < 3%
*Exact percentages are being withheld as trade secret information
4. FIRST AID MEASURES
Undiluted Product:
Eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing for at least
15 minutes.
Skin: IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water for at least 15 minutes.
Inhalation: IF INHALED: Remove person to fresh air and keep comfortable for breathing.
Ingestion: IF SWALLOWED: Rinse mouth. DO NOT induce vomiting unless directed to do so by medical personnel. Drink a cupful of milk or
water.
Notes to physician: Probable mucosal damage may contraindicate the use of gastric lavage.
Most Important Symptoms/Effects: No information available.
Immediate medical attention and special treatment needed Not applicable.
Aggravated Medical Conditions: Individuals with chronic respiratory disorders such as asthma, chronic bronchitis, emphysema, etc., may be
more susceptible to irritating effects.
Diluted Product:
Eyes: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Skin: Rinse with plenty of water If irritation occurs and persists, get medical attention.
Inhalation: No specific first aid measures are required
Ingestion: Rinse mouth with water.
5. FIRE-FIGHTING MEASURES
Specific methods:
Suitable extinguishing media:
Specific hazards:
Special protective equipment for firefighters: As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH
(approved or equivalent) and full protective gear.
Extinguishing media which must not be used for safety reasons: No information available.
No special methods required
Use dry chemical, CO2, water spray or "alcohol" foam.
Although this product has a flash point below 200 Deg. F, it is an aqueous solution containing an
alcohol and does not sustain combustion.
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 2 of 6
Page 3
6. ACCIDENTAL RELEASE MEASURES
Personal precautions:
Environmental precautions
and clean-up methods:
Put on appropriate personal protective equipment (see Section 8.).
Clean-up methods - large spillage. Remove all sources of ignition. Absorb spill with inert material (e.g.
dry sand or earth), then place in a chemical waste container. Use a water rinse for final clean-up.
7. HANDLING AND STORAGE
Handling: Can react to release chlorine gas. Avoid contact with skin, eyes and clothing. Do not taste or swallow. Avoid breathing vapors or mists.
Use only with adequate ventilation. Remove and wash contaminated clothing and footwear before re-use. Wash thoroughly after handling. Product
residue may remain on/in empty containers. All precautions for handling the product must be used in handling the empty container and residue.
COMBUSTIBLE LIQUID AND VAPOR. Use only in well-ventilated areas. Mix only with water. DO NOT MIX WITH BLEACH OR ANY OTHER
PRODUCT OR CHEMICAL. FOR COMMERCIAL AND INDUSTRIAL USE ONLY.
Storage: Protect from freezing. Keep tightly closed in a dry, cool and well-ventilated place. KEEP OUT OF REACH OF CHILDREN.
Aerosol Level (if applicable) : Not applicable
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Exposure Guidelines:
Ingredient(s) CAS # ACGIH OSHA
Didecyl dimethyl ammonium chloride 7173-51-5 - -
n-alkyl dimethyl benzyl ammonium chloride 68424-85-1 - -
Ethyl alcohol 64-17-5 1000 ppm (STEL) 1000 ppm (TWA)
Tetrasodium salt of EDTA 64-02-8 - -
Lauryl dimethyl amine oxide 1643-20-5 - -
Sodium sesquicarbonate 533-96-0 - -
Undiluted Product:
Engineering measures to reduce exposure:
Good general ventilation should be sufficient to control airborne levels Respiratory protection is not required if good ventilation is maintained.
.
1900 mg/m3 (TWA)
Personal Protective Equipment
Eye protection:
Hand protection:
Skin and body protection:
Respiratory protection:
Hygiene measures:
Chemical-splash goggles.
Chemical-resistant gloves.
Protective footwear. If major exposure is possible, wear suitable protective clothing and footwear.
In case of insufficient ventilation wear suitable respiratory equipment. A respiratory protection program
that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements must be followed whenever
workplace conditions warrant a respirator's use.
Handle in accordance with good industrial hygiene and safety practice.
Diluted Product:
Personal Protective Equipment
Eye protection:
Hand protection:
Skin and body protection:
Respiratory protection:
Hygiene measures:
No personal protective equipment required under normal use conditions.
No personal protective equipment required under normal use conditions.
No personal protective equipment required under normal use conditions.
No personal protective equipment required under normal use conditions.
Handle in accordance with good industrial hygiene and safety practice.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Liquid Color: Clear, Blue
Evaporation Rate: No information available Odor: Minty
Odor threshold: No information available. Boiling point/range: Not determined
Melting point/range: Not determined Decomposition temperature: Not determined
Autoignition temperature: No information available Solubility: Completely Soluble
Solubility in other solvents: No information available Relative Density (relative to water): 1.0
Density: 8.34 lbs/gal 1 Kg/L Vapor density: No information available
Bulk density: No information available Vapor pressure: No information available.
Flash point: 187 °F 86.1 °C Partition coefficient (n-octanol/water): No information available
Dilution Flash Point: > 200 °F > 93.3 °C Viscosity: No information available
Elemental Phosphorus: 0.00 % by wt. VOC: 3.58 % *
pH: 10.2 VOC % by wt. at use dilution 0.01 % *
Dilution pH: 8.8 @ 1:256 Flammability (Solid or Gas): Not applicable
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 3 of 6
Page 4
Metal Corrosion: Not determined
Explosion limits: - upper: Not determined - lower: Not determined
* - Title 17, California Code of Regulations, Division 3, Chapter 1, Subchapter 8.5, Article 2, Consumer Products, Sections 94508
10. STABILITY AND REACTIVITY
Reactivity:
Stability:
Hazardous decomposition products:
Materials to avoid:
Conditions to avoid:
Not Applicable
The product is stable
None reasonably foreseeable.
Oxidizing agents. Anionic surfactant. Do not mix with chlorinated products (such as bleach).
Keep away from heat. Keep away from open flames, hot surfaces and sources of ignition. Do not mix
with any other product or chemical.
11. TOXICOLOGICAL INFORMATION
Information on likely routes of exposure:
Eye contact, Skin contact, Inhalation, Ingestion
Delayed, immediate, or chronic effects and symptoms from short and long-term exposure
Skin contact: Corrosive. Causes severe burns. Symptoms may include burns, blisters, redness and pain (which may be delayed).
Eye contact: Corrosive. Causes serious eye damage. Symptoms may include pain, burning sensation, redness, watering, blurred
vision or loss of vision.
Ingestion: Causes burns/ serious damage to mouth, throat and stomach. Symptoms may include stomach pain and nausea.
Harmful if swallowed. Symptoms may include vomiting, nausea, and/or feeling of general unwellness.
Inhalation: May cause irritation and corrosive effects to nose, throat and respiratory tract. Symptoms may include coughing and
difficulty breathing.
Sensitization: No known effects.
Target Organs (SE): None known
Target Organs (RE): None known
Carcinogen Listings: Statment per route of exposure or specific component Ethyl alcohol is only classified as an IARC 1
carcinogen when it is meant for ingestion in alcoholic beverages. We do not produce alcoholic beverages; therefore it is not
considered a carcinogen in our products.
Ingredient(s) CAS # NTP IARC OSHA
Ethyl alcohol 64-17-5 -
Numerical measures of toxicity
ATE - Oral (mg/kg):
ATE - Dermal (mg/kg):
ATE - Inhalatory, mists (mg/l):
Percentage of unknown Acute
1700
>5000
>20
1.23001
Toxicity
12. ECOLOGICAL INFORMATION
Ecotoxicity: No information available.
Persistence and Degradability: No information available.
Bioaccumulation: No information available.
13. DISPOSAL CONSIDERATIONS
Waste from residues / unused products: Pesticide wastes are acutely hazardous. Improper disposal of excess pesticide, spray mixture, or
rinsate is a violation of Federal Law. If these wastes cannot be disposed of by use according to label instructions contact your State Pesticide or
Environmental Control Agency, or the Hazardous Waste reporesentative at the nearest EPA Regional Office for guidance. This product, as sold, if
discarded or disposed, is not a hazardous waste according to Federal regulations (40 CFR 261.4 (b)(4)). Dispose in compliance with all Federal,
state, provincial, and local laws and regulations. This product, when diluted as stated on this SDS, is not a hazardous waste according to Federal
regulations (40 CFR 261.4 (b)(4)). Under RCRA, it is the responsibility of the user of the product to determine, at the time of disposal, whether the
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 4 of 6
Page 5
waste solution meets RCRA criteria for hazardous waste. Dispose in compliance with all Federal, state, provincial, and local laws and regulations.
Contaminated Packaging: Do not re-use empty containers.
RCRA Hazard Class (undiluted product): Not Regulated
RCRA Hazard Class (diluted product): Not Regulated
14. TRANSPORT INFORMATION
DOT/TDG/IMDG: Proper shipping descriptions can vary by pack size. Please refer to the Diversey HazMat Library, only available through
Internet Explorer, http://naextranet.diversey.com/dot/, for up to date shipping information.
DOT (Ground) Bill of Lading Description:
IMDG (Ocean) Bill of Lading Description:
UN1903, DISINFECTANTS, LIQUID, CORROSIVE, N.O.S., (quaternary ammonium compounds), 8, III
UN1903, DISINFECTANTS, LIQUID, CORROSIVE, N.O.S., (quaternary ammonium compounds), 8, III,
MARINE POLLUTANT
15. REGULATORY INFORMATION
International Inventories at CAS# Level
All components of this product are listed on the following inventories: U.S.A. (TSCA).
U.S. Regulations
EPA Reg. No. : 70627-24
This chemical is a pesticide product registered by the United States Environmental Protection Agency and is subject to certain labeling
requirements under federal pesticide law. These requirements differ from the classification criteria and hazard information required for safety data
sheets (SDS), and for workplace labels of non-pesticide chemicals. The hazard information required on the pesticide label is reproduced below. The
pesticide label also includes other important information, including directions for use.
DANGER: CORROSIVE. Causes irreversible eye damage and skin burns. Do not get in eyes, on skin or on clothing. Wear chemical splash-proof
goggles or face shield, rubber gloves and protective clothing. Harmful if swallowed, inhaled or absorbed through skin. Avoid breathing spray mist.
Wash thoroughly with soap and water after handling and before eating, drinking, chewing gum, using tobacco or using the toilet. Remove
contaminated clothing and wash before reuse.
California Proposition 65: This product is not subject to the reporting requirements under California's Proposition 65.
RIGHT TO KNOW (RTK)
n-alkyl dimethyl benzyl ammonium
Ingredient(s) CAS # MARTK: NJRTK: PARTK: RIRTK:
Didecyl dimethyl ammonium
Tetrasodium salt of EDTA 64-02-8 - - - -
Lauryl dimethyl amine oxide 1643-20-5 - - - -
Sodium sesquicarbonate 533-96-0 - - - -
Water 7732-18-5 - - - -
7173-51-5 - - - -
chloride
68424-85-1 - - - -
chloride
Ethyl alcohol 64-17-5 X X X -
CERCLA/ SARA
SARA 311/312 Hazard Categories
Immediate:
Delayed:
Fire:
Reactivity:
Sudden Release of Pressure:
x
x
-
-
Canadian Regulations
16. OTHER INFORMATION
NFPA (National Fire Protection Association)
Rating Scale: (Low Hazard) 0 - 4 (Extreme Hazard)
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 5 of 6
Page 6
Health 3
Flammability 0
Instability 0
Version Number: 1
Preparation date: 2014-10-09
Reason for revision:
Prepared by:
Additional advice:
Notice to Reader: This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty,
express or implied, as to the accuracy of the information contained within. Actual conditions of use and handling are beyond seller's control. User is
responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State, Provincial and
Local laws and regulations.
Not applicable
NAPRAC
• Contains an added fragrance, see "Odor" heading in section 9 for specific description
Virex II 256 One-Step Disinfectant Cleaner and Deodorant; Quat Based Disinfectant 6 of 6
Loading...