Dickey-John PM300, PM400, PM332 Operator's Manual

PM300 - 332 - 400 PLANTER MONITOR
Operator’s Manual
TABLE OF CONTENTS
Introduction .......................................................................................................... 3
System Overview ............................................................................................................... 3
Specifications..................................................................................................................... 5
Major Features ..................................................................................................... 7
Performance ...................................................................................................................... 7
Console/Display ................................................................................................................. 7
Compatibility ...................................................................................................................... 7
User Aid ............................................................................................................................. 7
Quick Start Guide................................................................................................. 9
Planter Configuration ......................................................................................................... 9
Number of Rows ............................................................................................................................... 9
Row Spacing ................................................................................................................................... 10
Ground Speed Configuration ........................................................................................... 11
Help Card......................................................................................................................... 12
Key Functions .................................................................................................... 15
On/Off Key ....................................................................................................................... 15
Alarm Cancel Key ............................................................................................................ 15
Enter Key ......................................................................................................................... 16
Escape Key...................................................................................................................... 16
Up and Down Arrow Keys................................................................................................ 16
Left and Right Arrow Keys ............................................................................................... 16
Operate Key..................................................................................................................... 16
Planter Setup Key............................................................................................................ 16
Ground Speed Setup Key ................................................................................................ 17
Limits Setup Key.............................................................................................................. 17
Display And Service Key ................................................................................................. 17
Accessory Setup Key....................................................................................................... 17
Seed Count Mode Key..................................................................................................... 17
Speed Area Mode Key..................................................................................................... 17
Editing Screen Fields Using Keys.................................................................................... 18
Highlighted Digit for Editing............................................................................................................. 18
Installation .......................................................................................................... 19
Standard Mounting Bracket ............................................................................................. 19
Optional Mounting 3D Adjustable Bracket ....................................................................... 20
Installing Console Harnesses .......................................................................................... 21
Installing Implement Harness and Sensors ..................................................................... 22
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
i
TABLE OF CONTENTS
Advanced Setup ................................................................................................ 23
Planter and Ground Speed............................................................................................... 23
Row Setup (Auto Assigned) ............................................................................................................ 23
Ground Speed Setup....................................................................................................................... 24
Manual Ground Speed Constant Entry............................................................................................ 25
Accessory Setup (Optional)............................................................................................. 26
Limits Setup (Population) (Optional)................................................................................ 28
Target Population ............................................................................................................................ 28
HI Population/Low Population ......................................................................................................... 29
Population Adjustment..................................................................................................................... 29
Population Response Rate .............................................................................................................. 29
Units of Measurement, Backlighting and Alarm Volume Control..................................... 30
Service Screen ................................................................................................................ 30
Security Screen ............................................................................................................... 31
Auxiliary Modes................................................................................................. 33
Speed Area Mode............................................................................................................ 33
Seed Count Mode............................................................................................................ 33
Monitoring Planting........................................................................................... 35
Operate Screen Setup..................................................................................................... 35
Customizing the Upper Parameter Window .................................................................... 35
Customizing the Lower Parameter Window .................................................................... 37
Available Planting Parameters ........................................................................................ 38
Average Population ......................................................................................................................... 38
Minimum/Average/Maximum Population......................................................................................... 39
Population Row Scan ...................................................................................................................... 39
Average Spacing ............................................................................................................................. 39
Minimum/Average/Maximum Spacing............................................................................................. 39
Spacing Row Scan .......................................................................................................................... 39
Seeds per Distance ......................................................................................................................... 39
Minimum/Average/Maximum Seeds per Distance........................................................................... 39
Seeds per Distance Row Scan........................................................................................................ 39
Field Area 1 ..................................................................................................................................... 40
Field Area 2 ..................................................................................................................................... 40
Total Area ........................................................................................................................................ 40
Speed .............................................................................................................................................. 40
Area per Hour .................................................................................................................................. 40
Fan .................................................................................................................................................. 40
Shaft ................................................................................................................................................ 40
Flow ................................................................................................................................................. 40
Alarms ................................................................................................................ 41
Hopper Level ................................................................................................................... 41
Row Failure ..................................................................................................................... 41
All Rows Failure............................................................................................................... 42
Hi/Low Population Warning ............................................................................................. 43
Fan Speed Low/Hi Limit Warning .................................................................................... 43
Shaft Speed Low/Hi Limit Warning.................................................................................. 44
Flow Low/Hi Limit Warning .............................................................................................. 44
Failed Ground Speed Sensor .......................................................................................... 45
Battery Hi/Low ................................................................................................................. 45
Self-Test Failure .............................................................................................................. 46
Hi Ground Speed Exceeded (Optional) ........................................................................... 46
ii
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
TABLE OF CONTENTS
Troubleshooting................................................................................................. 47
Monitor Will Not Power On .............................................................................................. 47
Row Failure or Hi/Low Alarm When Row is Planting Properly..........................................47
Hopper Alarm Does not Sound When Hopper is Empty ...................................................48
Hopper Alarm Does Not Sound When Hopper is Full.......................................................48
System Voltage Alarm ......................................................................................................48
Accessory Alarm Sounds When Shaft, Fan or Flow is Working .......................................49
Ground Speed Alarm Sounds When Forward Movement ................................................49
Ground Speed High Alarm Sounds ..................................................................................49
Self-Test Alarm .................................................................................................................50
Connector Pin-Outs ......................................................................................................... 51
Connector Pin-Outs ......................................................................................................... 52
Warranty ..............................................................................................................57
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
iii
TABLE OF CONTENTS
iv
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
!
SAFETY NOTICES
Safety notices are one of the primary ways to call attention to potential hazards.
This Safety Alert Symbol identifies important safety messages in this manual. When you see this symbol, carefully read the message that follows. Be alert to the possibility of personal injury or death.
Use of the word WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
Use of the word CAUTION with the Safety Alert Symbol indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury.
Use of the word CAUTION without the safety alert symbol indicates a potentially hazardous situation which, if not avoided, may result in equipment damage.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
SAFETY NOTICES / 1
OPERATOR’S MANUAL
2 / SAFETY NOTICES
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
PMXXX
ENTER
ESCAPE
ACCY
SETUP
DISPLAY
&
SERVICE
GROUND
SPEED SETUP
LIMITS SETUP
OPERATE
PLANTER
SETUP
SPEED
AREA
MODE
SEED COUNT MODE
INTRODUCTION
SYSTEM OVERVIEW
The DICKEY-john PM300, PM332, and PM400 Planter Monitors offer features to monitor 16, 32, and 36 rows, respectively. The units monitor seed or fertilizer rows, two hopper levels, and a frequency input (shaft, fan, or flow). The monitors are compatible with DICKEY-john seed, flow, hopper level, and gear sensors. The units store all configuration data in nonvolatile memory, retaining information even when disconnected from power. Figure 1 provides an illustration of a generic console.
The PM300, PM332, and PM400 are designed to meet the custom needs of individual users. The display may be configured to output a comprehensive set of planter parameters. The user selects the type and number of parameters to be monitored. Choices may be as simple as monitoring population and field area or may be more complex. Similarly, blink or fail mode information may be viewed as a bar graph, gauge, or symbol. Information may be viewed in large format (for ease of viewing), or small format (for entire planter view). Auto-scrolling and arrow key override are used to maintain control of real-time information required by the user.
Figure 1
PM300, PM332, and PM400
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
INTRODUCTION / 3
OPERATOR’S MANUAL
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
5.2
527.3
4.5
1
1 2 3 4 5 6 7 8 9
3.2
2.9
5.0
6
in
6
1 2 3 4 5 6 7 8 9
33.4
10
9
12.5
33.4
0.0
10 11 12 13 14 15 16 17 18
1 2 3 4 5 6
10
33.5
7 8 9 10 11 12
10
37.2
2 4 6 8
1 2 3 4 5 6
12.5
7 8 9 10 11 12
2
33.3
Graphic mode: average population,
speed, and field 1 area output with bar
graphs
Text mode: average spacing, spacing
scan and min/max/avg spacing output
with bar graphs
Min/max/avg population, population
row scan, avg speed spacing, and shaft
speed with gauges
Min/max/avg population and row scan
with blinking row symbols
Rows 2, 4, 6, 8 (above limit) alarm
screen
Row scan and average spacing with
blinking symbols and row 1 hi alarm
(alarm cancel returns user to operate
screen)
Figure 2
User-Definable Display Examples
4 / INTRODUCTION
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
SPECIFICATIONS
Power 10–16 VDC, 5 A maximum
Operating temperature range -20°C to 70°C (-4°F to 158°F)
Storage temperature range -40°C to 85°C (-40°F to 185°F)
Size 18.4 cm W x 20.1 cm H x 4.3 cm D
(7.3" W x 7.9" H x 1.7" D)
Weight 4.4 lbs for 16-row PM300 system
4.8 lbs for 32-row PM332 system
6.4 lbs for 36-row PM400 system *Weight includes console and attached cables (battery power cable and signal cable that extends to the drawbar).
Wire Harnesses The PM300, PM332, and PM400 include
integrated harnesses to supply the unit's power (fused), ground speed input, and sensor inputs (to drawbar). The connectors are compatible with existing DICKEY-john harnesses. DICKEY-john can supply custom harnesses required for sensor inputs.
Sensors Compatible with existing DICKEY-john
sensors
Standard mounting Rear attached horizontal or vertical
mounting bracket Mounting bracket weighs 1.0 lb.
Optional mounting Three-axis adjustable mounting bracket
Contrast adjustment Automatic temperature compensation for
contrast
Backlight adjustment Three settings for full sun, daytime, or
nighttime use
CE certified
Dust and moisture resistant
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
INTRODUCTION / 5
OPERATOR’S MANUAL
6 / INTRODUCTION
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
MAJOR FEATURES
PERFORMANCE
Planter monitoring of 16 row (PM300), 32 rows (PM332), or 36 rows PM400
Monitoring of ground speed, two hopper levels, one frequency function (fan, shaft, or flow)
Easy and flexible configuration
User-definable view of two, three, or four functions (all are available): – Average Population – Average Seed Spacing – Average Seeds Per Distance – Population Row Scan – Seed Spacing Row Scan – Seed Per Distance Row Scan – Minimum, Maximum, Average Row Population – Minimum, Maximum, Average Row Spacing – Minimum, Maximum, Average Spacing Per Distance – Field Area 1 – Field Area 2 – Total Area 3 – Ground Speed – Fan, Shaft, or Flow Frequency
User-definable row information: –Bar Graph – Wiper Gauge – Symbols (Failure mode) – Symbols flashing proportional to seeding rates
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
CONSOLE/DISPLAY
Large, user friendly keys
User-definable text size ease of viewing
Graphic or text-based output labels
Backlit graphic display for nighttime use
Three-level backlight intensity adjustment
Large, concise error messages displayed with audible alarm
English or metric units
Horizontal and vertical mounting (optional 3D adjustment bracket)
COMPATIBILITY
Compatible with DICKEY-john sensors
Plug-in replacement for other DICKEY-john monitors
Optional support of RS-232 based data logging
USER AID
•Help card
MAJOR FEATURES / 7
OPERATOR’S MANUAL
8 / MAJOR FEATURES
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
PLANTER
SETUP
123
#
12
75,0
cm
9
m
1 2 3 5 6
4
I/O
Planter Configuration
# of Rows
Row Spacing
Row Setup
ENTER
QUICK START GUIDE
Three inputs are required for monitor operation.
Number of rows
Row spacing
Ground speed constant
Selecting a pre-programmed planter configuration provides easy set-up of planter row width, number of rows, implement width, and row types.
PLANTER CONFIGURATION
Planter Setup key
To program the planter configuration, select the Planter Setup key. The Planter Configuration screen will be displayed.
Figure 3
Planter Configuration Screen
Enter key
Left and Right Arrow keys
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
The PM300, PM332, and PM400 can store three planter configurations for users with split row planters or multiple planters and seeders, but many users store only one configuration.
To select a planter configuration number (1, 2, or 3)
1. Press Enter to highlight arrow indicator ( ) and move using the Left
and Right keys to make a selection.
2. Press Enter to confirm the selection.
NUMBER OF ROWS
To change number of rows:
1. Use the Left and Right Arrow keys to highlight the number of rows field.
QUICK START GUIDE / 9
OPERATOR’S MANUAL
ENTER
OPERATE
ESCAPE
123
#
15.0
in
15.00
ft
I/O
NUMBER OF ROWS
12
1 2 3 5 6
4
Enter
Up and Down Arrow keys
2. Press Enter to modify the number of rows as shown in Figure 4. Use the Right and Left Arrow keys to select the digit to change. Use the Up and Down Arrow keys to edit the selected digit. Use the Up Arrow key to increase the value; use the Down Arrow key to decrease the value.
3. Press the Enter key to confirm the selection. Enter the row spacing in the same manner.
4. Once the new values are entered, select either the Escape or Operate key to return to the Operate (main) screen.
Figure 4
Number of Rows Screen
Operate key
Escape key
Left and Right Arrow keys
ROW SPACING
To change row spacing:
1. Press Planter Setup key.
2. Use the Down arrow to highlight the row spacing field (refer to Figure
5).
3. Press Enter to select the field.
4. Use the Left and Right Arrow keys to select a digit for editing.
5. When a digit is highlighted, use the Up and Down Arrow keys to edit the value displayed. Use the Up Arrow key to increase the value; use the Down Arrow key to decrease the value.
6. When the field shows the correct planter row spacing, press Enter to confirm the selection.
7. Once the new values are entered, select either the Escape or Operate key to return to the Operate (main) screen.
10 / QUICK START GUIDE
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
123
#
in
10.00
ft
I/O
ROW SPACING
8
1 2 3 5 6
4
15.0
GROUND
SPEED SETUP
6096
0.0
mph
400 ft
=
0.0
mph
=
Start symbol (will change to Stop symbol when test begins
Manual ground speed (optional)
Maximum speed alarm (optional)
# of pulses in 400 ft.
Ground Speed Source (Radar or Reluctance)
Figure 5
Row Spacing Screen
Ground Speed Setup key
GROUND SPEED CONFIGURATION
To perform Ground Speed Configuration, select the Ground Speed Setup key. The Ground Speed Setup screen will display (refer to Figure 6).
Figure 6
Ground Speed Setup Screen
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
QUICK START GUIDE / 11
OPERATOR’S MANUAL
ENTER
OPERATE
ESCAPE
Enter key
Operate key
To perform a new calibration:
1. Measure a 400 foot (122 meter) course, clearly marking the beginning and end.
2. Using the Arrow keys, highlight the Start softkey on the screen (  ).
3. Begin moving the tractor forward at 2-5 mph.
4. When the tractor is even with the beginning marker, press the Enter key to start the 400-foot calibration.
5. After the calibration has begun, the softkey on the screen will change to a Stop ( ) softkey. Drive 400 feet and stop the vehicle.
6. Select the Enter key to stop the calibration. The new calibration factor will be displayed on the window.
7. Once the Stop key is selected, the value will be saved upon screen exit. Selecting the Escape key while the calibration is running will not save the value.
8. Select either the Escape or Operate key to return to the Operate (main) screen.
Escape key
HELP CARD
The help card (Figure 7) may be cut out to provide a compact reference for definitions, set-up screens, and general operating information.
12 / QUICK START GUIDE
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
123
#
10
15.0
in
12.50
ft
1 23
456
789
10 11 12
I/O
Planter Setup
6096
0.0
mph
400 ft
=
0.0
mph
=
Ground Speed
0.0
Limits Setup
%
%
0.0
%
+
0
%
+
123.4
43.8
1234
1 2 3
M E
E
1
1 2 3 4 5 6 7 8 9
16.8
33.3
16.9
Operate (main) Accessory Setup
3,0 3,0
3
3,0
Seed Count
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521
9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521
Speed Area Distance
0.0
0.0
Use keys to select screen Use (arrow keys) to select item Use ENTER to modify highlighted item Use (arrow keys) to change items/digits or to select digits Use ENTER to accept data or OPERATE to accept data and return to the OPERATE screen
123.4
43.8
1234
1
2
1
3
Functions (top half)
aA
Service
M: 0305022109
B: 0205030714
H: 1
25.7
10,910.0
ac
12.8
1
2
1 2 3
1 2 3 4 5 6 7 8 9
Rows output
(bottom half)
0000
0000
1 2 3
2
1,2,3
...
III.I
III.I
Average
Population
...
Seed Spacing Seeds per Distance
Population
...
Seed Spacing Seeds per Distance
Row
Scan
Minimum
Maximum
Average
Population
...
Seed Spacing Seeds per Distance
Field Area 1
Field Area 2 Total Area
1
2
Speed
Area/hour Distance
Shaft
Fan Flow
!
Warning Hi/Lo No flow
Hopper
All Rows Failed
No Speed Input
Planter Lifted
Start
Stop
Reset
Security Password Save Password
Configuration
Alarm
English/Metric
M
E
Back light
Graphic/Text Label
aA
Population Adjust+Response Rate
Display and Service Menus
User Preference
1
5.1
0.0
2
17.217.2
1 2
14.1
31.4
0.0
Figure 7
Help Card
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
QUICK START GUIDE / 13
OPERATOR’S MANUAL
14 / QUICK START GUIDE
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
PMXXX
ENTER
ESCAPE
ACCY
SETUP
DISPLAY
&
SERVICE
GROUND
SPEED SETUP
LIMITS SETUP
OPERATE
PLANTER
SETUP
SPEED
AREA
MODE
SEED COUNT MODE
KEY FUNCTIONS
Figure 8
Keys
On/Off key
Alarm Cancel key
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ON/OFF KEY
The On/Off key activates the unit. During power up, the monitor performs internal self-tests, illuminates the display, sounds the alarm, and determines which sensors are connected to the system. Pressing and holding the key for one second when the power is ON will turn the power OFF, independent of the screen being displayed.
ALARM CANCEL KEY
During normal operation, selecting the Alarm Cancel key acknowledges the alarm condition displayed on the screen. Active row alarms are reset after an ALL ROWS FAILURE condition or a power down-up sequence occurs. If the error condition continues, the key must be selected again to cancel the alarm. When no alarms are active, the volume may be modified by selecting and holding the Alarm Cancel key.
KEY FUNCTIONS / 15
OPERATOR’S MANUAL
ENTER
ESCAPE
OPERATE
PLANTER
SETUP
ENTER KEY
The Enter key selects a highlighted item for data modification. After changing the parameter values, Enter accepts the modified data.
Enter key
Escape key
Up and Down Arrow keys
Left and Right Arrow keys
ESCAPE KEY
On the Operate (main) screen, select and hold the Escape key for four seconds to clear an area accumulator if it is located on the top line of the display.
When navigating through sub-menus, the Escape key moves the user back one selection. After changing parameter values, selecting Escape accepts the modified data. The Escape key also serves as an alarm cancel key.
UP AND DOWN ARROW KEYS
On the Operate (main) screen, the Up and Down Arrow keys are used to manually select the parameters viewed at the top of the display. They are inactive if all parameters are already displayed (number of parameters are equal to or less than number of lines).
On the Operate (main) screen, the arrows are used to navigate between options. On set-up screens, the arrows are used to navigate between options or to change a digit/option.
LEFT AND RIGHT ARROW KEYS
On the Operate (main) screen, the Left and Right Arrow keys are used to manually select the rows viewed at the bottom of the display. They are inactive if all rows are already displayed. On other screens, the arrows are used to navigate between options.
OPERATE KEY
Operate key
Planter Setup key
16 / KEY FUNCTIONS
The Operate (home) key is used to return the user to the Operate (main) screen.
If data is changed, it is saved when this key is selected.
PLANTER SETUP KEY
The Planter Setup key is used to navigate to the Planter Setup screen for input of the number of rows, row spacing, implement width (optional), and row type (population — default, blockage, skipped, or disabled).
If data on another screen is changed, it is saved when this key is selected.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
GROUND
SPEED SETUP
LIMITS SETUP
DISPLAY
&
SERVICE
ACCY
SETUP
SEED
COUNT
MODE
SPEED
AREA
MODE
Ground Speed Setup key
Limits Setup key
GROUND SPEED SETUP KEY
The Ground Speed Setup key is used to navigate to the Ground Speed Setup screen for input of the ground speed calibration (or manual entry of ground speed calibration number), manual ground speed (used if no ground speed is available), and ground speed maximum limit (optional).
If data on another screen is changed, it is saved when this key is selected.
LIMITS SETUP KEY
The Limits Setup key is used to navigate to the Limits Setup screen for input of the upper limit (optional), target population value (optional), lower limit (optional), population adjustment factor (optional for sensors that count less than 100% of all seeds), and response rate (optional to increase or decrease the console response rate).
If data on another screen is changed, it is saved when this key is selected.
DISPLAY AND SERVICE KEY
Display and Service key
Accessory Setup key
Seed Count Mode key
The Display And Service key is used to navigate to the Display & Service Setup screen for access to the function, row indicators, service, and
security sub-menus; English/Metric units selection; display backlight intensity; and alarm volume.
If data on another screen is changed, it is saved when this key is selected.
ACCESSORY SETUP KEY
The Accessory Setup key is used to navigate to the Accessory Setup screen for selection of a fan (RPM) / shaft (RPM) / or flow (G/MIN or L/min) labels, upper and lower alarm limits, and calibration (or manual calibration number entry).
If data on another screen is changed, it is saved when this key is selected.
SEED COUNT MODE KEY
The Seed Count Mode key is used to navigate to the Seed Count screen. This mode allows users to test planters for proper operation prior to field use.
If data on another screen is changed, it is saved when this key is selected.
SPEED AREA MODE KEY
Speed Area Mode key
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
The Speed Area Mode key is used to navigate to the Speed Area Distance screen. This mode allows use of the console for non-planting operations. This mode is also used to start, stop, or clear the three independent area accumulators (FIELD AREA 1, FIELD AREA 2, and TOTAL AREA).
If data on another screen is changed, it is saved when this key is selected.
KEY FUNCTIONS / 17
OPERATOR’S MANUAL
6096
00.0
mph
400ft
=
0.0
mph
=
GNDSPD CONSTANT
A highlighted digit can be edited by using the Arrow keys on the Control Panel. Press Enter to accept and confirm the selection.
ENTER
ESCAPE
EDITING SCREEN FIELDS USING KEYS
The term “highlight” used throughout the manual refers to pressing a key to activate and move the blinking cursor until the desired digit on the screen is highlighted. Pressing Enter accepts and confirms the selection.
HIGHLIGHTED DIGIT FOR EDITING
18 / KEY FUNCTIONS
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
Slide console until snap engages
Mount on vehicle with locally acquired hardware
INSTALLATION
The monitor is tested and inspected before shipping to ensure the unit is fully operational and meets measurement specifications. Inspect for damage that may have occurred during transit. Save all packing materials until the inspection is complete. If damage is found, immediately file a claim with the carrier and notify your DICKEY-john Sales Representative.
STANDARD MOUNTING BRACKET
NOTE: When mounted to a vertical
surface, a tie-wrap may be used to secure the cables to the bottom of the bracket.
Install the mounting bracket at the desired location using locally acquired hardware. Install the console to the bracket by aligning the console mating grooves with the bracket and sliding the console onto the bracket until the snap engages.
Figure 9
Standard Mounting Bracket
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
The console must not obstruct the view of the operator or interfere with the operation of the tractor.
To prevent damage to the console, be sure the snap fully engages during installation.
INSTALLATION / 19
OPERATOR’S MANUAL
Slide console until snap engages
Mount on vehicle with locally acquired hardware
Wing bolts
OPTIONAL MOUNTING 3D ADJUSTABLE BRACKET
Separate the bracket halves from one another by loosening the wing bolt. Install the upper bracket half into the console by sliding the bracket’s rectangular section into the console mating grooves until the snap engages. Install the bottom bracket half at the location of your choice using locally acquired hardware.
Figure 10
Optional 3D Mounting Bracket
20 / INSTALLATION
The console must not obstruct the view of the operator or interfere with the operation of the tractor.
To prevent damage to the console, be sure the snap fully engages during installation.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
+
Ground Speed
Battery
PMXXX
ENTER
ESCAPE
ACCY SETUP
DISPLAY
&
SERVICE
GROUND
SPEED SETUP
LIMITS
SETUP
OPERATE
PLANTER
SETUP
SPEED AREA MODE
SEED
COUNT
MODE
Implement (rows and accessories)
*
*PM300 does not have a second cable PM332 has a 9 pin accessory cable PM400 has a 37-pin cable
INSTALLING CONSOLE HARNESSES
Several harnesses are located at the bottom of the PM300, PM332, and PM400. These include power, ground speed sensor, and sensor inputs (rows, lift switch, two hopper levels, and one frequency function [shaft/fan/ flow]).
Figure 11
Console Harnesses
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
1. Route the power harness to a +12 V source near the battery if possible.
2. Route the ground speed sensor harness connection to the RADAR, Hall Effect, or GPS ground speed sensor.
3. Route the implement harness to the location of choice, typically near the drawbar.
The harnesses must not obstruct movement of the operator or of the moving parts of the tractor or implement. Take care when routing harnesses to secure them at proper locations; provide slack as needed to allow for movement.
Poor +12 V connections may cause intermittent console operation. Be sure to connect the power harness to a clean, well-conditioned source (direct battery connection is preferred).
INSTALLATION / 21
OPERATOR’S MANUAL
Row1Row2Row3Row4Row5Row
6
Row
7
Row
8
Implement connector(s) rows and accessories
Seed sensors
INSTALLING IMPLEMENT HARNESS AND SENSORS
The implement harness provides custom fit and functions required by the implement. Each harness branch is labeled for location (row 1, row 2, etc.) or sensor (lift switch) for routed connection. Some sensors may require special adapters for connection.
Figure 12
Implement Harness/Sensors
1. Install sensors onto seed tubes using tie-wraps.
2. Route implement harness to the appropriate locations; provide slack near moving parts to allow for movement. Attach harness to the implement using tie-wraps.
3. Make sure the hitch connections will connect to the tractor connections with the proper amount of slack for implement movement.
The harnesses must not obstruct moving parts of the tractor or implement. Take care when routing harnesses to retain them at proper locations with adequate slack for movement.
22 / INSTALLATION
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
PLANTER
SETUP
123
#
12
75,0
cm
9
m
1 2 3 5 6
4
I/O
Planter Configuration
# of Rows
Row Spacing
Row Setup
Planter Setup key
ADVANCED SETUP
The monitor is designed for ease of basic monitoring by new users while supporting expanded features for advanced users. The user may decide which features to configure.
PLANTER AND GROUND SPEED (REQUIRES DATA ENTRY)
The two setup screens that require input for the system to function as a monitor are the Planter Setup screen (Figure 13) and the Ground Speed Setup screen (Figure 14).
Figure 13
Planter Setup Screen
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ROW SETUP (AUTO ASSIGNED)
The console will automatically assign the number of rows defined on the Planter Setup screen as ON (population rows).
Rows may be configured to ON (population), OFF (split row), FLOW (blockage), or DISABLED.
When ON is selected (plant), the row is active and the console will detect sensors and seed flow.
When OFF is selected (blank), the row is removed and remaining rows are re-numbered. This is used for split row systems where every other row or sets of internal rows are not planting. Their corresponding row number is ignored, allowing for true planting operations to be displayed on the monitor.
ADVANCED SETUP / 23
OPERATOR’S MANUAL
ENTER
GROUND
SPEED SETUP
Enter key
Left and Right Arrow keys
When DISABLED is selected (circle with slash), the row input is ignored. The row number will be displayed. This is used when a row or sensor is malfunctioning and the operator wants to disable monitoring on that row.
When FLOW is selected (funnel), the row will not be included for population calculations but will be monitored for flow. The flow rows will be used to detect flow (fertilizer or seeds) and alarm if the flow falls below two pulses per second.
The Planter Setup screen must include the number of rows and the row spacing or implement width for the console to properly display population. Up to three individual configurations can be programmed and supports split row planters (CONFIGURATION 1 for NORMAL and 2 for SPLIT ROW) and a separate seeder or drill (CONFIGURATION 3).
To configure row setup:
1. Highlight the 123 (refer to Figure 13) at the upper left corner of the screen
2. Press the Enter key
3. Use the Left and Right Arrow keys to select the appropriate planter configuration.
4. Press Enter to accept selection.
5. Press the Down Arrow key to highlight the I/O icon for row setup.
6. Press the Enter key to select the icon and highlight the first row unit.
7. Use the Up or Down Arrow key to toggle through the four possible configurations: On, Off, Disabled or Flow.
8. Use the Left or Right Arrow key to highlight another row unit for reconfiguring.
9. Press the Enter key to save the selection.
10. Press Enter key again to select another row to change and the Left or Right Arrow key to move to other row units to reconfigure.
11. When finished, press Operate key to return to the Operate (main) screen.
Up or Down Arrow keys
Ground Speed Setup key
24 / ADVANCED SETUP
GROUND SPEED SETUP
The Ground Speed Setup screen must include a calibration factor for proper calculation and display of ground speed. Also included on the Ground Speed Setup screen are a calibration aid, a manual ground speed value, and a maximum speed alarm. The calibration aid may be used to measure the calibration factor, which is the number of pulses in 400 ft (122 m). The manual ground speed (optional) may be used when a ground speed sensor is not installed or has failed in the field. The maximum speed alarm (optional) provides the user with an over-speed alarm.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
6096
0.0
mph
400 ft
=
0.0
mph
=
Start symbol (will change to Stop symbol when test begins
Manual ground speed (optional)
Maximum speed alarm (optional)
# of pulses in 400 ft.
Ground Speed Source (Radar or Reluctance)
ENTER
Figure 14
Ground Speed Setup Screen
NOTE: To verify that the correct
calibration number has been obtained, move to the Speed Area Mode screen. Verify that the speed matches the vehicle’s speedometer or remeasure the 400-foot distance.
Up or Down Arrow keys
Enter key
MANUAL GROUND SPEED CONSTANT ENTRY
A manual ground speed value should only be entered when the ground speed sensor or tractor radar has failed and no ground speed input is available.
IMPORTANT: Entering a manual ground speed value when the ground
speed sensor or tractor radar is working properly and connected to the monitor will interfere with the proper operation of the planter monitor. Accumulated acreage will not be recorded.
To enter a manual ground speed value:
1. Press the Ground Speed Setup key to access the ground speed setup screen.
1. Use the Down Arrow key to highlight the manual ground speed value (refer to Figure 6).
2. Select the Enter key to modify the constant.
3. Use the Arrow keys to select digits, increment, and decrement values.
4. Select the Enter key to accept the new number.
5. Once the new values have been entered, select either the Escape or Operate key to return to the Operate (main) screen.
Any non-zero value will activate manual ground speed. Set manual ground speed to zero to disable.
To verify that the correct calibration number has been obtained, move to the Speed Area Mode screen.
1. Press the Speed Area Mode key.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ADVANCED SETUP / 25
OPERATOR’S MANUAL
SPEED
AREA
MODE
1
5.1
0.0
2
17.217.2
1 2
14.1
31.4
0.0
Field Area 1
Field Area 2
Total Area
Distance
Reset Counter
Stop
Start
ACCY
SETUP
2. Verify that the speed matches the vehicle’s speedometer or re-measure the 400-foot distance.
Figure 15
Speed Area Mode Screen
ACCESSORY SETUP (OPTIONAL)
To add an auxiliary sensor and its performance characteristics (calibration values, limits, etc.) to the monitoring inputs, it must be activated by entering a calibration constant. If minimum or maximum alarms are desired, the limits may be added to the calibrated sensors. A fan, shaft, or flow sensor may be monitored with HI and/or LOW alarms or no alarm values. Refer to Figure 16.
26 / ADVANCED SETUP
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
3,0 3,0
3
3,0
Fan
Shaft
Flow
ACCY
SETUP
ENTER
Figure 16
Accessory Screen
Left and Right Arrow keys
Enter key
Start symbol
To enter a calibration constant:
1. Press Accessory Setup key.
2. Use the Left and Right key to select fan, shaft or flow symbol.
3. Use the Down Arrow key to change high and low alarm values.
4. Press Enter to Highlight digit to change. If the calibration factor is unknown, the monitor can determine the calibration factor by using the built-in calibration mode.
Assure equipment is configured to be operated safely. Shaft/fan calibration requires movement in associated equipment and revolution counting. Flow calibration requires liquid dispensing, catching, and measurement.
To perform a sensor calibration, highlight the Start symbol. Assure the system is in a safe state. Start the monitor calibration by selecting the Enter key. The Start symbol (triangle) will change to a Stop symbol (square). Activate the shaft, fan, or flow. Count the revolutions (shaft/fan) or catch liquid (flow) while the monitor measures pulses. Deactivate the shaft, fan, or flow. Stop the monitor calibration by selecting the Enter key again. Highlight the revolutions or liquid level window. Select the Enter key. Enter the number of revolutions (shaft/fan) or gallons (flow).
Stop symbol
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ADVANCED SETUP / 27
OPERATOR’S MANUAL
LIMITS SETUP
%
%
%
+
0
%
+
27.0
33.0
30.0
HI POP ALARM
Hi Alarm
Lo Alarm
Population Adjust
Population Filter
Target Population
ENTER
LIMITS SETUP (POPULATION) (OPTIONAL)
The Limits Setup screen allows users to define several population features (refer to Figure 17). Users may define a target population, a minimum or under population alarm limit, a maximum or over population alarm limit, a population adjustment factor, and a population response rate.
Figure 17
Limits Setup Screen
Up or Down Arrow keys
Left and Right Arrow keys
Enter key
28 / ADVANCED SETUP
TARGET POPULATION
Target population is defined in 1000s of seeds per acre or hectare, dependent on the unit of measurement selected. If no value is entered, the monitor uses average population to calculate alarms or row population indicators.
With the limits set up screen displayed as shown in Figure 17:
1. Use the Down Arrow key to highlight the target population field.
2. Press the Enter key to highlight field.
3. Use the Left or Right Arrow key to select a digit for editing.
4. When a digit is highlighted, use the Up or Down Arrow keys to edit the value displayed.
5. When the field shows the desired target population, press the Enter key to confirm the selection.
6. Select either the Escape or Operate key to return to the Operate (main) screen.
If no value is entered, the monitor uses average population to calculate alarms or row population indicators.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
ENTER
OPERATE
Up or Down Arrow keys
Enter key
HI POPULATION/LOW POPULATION
The Hi population and Low population values determine when an alarm or row indicator displays to warn the operator about a population problem. If the percentage (%) box is checked, the values are percentage based. For example, 10% of 30,000 seeds/acre for the over population setting (33,000 seeds/acre) and for the under population setting (27,000 seeds/acre) (refer to Figure 17). If the percentage (%) box is not checked, the values are population based and expressed in 1000s of seeds per acre or hectare. The over population and under population values are independent of each other and do not have to be the same percentage value.
To change the percentage (%) box setting,
1. Use the Up or Down Arrow key to highlight the percentage (%) box.
2. Press the Enter key to toggle the setting from checked to unchecked.
To change the population value settings:
1. Use the Up or Down Arrow key to highlight the hi alarm or low alarm field.
2. Press the Enter key to highlight the field for editing.
3. Use the Left or Right Arrow key to select a digit for editing.
4. When a digit is highlighted, use the Up or Down Arrow keys to edit the value displayed.
5. Press Enter key to confirm the selection.
6. Press the Operate key to return to the Operate (main) screen.
Left and Right Arrow keys
POPULATION ADJUSTMENT
A population adjustment provides a means to display populations nearer the actual versus the sensed seeding rates. This is useful when sensors do not detect doubles, triples, etc.
To change the over population value setting:
1. Use the Up or Down Arrow key to highlight the field.
2. Press the Enter key to highlight the field for editing.
3. Use the Left or Right Arrow key to select a digit for editing.
4. When a digit is highlighted, use the Up or Down Arrow keys to edit the value displayed.
5. Press Enter key to confirm the selection.
6. Press the Operate key to return to the Operate (main) screen.
POPULATION RESPONSE RATE
The population response rate is used to provide population display stability for planters with few rows versus many or when the sensed application rate does not match the actual application rate. Use the Population Filter to stabilize population and alarm reporting.
To change population response rate:
1. Move the slide to the right when planting high seed rates and to the left when planting low seed rates. (refer to Figure 17).
2. Press the Operate key to return to the Operate (main) screen.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ADVANCED SETUP / 29
OPERATOR’S MANUAL
DISPLAY
&
SERVICE
123.4
43.8
1234
123.4
43.8
1 2 3
M E
E
Units, Backlight, Alarm Volume
Service
Security
Upper Setup
Lower Setup
M E
E
ENTER
Units
Backlighting
UNITS OF MEASUREMENT, BACKLIGHTING AND ALARM VOLUME CONTROL
The display screen can be customized by changing the units of measurement to English or Metric, control backlight intensity and increase or decrease alarm volume.
Figure 18
Display & Service Screen
Volume
Service icon
Up or Down Arrow keys
To change Units, Backlight, and Alarm Volume:
1. Press Display & Service key.
2. Press the Down Arrow key to highlight Units, Backlight or Alarm Volume icon.
3. Press Enter to highlight the setting to change and the Up and Down Arrow key to cycle through selection.
4. Press Enter to confirm the desired selection.
SERVICE SCREEN
The service screen provides information about the monitor’s software and hardware versions, total hours of operation, total acres covered, battery voltage, hopper level 1 and 2 sensor status, and lift switch status. (refer to Figure 19).
To display the service screen:
1. Press the Display & Service key.
2. Highlight the Service icon and press Enter.
Enter key
30 / ADVANCED SETUP
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
M: 0305022109
B: 0205030714
H: 1
25.7
910.0
ac
12.8
1
2
Total hours of operation
Total acres covered
Hardware and software versions
Battery voltage
Hopper Level 1 and 2
sensor status
Lift switch
status
ESCAPE
ENTER
Figure 19
Service Screen
Up or Down Arrow keys
Security icon
Enter key
Escape key
SECURITY SCREEN
Security features allow password protection security levels to be activated (refer to Figure 20). This prevents unauthorized personnel from modifying key parameters in the field.
The password screen allows the operator to individually lock screens to assure they are not modified.
To Lock and Unlock Screens:
1. Press the Display & Service key.
2. Using the Arrow keys, highlight the Security icon and press the Enter key to enter a password.
3. Modify the digits and select the Enter key again to accept the password.
4. Highlight the Configuration key and press Enter to navigate to the list of screens.
5. Use the Up or Down Arrow key to highlight icon for editing.
6. Press Enter to select the Lock/Unlock icon.
7. Lock or unlock screens by pressing the Up or Down Arrow keys.
8. Press Enter key to accept Lock or Unlock.
9. Select the Escape key to return to the Password screen.
10. Highlight the padlock and select the Enter key to toggle the unlocked state to locked. The selected screens will require input of the password prior to modification.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ADVANCED SETUP / 31
OPERATOR’S MANUAL
0000
0000
1 2 3
1,2,3
...
III.I III.I
Configuration
Screens that may be locked
+
-
l
Configuration softkey
Figure 20
Security Screen and Screens That May Be Locked
32 / ADVANCED SETUP
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
1
5.1
0.0
2
17.217.2
1 2
14.1
31.4
0.0
Field Area 1
Field Area 2
Total Area
Distance
Reset Counter
Stop
Start
Accessory field not supported on this model
SPEED
AREA
MODE
SEED
COUNT
MODE
AUXILIARY MODES
NOTE: Alarms are disabled in these
modes.
NOTE: A lift switch may be used to
more accurately monitor acre accumulators and is required for acreage monitoring in n o n - p l a n t i n g o p e r a t i o n s .
If a manual ground speed is selected, the area and distance will not accumulate in this mode.
The monitors provide modes for alternate monitor use and row unit testing.
SPEED AREA MODE
The SPEED AREA mode is used for cultivating (Figure 21). This mode includes start/stop/reset for Field Area 1, Field Area 2, Total Area (hc3/ac3), and distance.
Figure 21
Speed Area Mode
S
U
SEED COUNT MODE
The SEED COUNT mode is used to determine row unit performance when operating in a stationary manner. A reset for all rows is included (refer to Figure 22).
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
AUXILIARY MODES / 33
OPERATOR’S MANUAL
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521
9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521 9,521
Reset option
Figure 22
Seed Counting Mode
34 / AUXILIARY MODES
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
OPERATE
192103114125136147158
16
16.8
33.1
Upper
Lower
MONITORING PLANTING
OPERATE SCREEN SETUP
The Operate (main) screen provides many tools for monitoring planting. This screen can be immediately accessed from any other screen or sub-menu by pressing the Operate key.
The Operate screen is divided into the upper parameter window and the lower parameter window. The operator can customize the layout and content of both windows, but the size of the individual windows is fixed. (refer to Figure 23).
Figure 23
Operate Screen
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
CUSTOMIZING THE UPPER PARAMETER WINDOW
The Operate (Main) screen may be customized by changing the number of parameter lines to display in the upper window, the icon selected as text or graphic, and the planting parameter reported for each line.
An example of five parameters selected:
1 = Average population
2 = Speed
3 = Field area
4 = Total area
5 = Shaft RPM
MONITORING PLANTING / 35
OPERATOR’S MANUAL
1
2
1
3
aA
Graphics/Text Mode
Increases/Decreases Parameter Lines
SET UPPER PARAMS
Parameter Lines
123.4
43.8
1234
DISPLAY
&
SERVICE
ENTER
16.8
33.1
5.4
33.1
8
33.5
25
37.2
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
4.5
1
12.5
16.8
...
13
9
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
2 Parameter Functions 3 Parameter Functions 4 Parameter Functions
Figure 24
Upper Parameters Screen
Upper Parameter icon
Enter key
Changing Number of Parameters
The parameter lines display can be configured to show 2, 3, or 4 parameters at one time by changing the size of the parameters. The Up and Down Arrow keys are used at the Operate screen to scroll down to see all parameters being monitored.
To Change the Number of Parameter Lines:
1. Press the Display & Service key with the Upper Parameter icon highlighted.
2. Press the Enter key.
3. Press the Down Arrow key to highlight the magnifying glass.
4. Press Enter key to select the icon. Use the Up or Down Arrow key to toggle through the options for 2, 3 or 4 display lines.
5. Press Enter to confirm the selection.
Figure 25
Parameter Line Options
Up or Down Arrow key
36 / MONITORING PLANTING
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
ENTER
1 2 3
DISPLAY
&
SERVICE
Parameters may be selected to display in numerical order from the following list. (refer to MONITORING FUNCTIONS p. 39 for additional information).
Average Population
Average Seed Spacing
Average Seeds Per Distance
Population Row Scan
Seed Spacing Row Scan
Seed Per Distance Row Scan
Minimum, Maximum, Average Row Population
Minimum, Maximum, Average Row Spacing
Minimum, Maximum, Average Spacing Per Distance
Field Area 1
Field Area 2
Total Area 3
Ground Speed
Fan, Shaft, or Flow Frequency
Changing Graphic or Text Icons
The planting parameters display can be configured for text or graphic icons in the upper window.
Enter key
Lower Parameter icon
To Change the Graphic/Text Settings:
1. Press the Display & Service key with the Upper parameter icon highlighted.
2. Press the Enter key.
3. Use the Down Arrow key to highlight the Graphic/Text icon.
4. Press Enter key to select the icon. Use the Up or Down Arrow key to toggle to desired setting.
5. Press Enter to confirm selection.
CUSTOMIZING THE LOWER PARAMETER WINDOW
The lower setup screen parameters can be modified to change the row indicator type and size. Row indicator types include blinking box (blink rate proportional to seeding rate), solid box (indicating row failure), bar graph, or wiper gauge.
To Change the Row Indicator Type and Row Indicator Size:
1. Press the Display & Service key with the Lower Parameter row indicator icon highlighted.
2. Press Enter to display the lower setup screen.
3. Highlight the Row Indicator Type or Row Indicator Size icon to change.
4. Press the Up or Down Arrow key to cycle through desired setting.
5. Press Enter to accept selection.
Up and Down Arrow keys
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
MONITORING PLANTING / 37
OPERATOR’S MANUAL
1 2 3 4 5 6 7 8
blinking box
solid box
bar graph
wiper gauge
SET LOWER TYPE
Row Indicator Type
Row Indicator Size
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
16,8
33,1
16,8
33,1
1 2 3 4 5 6 7 8 9
16,8
33,1
1 2 3 4 5 6
Small Row Indicators Medium Row Indicators
Large Row Indicators
Left and Right Arrow keys
Figure 26
Lower Parameters Screen
Row indicator size determines the number of rows displayed on the bottom half of the screen and may be displayed in a small, medium, or large size as shown in Figure 27. Default setting is non-blinking box, medium size.
When more rows are configured ON than are viewable, the monitor automatically scrolls through the rows at 5 second intervals (bar graph with 36-row machine). The operator may use the Right and Left Arrow keys to manually select the desired rows. Automatic scrolling will restart 10 seconds after a manual selection.
Average Population
38 / MONITORING PLANTING
Figure 27
Row Indicator Size
AVAILABLE PLANTING PARAMETERS
AVERAGE POPULATION
Average Population displays the average of the planter's rows that are
configured for population in thousands of seeds per acre (s/ac) or thousands of seeds per hectare (s/ha). The population response rate and population adjustment may be modified on the target set-up screen. This function may be labeled with a symbol or text, depending on the text/ graphic setting.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
...
...
...
Minimum/Average/Maximum Population
Population Row Scan
Average Spacing
MINIMUM/AVERAGE/MAXIMUM POPULATION
Minimum/Average/Maximum Population alternates the display of the
minimum row, planter average, and maximum row every two seconds. When a minimum or maximum row is displayed, the corresponding symbol is shown with the row number.
POPULATION ROW SCAN
Population Row Scan displays the population of each of the planter’s
rows. The displayed row is incremented every two seconds. After the last row is displayed, the scan will resequence beginning with the first active row.
AVERAGE SPACING
Average Spacing displays the average seed spacing (inches or cm) of the
planter's rows that are configured for population. This function may be labeled with a symbol or text, depending on the text/graphic setting.
MINIMUM/AVERAGE/MAXIMUM SPACING
Minimum/Average/Maximum Spacing
Spacing Row Scan
Seeds Per Distance
Minimum/Average/Maximum Seeds Per Distance
Minimum/Average/Maximum Spacing alternates the display of the minimum row, planter average, and maximum row every two seconds. When a minimum or maximum row is displayed, the corresponding symbol is shown with the row number.
SPACING ROW SCAN
Spacing Row Scan displays the spacing of each of the planter's rows. The
displayed row is incremented every two seconds. After the last row is displayed, the scan will resequence beginning with the first active row.
SEEDS PER DISTANCE
Average Seeds Per Distance displays the average seeds per foot (s/ft) or
seeds per meter (s/m) of the planter's rows that are configured for population. This function may be labeled with a symbol or text, depending on the text/graphic setting.
MINIMUM/AVERAGE/MAXIMUM SEEDS PER DISTANCE
Minimum/Average/Maximum Seeds Per Distance alternates the display
of the minimum row, planter average, and maximum row every two seconds. When a minimum or maximum row is being displayed, the corresponding symbol is shown with the row number.
SEEDS PER DISTANCE ROW SCAN
Seeds Per Distance Row Scan
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
Seeds Per Distance Row Scan displays the seeds per distance of each of the planter's rows. The displayed row is incremented every two seconds. After the last row is displayed, the scan will resequence beginning with the first active row.
MONITORING PLANTING / 39
OPERATOR’S MANUAL
1
2
Field Area 1
FIELD AREA 1
Field Area 1 (ac1/ha1) displays the area of Field 1 in acres (ac) or hectares
(ha) depending on the English/Metric setting. This function may be labeled with a symbol or text, depending on the text/graphic setting.
FIELD AREA 2
Field Area 2 (ac2/ha2) displays the area of Field 2 in acres (ac) or hectares
(ha) depending on the English/Metric setting. This function may be labeled with a symbol or text, depending on the text/graphic setting.
Field Area 2
Tota l Ar ea
Speed
Area Per Hour
TOTAL AR EA
Total Are a (ac3/ha3) displays the total field area in acres (ac) or hectares
(ha) depending on the English/Metric setting. This function may be labeled with a symbol or text, depending on the text/graphic setting.
SPEED
Speed displays vehicle speed in miles per hour (MPH) or kilometers per
hour (km/h) depending on the English/Metric setting. This function may be labeled with a symbol or text, depending on the text/graphic setting.
AREA PER HOUR
Area Per Hour displays the current rate of area per hour in acres per hour
(ac/hr) or hectares per hour (ha/hr) depending on the English/Metric setting.
FAN
Fan displays the fan's speed in revolutions per minute (RPM).
SHAFT
Shaft function displays the shaft's speed in revolutions per minute (RPM).
FLOW
Fan
Shaft
Flow
40 / MONITORING PLANTING
Flow displays the flow rate speed in gallons per acre (g/ac) or liters per hectare (l/ha) depending on the English/Metric setting.
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
1
2
HOPPER 1 LOW HOPPER 2 LOW
ALARMS
NOTE: An audible 2-chirp alarm is also
output during navigation or data entry to indicate an illegal or nonfunctional key selection.
Alarm Cancel key
Primary operating alarms are displayed on the entire screen and are accompanied by an audible alarm.
All monitor alarms are set to a default of Zero (0) and will not activate unless programmed per the Advanced Setup section.
HOPPER LEVEL
Hopper level alarms activate when the seed level drops below the sensor mounting level (refer to figure 28). Alarm can be silenced by pressing the Alarm Cancel key.
Figure 28
Hopper 1 And 2 Alarms
ROW FAILURE
A row failure alarm occurs when the console detects less than 2 seeds per second through the seed tube. This may result from a poor or faulty connection to the seed sensor harness. This is a solid on alarm indicating a problem has been detected and is silenced by pressing the Alarm Cancel key as shown in Figure 29.
Once the Alarm Cancel key is pressed, the alarm will not sound again unless:
1. Planting condition returns to a normal state and falls again below 2
2. Power on/off sequence occurs before problem is corrected.
3. An All Rows Failure alarm occurs then the console again detects less
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
seeds per second.
than 2 seeds per second through the seed tube.
ALARMS / 41
OPERATOR’S MANUAL
1 3 5 7
Row Failure
Figure 29
Row Failure Display
ALL ROWS FAILURE
An All Row Failure alarm is a unique alarm identifier (8 chirps) that differentiates from all other alarms and triggers when no seed flow is detected from any row unit when ground speed is detected.
Typical scenarios to activate an All Row Failure alarm:
1. Tractor is stopped while planter is in the ground.
2. Tractor is operating with planter lifted.
3. Normal “end of run” turn around.
Figure 30
All Rows Failure Display
42 / ALARMS
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
2 4 6 8
2 4 6 8
LOW FAN SPEED
HIGH FAN SPEED
HI/LOW POPULATION WARNING
The Hi and Low population alarm triggers when seed flow drops below the population alarm limit set on the Limits Setup screen. The alarm display will beep and flash on the screen briefly indicating row units are over or under the desired population (refer to Figure 31). The Operate (Main) screen will display the row unit over or under population symbol until recorrected, All Rows Failure occurs, or sensor mechanical problems are fixed.
Figure 31
Population Limit Warning Display
FAN SPEED LO/HI LIMIT WARNING
Fan speed alarms are triggered with a solid-on alarm when any fan speed exceeds or falls below the value entered for Fan Speed Lo/Hi Limits in the Setup mode (Refer to Figure 32). Alarm can be silenced by pressing Alarm Cancel key, but will re-activate if problem is not resolved.
Figure 32
Fan Speed Limit Warning Display (Optional)
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ALARMS / 43
OPERATOR’S MANUAL
LOW SHAFT SPEED
HI SHAFT SPEED
LOW FLOW RATE
HIGH FLOW RATE
SHAFT SPEED LOW/HI LIMIT WARNING
Alarm sounds when any shaft speed exceeds or falls below the value entered for Shaft Speed Lo or Hi Limits in the Setup mode (Refer to Figure
33). Alarm can be silenced by pressing Alarm Cancel key, but will re-activate if problem is not resolved.
Figure 33
Shaft Speed Limit Warning Display (Optional)
FLOW LOW/HI LIMIT WARNING
An alarm will sound when flow inputs exceed or fall below the value entered for the Flow Lo or Hi Limits in the Setup mode. (Refer to Figure 34). Alarm can be silenced by pressing Alarm Cancel key, but will re-activate if problem is not resolved.
Figure 34
Flow Low/ Hi Limit Warning Display (Optional)
44 / ALARMS
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
=
00.0
GROUND SPD FAILED
16.5
HI BATTERY VOLTAGE
FAILED GROUND SPEED SENSOR (PLANTING DETECTED WITHOUT GROUND SPEED)
The failed ground speed sensor alarm triggers when planting is detected with no ground speed being reported. This may result from a poor or faulty connection to the speed sensor or from a defective sensor. This is a 4-chirp alarm which is acknowledged by pressing the Alarm Cancel key, but will re-activate until the problem is corrected.
Figure 35
Ground Speed Sensor Failure Display
BATTERY HI/LOW
The battery hi/low alarm triggers when battery voltage is out of range - over voltage and under voltage. The correct power operating range is 10-16 VDC. Alarm indicates an electrical problem exists that must be corrected. The alarm cannot be shut off and will continue to sound until corrective action is taken.
Figure 36
Battery Failure Display
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
ALARMS / 45
OPERATOR’S MANUAL
2 4 5 6
SELF TEST FAILURE
7 8 9
10
11
12
HI GROUND SPEED
SELF-TEST FAILURE
The Self Test Failure alarm activates at every power cycle comparing configured number of rows to number of rows detected. Any sensor not found during self-test or inaccurate configuration will sound alarm and display on the Operate (main) screen. The alarm can be acknowledged by pressing the Alarm Cancel key, but will re-activate until problem is resolved.
Figure 37
Self Test Failure
HI GROUND SPEED EXCEEDED (OPTIONAL)
The Hi Ground Speed Exceeded alarm is triggered anytime the speed has exceeded the mph input in the Ground Speed Setup screen. Alarm can be silenced by pressing the Alarm Cancel key.
Figure 38
Maximum Speed Exceeded Warning Display (Optional)
46 / ALARMS
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
TROUBLESHOOTING
MONITOR WILL NOT POWER ON
Probable Cause
1. Blown console fuse
2. Poor battery connection
3. Low battery voltage
4. Defective console
Corrective Action
1. Check fuse (located near battery connection). If needed, replace with
5.0 A fuse maximum. If fuse blows again, check all harnesses for pinches or breaks that may cause power short to ground.
2. Be sure connections are clean and tight. Inspect harness for damage.
3. Console voltage must be at least 10 V. If low, recharge or replace battery.
4. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
ROW FAILURE OR HI/LOW ALARM WHEN ROW IS PLANTING PROPERLY
Probable Cause
1. Seed sensor coated with dirt
2. Faulty sensor or harness
3. Defective console
Corrective Action
1. Clean sensor using a dry bottle brush.
2. Drop seed down the seed tube or place a dry bottle brush down the seed tube to trigger sensor. Observe if troubleshooting sensor LED mounted to the tube blinks. If sensor does not blink, replace the sensor. If the sensor LED blinks, check harness for damage or pinched wires. If the sensor does not have an LED, swap harness connection with adjacent sensor to determine if sensor is damaged.
3. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
TROUBLESHOOTING / 47
OPERATOR’S MANUAL
HOPPER ALARM DOES NOT SOUND WHEN HOPPER IS EMPTY
Probable Cause
1. Hopper sensor coated with dirt
2. Faulty sensor or harness shorted to ground
3. Defective console
Corrective Action
1. Clean sensor using a dry bottle brush.
2. Swap harness connection with another sensor to determine if sensor or harness is damaged. Use service screen if another sensor is not available. Replace sensor or repair harness.
3. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
HOPPER ALARM SOUNDS WHEN HOPPER IS FULL
Probable Cause
1. Faulty sensor or harness open
2. Defective console
Corrective Action
1. Swap harness connection with another sensor to determine if sensor or harness is damaged. Use service screen if another sensor is not available. Replace sensor or repair harness.
2. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
SYSTEM VOLTAGE ALARM
Probable Cause
1. Low battery voltage
2. Poor battery connection
3. Damaged harness
Corrective Action
1. Console voltage must be at least 10 V. If low, recharge or replace battery.
2. Be sure connections are clean and tight. Inspect harness for damage.
3. Check all harnesses for pinches or breaks that may cause power or 8 V-sensor power short to ground.
48 / TROUBLESHOOTING
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
ACCESSORY ALARM SOUNDS WHEN SHAFT, FAN, OR FLOW IS WORKING
Probable Cause
1. Sensor failure
2. Wrong calibration number
3. Incorrect limits
4. Defective console
Corrective Action
1. Shaft, fan, or flow sensor not operating. Replace defective sensors.
2. Sensor calibration number is incorrect. Check calibration number in accessory setup screen.
3. Sensor limits are incorrect. Check limits in accessory setup screen.
4. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
GROUND SPEED ALARM SOUNDS WITH FORWARD MOVEMENT
Probable Cause
1. Ground speed sensor failure
2. Console failure
Corrective Action
1. No ground speed sensor is detected, or planting is detected on at least one row with no ground speed. Replace faulty ground speed sensor.
2. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
GROUND SPEED HIGH ALARM SOUNDS
Probable Cause
1. Ground speed alarm set too low
2. Incorrect ground speed constant
Corrective Action
1. Set ground speed alarm limit higher or to zero to disable.
2. Ground speed sensor has not been calibrated, RADAR sensor angle has changed, or incorrect sensor constant is entered. Use SPEED, AREA, DISTANCE mode to determine if speed is correct. If incorrect, recalibrate speed constant (Speed Setup screen).
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
TROUBLESHOOTING / 49
OPERATOR’S MANUAL
SELF-TEST ALARM
Probable Cause
1. Faulty sensor or harness
2. Console failure
Corrective Action
1. Trigger sensor and observe troubleshooting LED. If sensor does not have LED, swap harness connection with adjacent sensor to determine if sensor or harness is damaged. Replace sensor or harness.
2. Console is damaged. Contact your dealer, DICKEY-john USA (1-800-637-3302) or DICKEY-john Europe (011-33-141-192189).
50 / TROUBLESHOOTING
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
OPERATOR’S MANUAL
Battery Pin Label Description
Red Wire Battery +12V Black Wire Battery Ground
PM300 Implement Pin # Description
1 Row 1 (green) 2 Row 2 (brown) 3 Row 3 (blue) 4 Row 4 (orange) 5 Row 5 (yellow) 6 Row 6 (violet) 7 Row 7 (gray) 8 Row 8 (pink) 9 Row 9 (tan) 10 Row 10 (white/black) 11 Row 11 (red/black) 12 Row 12 (green/black) 13 Row 13 (orange/black) 14 Row 14 (blue/black) 15 Row 15 (black/white) 16 Row 16 (red/white) 17-23 No connection 24 8 V sensor power (red) 25 8 V sensor power (red/black/white) 26 Sensor return (black) 27 Sensor return (white/black/red) 28 No connection 29 Hopper 1 (green/white) 30 Hopper 2 (blue/white) 31 Shaft/Fan/Flow (black/red) 32 8 V power (red) 33 12 V switched power (white/red) 34 12 V return (black) 35 RS-232 Rx (blue/red) 36 RS-232 Tx (red/green) 37 Lift switch (orange/red)
Ground Speed Pin # Description
1 Ground (black) 2 Signal (green) 3 Power (red) 4 Sense (white)
PM332 Implement Pin # Description
1 Row 1 green) 2 Row 2 (brown) 3 Row 3 (blue) 4 Row 4 (orange) 5 Row 5 (yellow) 6 Row 6 (violet) 7 Row 7 (gray) 8 Row 8 (pink) 9 Row 9 (tan) 10 Row 10 (white/black) 11 Row 11 (red/black) 12 Row 12 (green/black) 13 Row 13 (orange/black) 14 Row 14 (blue/black) 15 Row 15 (black/white) 16 Row 16 (red/white) 17 Row 17 (green/white) 18 Row 18 (blue/white) 19 Row 19 (black/red) 20 Row 20 (white/red) 21 Row 21 (orange/red) 22 Row 22 (blue/red) 23 Row 23 (red/green) 24 +8 V Snsr Pwr Left (red) 25 +8 V Snsr Pwr Right (red/blk/white) 26 Ground Left (black) 27 Ground Right (white/black/red) 28 Row 24 (orange) 29 Row 25 (black/white/red) 30 Row 26 (green/black/white) 31 Row 27 (orange/black/white) 32 Row 28 (blue/black/white) 33 Row 29 (black/red/green) 34 Row 30 (white/red/green) 35 Row 31 (red/black/green) 36 Row 32 (green/black/orange) 37 Lift Switch (white)
CONNECTOR PIN-OUTS
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
TROUBLESHOOTING / 51
OPERATOR’S MANUAL
PM332 Implement Accessory Harness Pin # Description
1 Lift Switch (light green) 2 Hopper # 1 (brown) 3 Hopper # 2 (light blue) 4 Frequency (orange) 5 +8 V Acc Power (yellow) 6 + 12 V Acc Power (purple) 7 Acc Return (gray) 8 RS-232 Rx (pink) 9 RS-232 Tx (neutral)
PM400 Implement 1 Pin # Description
1 Row 1 (green) 2 Row 2 (brown) 3 Row 3 (blue) 4 Row 4 (orange) 5 Row 5 (yellow) 6 Row 6 (violet) 7 Row 7 (gray) 8 Row 8 (pink) 9 Row 9 (tan) 10 Row 10 (white/black) 11 Row 11 (red/black) 12 Row 12 (green/black) 13 Row 13 (orange/black) 14 Row 14 (blue/black) 15 Row 15 (black/white) 16 Row 16 (red/white) 17 Row 17 (green/white) 18 Row 18 (blue/white) 19 Row 19 (black/red) 20 Row 20 (white/red) 21 Row 21 (orange/red) 22 Row 22 (blue/red) 23 Row 23 (red/green) 24 +8 V Snsr Pwr Left (red) 25 +8 V Snsr Pwr Right (red)
PM400 Implement 2 Pin # Description
1 Row 25 (green) 2 Row 26 (brown) 3 Row 27 (blue) 4 Row 28 (orange) 5 Row 29 (yellow) 6 Row 30 (violet) 7 Row 31 (gray) 8 Row 32 (pink) 9 Row 33 (tan) 10 Row 34 (white/black) 11 Row 35 (red/black) 12 Row 36 (green/black) 13-23 No connection 24 8 V sensor power (red/black/white) 25 8 V sensor power (red) 26 Sensor return (white/black/red) 27 Sensor return (black) 28 No connection 29 No connection 30 No connection 31 No connection 32 No connection 33 No connection 34 No connection 35 No connection 36 No connection 37 No connection
PM400 Implement 1 (continued) Pin # Description
26 Sensor return left (black) 27 Sensor return right (black) 28 Row 24 (orange/green) 29 Hopper 1 (black/white/red) 30 Hopper 2 (green/black/white) 31 Shaft/Fan/Flow (orange/black/white) 32 8V power (red) 33 12V switched power (black/red/green) 34 Sensor return (black) 35 RS-232 RX (red/black/green) 36 RS-232 TX (green/black/orange) 37 Lift switch (white)
CONNECTOR PIN-OUTS
52 / TROUBLESHOOTING
PM300, PM332, PM400 Planter Monitors
11001-1372-201702 Rev B
Dealers have the responsibility of calling to the attention of their customers the following
warranty prior to acceptance of an order from their customer for any DICKEY-john product.
DICKEY-john® WARRANTY
DICKEY-john warrants to the orig inal purchaser for use that, if any part of the product proves to be defective in material or workmanship within one year from date of original installation, and is returned to DICKEY-john within 30 days after such defect is discovered, DICKEY-john will (at our option) either replace or repair said part. This warrant y does not ap ply to damage resulting f r om misuse, neglect, accident, or im proper inst a llatio n or maintenance; any expenses or liabi lity for rep airs made b y outside p arties without DICKEY-j ohn’s written consent; damage to any associated equipment; or lost profits or s pecial damages. Said part will not be considered defective if it substantially fulfills the perform ance expectations. THE FOREGOING WARRANTY IS EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES OF MERCHANTABILITY, FITNESS FOR PURPOSE, AND OF ANY OTHER TYPE, WHETHER EXPRESS OR IMPLIED. DICKEY-john neither assumes nor authorizes anyone t o assume for it any other obligation or liability in connection with said part and will not be liable for consequential damages. Purchaser accepts these terms and warranty limitations unless the product is returned within fifteen days for full refund of purchase price.
For DICKEY- john Service Department, call
1-800-637-3302 in either the U.S.A. or Canada
Headquarters:
5200 Dickey-john Road, Auburn, IL USA 62615
TEL: 217 438 3371, FAX: 217 438 6012, WEB: www.dickey-john.com
Europe:
DICKEY-john Europe S.A.S, 165, boulevard de Valmy, 92706 – Colombes – France
TEL: 33 (0) 1 41 19 21 80, FAX: 33 (0) 1 47 86 00 07 WEB: www.dickey-john.com
Specifications subject to change without notice.
© 2017 DICKEY-john
PM300 - 332 - 400 PLANTER MONITORS
DICKEY-john Sales
800-637-2952 agsales@dickey-john.com
DICKEY-john Technical Support
800-637-3302 service@dickey-john.com
Europe Sales and Technical Support
+33 1 41 19 21 80 europe@dickey-john.com
Operator’s Manual
5200 Dickey-john Road Auburn, IL 62615
www.dickey-john.com
217-438-3371 217-438-6012 fax
©2017 DICKEY-john
DICKEY-john, the DICKEY-john Logo and IntelliAg are registered trademarks of DICKEY-john.
11001-1372-201702 Rev B
Loading...