SAFETY DATA SHEET
Revision Date 15-May-2015
1. IDENTIFICATION
Product identifier
Product Name
Other means of identification
Product Code
Synonyms
Recommended use of the chemical and restrictions on use
Recommended Use
Uses advised against
Details of the supplier of the safety data sheet
Manufacturer Address
ITW Permatex
10 Columbus Blvd.
Hartford, CT 06106 USA
Company Phone Number
24 Hour Emergency Phone Number
DEVCON HOME SUPER GLUE 2 GR.
29045
None
This product is a cyanoacrylate-based adhesive
No information available
Distributor
ITW Permatex Canada
35 Brownridge Road, Unit 1
Halton Hills, ON Canada L7G 0C6
Telephone: (800) 924-6994
1-87-Permatex
(877) 376-2839
Chem-Tel: 800-255-3924
International Emergency:
00+1+ 813-248-0585
Contract Number: MIS0003453
Version 1
E-mail address
mail@permatex.com
2. HAZARDS IDENTIFICATION
Classification
OSHA Regulatory Status
This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Skin corrosion/irritation Category 2
Serious eye damage/eye irritation Category 2
Specific target organ toxicity (single exposure) Category 3
Flammable liquids
Label elements
Emergency Overview
Warning
Causes skin irritation
Causes serious eye irritation
May cause respiratory irritation
Combustible liquid
_____________________________________________________________________________________________
Category 4
Page 1 / 8
Revision Date 15-May-201529045 - DEVCON HOME SUPER GLUE 2 GR.
_____________________________________________________________________________________________
Odor IrritatingAppearance Clear Physical state Liquid
Precautionary Statements - Prevention
Wash face, hands and any exposed skin thoroughly after handling
Wear protective gloves/protective clothing/eye protection/face protection
Avoid breathing dust/fume/gas/mist/vapors/spray
Use only outdoors or in a well-ventilated area
Keep away from heat/sparks/open flames/hot surfaces. — No smoking
Keep cool
Precautionary Statements - Response
Specific treatment (see supplemental first aid instructions on this label)
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing
If eye irritation persists: Get medical advice/attention
IF ON SKIN: Wash with plenty of soap and water
If skin irritation occurs: Get medical advice/attention
Take off contaminated clothing and wash before reuse
IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing
Call a POISON CENTER or doctor/physician if you feel unwell
In case of fire: Use CO2, dry chemical, or foam for extinction
Precautionary Statements - Storage
Store in a well-ventilated place. Keep container tightly closed
Store locked up
Precautionary Statements - Disposal
Dispose of contents/container to an approved waste disposal plant
Hazards not otherwise classified (HNOC)
Not applicable
Other Information
Not applicable.
Unknown acute toxicity 3% of the mixture consists of ingredient(s) of unknown toxicity
3. COMPOSITION/INFORMATION ON INGREDIENTS
substance(s)
Chemical Name CAS No Weight-% Trade Secret
ETHYL-2-CYANOACRYLATE 7085-85-0 60 - 100 *
*The exact percentage (concentration) of composition has been withheld as a trade secret.
4. FIRST AID MEASURES
Description of first aid measures
General advice
Get medical advice/attention if you feel unwell.
_____________________________________________________________________________________________
Page 2 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR. Revision Date 15-May-2015
_____________________________________________________________________________________________
Eye contact
Skin contact
Inhalation
Ingestion
Self-protection of the first aider
Most important symptoms and effects, both acute and delayed
Symptoms
Indication of any immediate medical attention and special treatment needed
Note to physicians
IF IN EYES:. Immediately flush with plenty of water. After initial flushing, remove any
contact lenses and continue flushing for at least 15 minutes. If eyelids are bonded closed,
release eyelashes with warm water by covering with a wet pad. If symptoms persist, call a
physician.
IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin
with water/shower. Wash with soap and water. Allow warm water to penetrate the bond and
gently attempt to move bonded areas without pulling the skin away from bonded area. If
symptoms persist, call a physician.
IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for
breathing. If symptoms persist, call a physician.
IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an
unconscious person. Call a physician.
Use personal protective equipment as required.
See section 2 for more information.
Treat symptomatically.
5. FIRE-FIGHTING MEASURES
Suitable extinguishing media
Carbon dioxide (CO2), Dry chemical, Foam
Unsuitable extinguishing media
None.
Specific hazards arising from the chemical
Combustible material.
Explosion data
Sensitivity to Mechanical Impact
Sensitivity to Static Discharge
Protective equipment and precautions for firefighters
As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full
protective gear.
None.
None.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Personal precautions
Environmental precautions
Environmental precautions
Use personal protective equipment as required. Remove all sources of ignition. Ensure
adequate ventilation, especially in confined areas. Avoid contact with skin, eyes or clothing.
See Section 12 for additional ecological information. Do not flush into surface water or
sanitary sewer system. Prevent further leakage or spillage if safe to do so. Prevent product
from entering drains.
Methods and material for containment and cleaning up
Methods for containment
Prevent further leakage or spillage if safe to do so.
_____________________________________________________________________________________________
Page 3 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR.
Revision Date 15-May-2015
_____________________________________________________________________________________________
Methods for cleaning up
Prevention of secondary hazards
Ensure adequate ventilation. Soak up with inert absorbent material. Sweep up and shovel
into suitable containers for disposal.
Clean contaminated objects and areas thoroughly observing environmental regulations.
7. HANDLING AND STORAGE
Precautions for safe handling
Advice on safe handling
Conditions for safe storage, including any incompatibilities
Storage Conditions
Incompatible materials
Handle in accordance with good industrial hygiene and safety practice. Avoid breathing
vapors or mists. Avoid contact with skin, eyes or clothing. Wash thoroughly after handling.
Wash contaminated clothing before reuse. Use personal protective equipment as required.
Keep away from heat/sparks/open flames/hot surfaces. — No smoking.
Keep away from heat, sparks, flame and other sources of ignition (i.e., pilot lights, electric
motors and static electricity).
Strong oxidizing agents, Water, Alcohols, Amines, Alkalis, Polymerization can occur
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Control parameters
Exposure Guidelines
Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH
ETHYL-2-CYANOACRYLATE
7085-85-0
Appropriate engineering controls
.
TWA: 0.2 ppm - -
Engineering Controls
Individual protection measures, such as personal protective equipment
Eye/face protection
Skin and body protection
Respiratory protection
General Hygiene Considerations
Showers
Eyewash stations
Ventilation systems
Wear safety glasses with side shields (or goggles).
Wear protective gloves and protective clothing.
Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as
appropriate.
When using do not eat, drink or smoke. Regular cleaning of equipment, work area and
clothing is recommended.
9. PHYSICAL AND CHEMICAL PROPERTIES
Information on basic physical and chemical properties
Physical state
Appearance
Odor
Odor threshold
Property
pH
Melting point / freezing point
Boiling point / boiling range
Flash point
Liquid
Clear
Irritating
No information available
Values
No information available
No information available
> 150 °C / 302 °F
85 °C / 185 °F
Remarks • Method
_____________________________________________________________________________________________
Page 4 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR.
Revision Date 15-May-2015
_____________________________________________________________________________________________
Evaporation rate
Flammability (solid, gas)
Flammability Limit in Air
Upper flammability limit:
Lower flammability limit:
Vapor pressure
Vapor density
Relative density
Water solubility
Solubility in other solvents
Partition coefficient
Autoignition temperature
Decomposition temperature
Kinematic viscosity
Dynamic viscosity
Explosive properties
Oxidizing properties
Other Information
Softening point
Molecular weight
VOC Content (%)
Density
Bulk density
No information available
No information available
No information available
No information available
<0.2 mmHg
>1 Air = 1
1.06
Not applicable
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
<20 g/l
No information available
No information available
10. STABILITY AND REACTIVITY
Polymerization
Reactivity
No data available
Chemical stability
Stable under recommended storage conditions.
Possibility of Hazardous Reactions
None under normal processing.
Conditions to avoid
Heat, flames and sparks.
Incompatible materials
Strong oxidizing agents, Water, Alcohols, Amines, Alkalis, Polymerization can occur
Hazardous Decomposition Products
Carbon oxides
11. TOXICOLOGICAL INFORMATION
Information on likely routes of exposure
Inhalation
Eye contact
Skin contact
May cause irritation of respiratory tract. May cause drowsiness or dizziness.
Contact with eyes may cause irritation. May cause redness and tearing of the eyes.
Will bond to skin.
Ingestion
Chemical Name Oral LD50 Dermal LD50 Inhalation LC50
ETHYL-2-CYANOACRYLATE
7085-85-0
Ingestion may cause irritation to mucous membranes.
> 5 mL/kg ( Rat ) - -
_____________________________________________________________________________________________
Page 5 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR. Revision Date 15-May-2015
_____________________________________________________________________________________________
Information on toxicological effects
Symptoms
Delayed and immediate effects as well as chronic effects from short and long-term exposure
Sensitization
Germ cell mutagenicity
Carcinogenicity
The following values are calculated based on chapter 3.1 of the GHS document .
ATEmix (oral)
No information available.
No information available.
No information available.
No information available.
5144 mg/kg
12. ECOLOGICAL INFORMATION
Ecotoxicity
100% of the mixture consists of components(s) of unknown hazards to the aquatic environment
Persistence and degradability
No information available.
Bioaccumulation
No information available.
Mobility
No information available.
Other adverse effects
No information available
13. DISPOSAL CONSIDERATIONS
Waste treatment methods
Disposal of wastes
Contaminated packaging
US EPA Waste Number
Disposal should be in accordance with applicable regional, national and local laws and
regulations.
Do not reuse container.
Not applicable
14. TRANSPORT INFORMATION
DOT
Proper shipping name:
IATA
Proper shipping name:
IMDG
Proper shipping name:
Not regulated
Not regulated
Not regulated
15. REGULATORY INFORMATION
International Inventories
_____________________________________________________________________________________________
Page 6 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR.
Revision Date 15-May-2015
_____________________________________________________________________________________________
TSCA
DSL/NDSL
EINECS/ELINCS
ENCS
IECSC
KECL
PICCS
AICS
Complies
Complies
Complies
Complies
Complies
Complies
Complies
Complies
Legend:
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances
ENCS - Japan Existing and New Chemical Substances
IECSC - China Inventory of Existing Chemical Substances
KECL - Korean Existing and Evaluated Chemical Substances
PICCS - Philippines Inventory of Chemicals and Chemical Substances
AICS - Australian Inventory of Chemical Substances
US Federal Regulations
SARA 313
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any
chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372
SARA 311/312 Hazard Categories
Acute health hazard
Chronic Health Hazard
Fire hazard
Sudden release of pressure hazard
Reactive Hazard
Yes
No
Yes
No
No
CWA (Clean Water Act)
This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40
CFR 122.42)
CERCLA
This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive
Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and
Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level
pertaining to releases of this material
US State Regulations
California Proposition 65
This product does not contain any Proposition 65 chemicals
U.S. State Right-to-Know Regulations
Chemical Name New Jersey Massachusetts Pennsylvania
ETHYL-2-CYANOACRYLATE
7085-85-0
U.S. EPA Label Information
EPA Pesticide Registration Number
NFPA
HMIS
NFPA (National Fire Protection Association)
HMIS (Hazardous Material Information System)
Health hazards 2 Flammability 2
Health hazards 2 Flammability 2
Not applicable
X - -
Instability 0
-
Physical hazards 0 Personal protection B
_____________________________________________________________________________________________
Page 7 / 8
29045 - DEVCON HOME SUPER GLUE 2 GR. Revision Date 15-May-2015
_____________________________________________________________________________________________
Revision Date
Disclaimer
The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief
at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing,
storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The
information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process, unless specified in the text.
15-May-2015
End of Safety Data Sheet
_____________________________________________________________________________________________
Page 8 / 8
Loading...