SAFETY DATA SHEET
Revision Date 30-Jul-2015
1. IDENTIFICATION
Product identifier
Product Name
Other means of identification
Product Code
Synonyms
Recommended use of the chemical and restrictions on use
Recommended Use
Uses advised against
Details of the supplier of the safety data sheet
Manufacturer Address
ITW Permatex
10 Columbus Blvd.
Hartford, CT 06106 USA
Company Phone Number
24 Hour Emergency Phone Number
DEVCON HOME SILICONE ADHESIVE 50 GR.
12045
None
Sealant
No information available
Distributor
ITW Permatex Canada
35 Brownridge Road, Unit 1
Halton Hills, ON Canada L7G 0C6
Telephone: (800) 924-6994
1-87-Permatex
(877) 376-2839
Chem-Tel: 800-255-3924
International Emergency:
00+1+ 813-248-0585
Contract Number: MIS0003453
Version 6
E-mail address
mail@permatex.com
2. HAZARDS IDENTIFICATION
Classification
OSHA Regulatory Status
This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
NOTE: This product is a consumer product and is labeled in accordance with the US Consumer Product Safety
Commission regulations which take precedence over OSHA Hazard Communication labeling. The actual container label
will not include the label elements below. The labeling below applies to industrial/professional products.
Label elements
Emergency Overview
The product contains no substances which at their given concentration, are considered to be hazardous to health
Appearance Clear Physical state Paste Odor Acetic acid
_____________________________________________________________________________________________
Page 1 / 8
Revision Date 30-Jul-201512045 - DEVCON HOME SILICONE ADHESIVE 50 GR.
_____________________________________________________________________________________________
Precautionary Statements - Storage
Protect from moisture
Precautionary Statements - Disposal
Dispose of contents/container to an approved waste disposal plant
Hazards not otherwise classified (HNOC)
Not applicable
Other Information
- The classification as a carcinogen need not apply if the full refining history is known and it can be shown that the substance from
which it is produced is not a carcinogen. This note applies only to certain complex oil derived substances in Annex I
- Acetic acid produced during curing can irritate eyes, nose and throat
Unknown acute toxicity 2.7 % of the mixture consists of ingredient(s) of unknown toxicity
3. COMPOSITION/INFORMATION ON INGREDIENTS
substance(s)
Chemical Name CAS No Weight-% Trade Secret
POLY (DIMETHYLSILOXANE), HYDROXY
TERMINATED
DISTILLATES (PETROLEUM), HYDROTREATED
MIDDLE
AMORPHOUS SILICA 7631-86-9 7 - 13 *
METHYLTRIACETOXYSILANE 4253-34-3 1 - 5 *
ETHYLTRIACETOXYSILANE 17689-77-9 1 - 5 *
*The exact percentage (concentration) of composition has been withheld as a trade secret.
70131-67-8 40 - 70 *
64742-46-7 10 - 30 *
4. FIRST AID MEASURES
Description of first aid measures
General advice
Eye contact
Skin contact
Inhalation
Ingestion
Self-protection of the first aider
Most important symptoms and effects, both acute and delayed
Symptoms
Indication of any immediate medical attention and special treatment needed
Note to physicians
Get medical advice/attention if you feel unwell.
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. If eye irritation persists: Get medical
advice/attention.
IF ON SKIN:. Wash skin with soap and water. If skin irritation persists, call a physician.
Wash contaminated clothing before reuse.
IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for
breathing. If symptoms persist, call a physician.
IF SWALLOWED:. Do NOT induce vomiting. Never give anything by mouth to an
unconscious person. Call a physician.
Use personal protective equipment as required.
See section 2 for more information.
Treat symptomatically.
5. FIRE-FIGHTING MEASURES
_____________________________________________________________________________________________
Page 2 / 8
12045 - DEVCON HOME SILICONE ADHESIVE 50 GR. Revision Date 30-Jul-2015
_____________________________________________________________________________________________
Suitable extinguishing media
Carbon dioxide (CO2), Dry chemical, Foam
Unsuitable extinguishing media
None.
Specific hazards arising from the chemical
None in particular.
Explosion data
Sensitivity to Mechanical Impact
Sensitivity to Static Discharge
None.
None.
Protective equipment and precautions for firefighters
As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full
protective gear.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions, protective equipment and emergency procedures
Personal precautions
Avoid contact with eyes and skin. Wash thoroughly after handling.
Environmental precautions
Environmental precautions
Do not flush into surface water or sanitary sewer system. See Section 12 for additional
ecological Information.
Methods and material for containment and cleaning up
Methods for containment
Methods for cleaning up
Prevent further leakage or spillage if safe to do so.
Ensure adequate ventilation. Flood with water to complete polymerization and scrape off
floor. Sweep up and shovel into suitable containers for disposal. Slippery, can cause falls if
walked on.
Prevention of secondary hazards
Clean contaminated objects and areas thoroughly observing environmental regulations.
7. HANDLING AND STORAGE
Precautions for safe handling
Advice on safe handling
Conditions for safe storage, including any incompatibilities
Storage Conditions
Handle in accordance with good industrial hygiene and safety practice. Avoid contact with
skin and eyes.
Keep containers tightly closed in a cool, well-ventilated place. Protect from moisture.
Incompatible materials
Strong oxidizing agents, Acids, Water
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Control parameters
Exposure Guidelines
Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH
AMORPHOUS SILICA
7631-86-9
_____________________________________________________________________________________________
.
- (vacated) TWA: 6 mg/m3 <1%
Crystalline silica
TWA: 20 mppcf
: (80)/(% SiO2) mg/m3 TWA
IDLH: 3000 mg/m
TWA: 6 mg/m
3
3
Page 3 / 8
12045 - DEVCON HOME SILICONE ADHESIVE 50 GR.
Revision Date 30-Jul-2015
_____________________________________________________________________________________________
NIOSH IDLH Immediately Dangerous to Life or Health
Other Information
Appropriate engineering controls
Engineering Controls
Individual protection measures, such as personal protective equipment
Eye/face protection
Skin and body protection
Respiratory protection
General Hygiene Considerations
Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962
(11th Cir., 1992).
Eyewash stations
Wear safety glasses with side shields (or goggles).
Wear protective gloves and protective clothing.
Use NIOSH-approved air-purifying respirator with organic vapor cartridge or canister, as
appropriate.
When using do not eat, drink or smoke. Regular cleaning of equipment, work area and
clothing is recommended.
9. PHYSICAL AND CHEMICAL PROPERTIES
Information on basic physical and chemical properties
Physical state
Appearance
Odor
Odor threshold
Paste
Clear
Acetic acid
No information available
Property
pH
Melting point / freezing point
Boiling point / boiling range
Flash point
Evaporation rate
Flammability (solid, gas)
Flammability Limit in Air
Upper flammability limit:
Lower flammability limit:
Vapor pressure
Vapor density
Relative density
Water solubility
Solubility in other solvents
Partition coefficient
Autoignition temperature
Decomposition temperature
Kinematic viscosity
Dynamic viscosity
Explosive properties
Oxidizing properties
Other Information
Softening point
Molecular weight
VOC Content (%)
Density
Bulk density
Values
No information available
No information available
Not Applicable
> 93 °C / > 200 °F
No information available
No information available
No information available
No information available
No information available
>1
0.96
Not applicable
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
No information available
23 g/L
No information available
No information available
Remarks • Method
Polymerization
Air = 1
Polymerization
10. STABILITY AND REACTIVITY
_____________________________________________________________________________________________
Page 4 / 8
Revision Date 30-Jul-201512045 - DEVCON HOME SILICONE ADHESIVE 50 GR.
_____________________________________________________________________________________________
Reactivity
No data available
Chemical stability
Stable under recommended storage conditions.
Possibility of Hazardous Reactions
None under normal processing.
Conditions to avoid
Excessive heat.
Incompatible materials
Strong oxidizing agents, Acids, Water
Hazardous Decomposition Products
Carbon oxides
Nitrogen oxides (NOx)
Acetic acid
Formaldehyde
11. TOXICOLOGICAL INFORMATION
Information on likely routes of exposure
Inhalation
Eye contact
Skin contact
Ingestion
Chemical Name Oral LD50 Dermal LD50 Inhalation LC50
POLY (DIMETHYLSILOXANE),
HYDROXY TERMINATED
70131-67-8
DISTILLATES (PETROLEUM),
HYDROTREATED MIDDLE
64742-46-7
AMORPHOUS SILICA
7631-86-9
METHYLTRIACETOXYSILANE
4253-34-3
May cause irritation of respiratory tract.
Contact with eyes may cause irritation. May cause redness and tearing of the eyes.
May cause skin irritation and/or dermatitis.
Ingestion may cause irritation to mucous membranes.
- > 16 mL/kg ( Rabbit ) > 8750 mg/m3 ( Rat ) 7 h
= 7400 mg/kg ( Rat ) > 2000 mg/kg ( Rabbit ) = 4.6 mg/L ( Rat ) 4 h
> 5000 mg/kg ( Rat ) > 2000 mg/kg ( Rabbit ) > 2.2 mg/L ( Rat ) 1 h
= 2060 mg/kg ( Rat ) - -
Information on toxicological effects
Symptoms
No information available.
Delayed and immediate effects as well as chronic effects from short and long-term exposure
Sensitization
Germ cell mutagenicity
Carcinogenicity
Chemical Name ACGIH IARC NTP OSHA
AMORPHOUS SILICA
7631-86-9
IARC (International Agency for Research on Cancer)
Not classifiable as a human carcinogen
Target Organ Effects
No information available.
No information available.
The table below indicates whether each agency has listed any ingredient as a carcinogen.
- Group 3 - -
Eyes, Respiratory system, Skin, Teeth.
The following values are calculated based on chapter 3.1 of the GHS document .
ATEmix (oral)
15169 mg/kg
_____________________________________________________________________________________________
Page 5 / 8
12045 - DEVCON HOME SILICONE ADHESIVE 50 GR. Revision Date 30-Jul-2015
_____________________________________________________________________________________________
ATEmix (dermal)
ATEmix (inhalation-dust/mist)
4633 mg/kg
5.5 mg/l
12. ECOLOGICAL INFORMATION
Ecotoxicity
67 % of the mixture consists of components(s) of unknown hazards to the aquatic environment
Chemical Name Algae/aquatic plants Fish Crustacea
DISTILLATES (PETROLEUM),
HYDROTREATED MIDDLE
64742-46-7
AMORPHOUS SILICA
7631-86-9
Persistence and degradability
No information available.
Bioaccumulation
No information available.
Mobility
No information available.
Other adverse effects
No information available
440: 72 h Pseudokirchneriella
subcapitata mg/L EC50
- 35: 96 h Pimephales promelas mg/L
LC50 flow-through 10000: 96 h
Pimephales promelas mg/L LC50
static
5000: 96 h Brachydanio rerio mg/L
LC50 static
-
7600: 48 h Ceriodaphnia dubia
mg/L EC50
Waste treatment methods
Disposal of wastes
Contaminated packaging
US EPA Waste Number
DOT
Proper shipping name:
IATA
Proper shipping name:
IMDG
Proper shipping name:
International Inventories
TSCA
DSL/NDSL
EINECS/ELINCS
13. DISPOSAL CONSIDERATIONS
Disposal should be in accordance with applicable regional, national and local laws and
regulations.
Do not reuse container.
Not applicable
14. TRANSPORT INFORMATION
Not regulated
Not regulated
Not regulated
15. REGULATORY INFORMATION
Complies
Complies
Not Listed.
_____________________________________________________________________________________________
Page 6 / 8
12045 - DEVCON HOME SILICONE ADHESIVE 50 GR.
Revision Date 30-Jul-2015
_____________________________________________________________________________________________
ENCS
IECSC
KECL
PICCS
AICS
Not Listed.
Complies
Complies
Complies
Complies
Legend:
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances
ENCS - Japan Existing and New Chemical Substances
IECSC - China Inventory of Existing Chemical Substances
KECL - Korean Existing and Evaluated Chemical Substances
PICCS - Philippines Inventory of Chemicals and Chemical Substances
AICS - Australian Inventory of Chemical Substances
US Federal Regulations
SARA 313
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any
chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372
SARA 311/312 Hazard Categories
Acute health hazard
Chronic Health Hazard
Fire hazard
Sudden release of pressure hazard
Reactive Hazard
Yes
No
No
No
No
CWA (Clean Water Act)
This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR 122.21
and 40 CFR 122.42)
CERCLA
This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive
Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302)
US State Regulations
California Proposition 65
This product does not contain any Proposition 65 chemicals
U.S. State Right-to-Know Regulations
Chemical Name New Jersey Massachusetts Pennsylvania
AMORPHOUS SILICA
7631-86-9
ACETIC ACID
64-19-7
U.S. EPA Label Information
EPA Pesticide Registration Number
NFPA
HMIS
NFPA (National Fire Protection Association)
HMIS (Hazardous Material Information System)
Health hazards 1 Flammability 1
Health hazards 1 Flammability 1 Physical hazards 0 Personal protection B
Not applicable
X X X
X X X
Instability 0
-
Revision Date
30-Jul-2015
_____________________________________________________________________________________________
Page 7 / 8
12045 - DEVCON HOME SILICONE ADHESIVE 50 GR. Revision Date 30-Jul-2015
_____________________________________________________________________________________________
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage,
transportation, disposal and release and is not to be considered a warranty or quality specification. The information
relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.
End of Safety Data Sheet
_____________________________________________________________________________________________
Page 8 / 8
Loading...