Desco TB-7017 User Manual

TB-7017 October 2008 Page 1 of 2

Material Safety Data Sheet

Material Safety Data Sheet maybe used to comply with
EC, according to 91/155EC and ANSI Standard Z400.1-1998
Date: October 1, 2008

1
0

0

0

Flammability

(Red)

Reactivity

(Yellow)

Health

(Blue)

Special Hazard

NFPA Designation 704

Degree of Hazard
4 = Extreme 1 = Slight
3 = High 0 = Insignificant
2 = Moderate

Statfree T2™ Dissipative Dual Layer Rubber
Section I. Identification of the Product and of the Enterprise

Identity: Statfree T2™ Dissipative Dual Layer Rubber Emergency: Phone: [phone]
Manufacturer: Desco Industries Inc. Fax:[phone]

90 Hudson Road
Canton, MA 02021
U.S.A.

Section II. Health Data

First Aid Measures: The product is and article and has no significant toxic hazard. Hazardous fumes can be produced by

combustion or high temperature decomposition

If Exposed to Fumes From Combustion

:

Skin Contact: Flush skin thoroughly with cool water for at least five minutes.
Eye Contact: Immediately flush eyes with a directed stream of water for at least 15 minutes, while forcibly

holding eyelids apart to ensure complete irrigation of eye and lid tissue. GET MEDICAL
ATTENTION.

Inhalation: Remove to fresh air. If breathing is difficult administer oxygen. If respiration stops, give

mouth-to-mouth resuscitation. GET MEDICALATTENTION.

NOTE TO PHYSICIAN: This material is an article and has no significant toxic hazard. Hazardous fumes (CO, CO

2

) are
produced by combustion and may be produced by decomposition at elevated temperatures above
450°F.

Ef

fects of Overexposure:

Acute: This material is an article and has no significant hazard. This article decomposes at high

temperatures, and can produce irritating toxic fumes.

Chronic: No significant hazard.
Route: Fumes from high temperature decomposition are toxic when inhaled and irritating to skin and

mucous membranes.

Toxicity: This material is and article and has no significant toxic hazard.

Sec

tion III. Fire and Explosion Hazard Data

Flash Point: About 500°F. Method: ASTM-D-1929
Flammable Limits(In Air % by Vol.): N/A
Auto Ignition Temperature: About 700°F.
Extinguishing Media: Carbon dioxide, dry chemical, water.
Special Fire Fighting Procedure &
Personal Protection: In case of fire, use water or other extinguishing medium appropiate for surrounding fires. Use

self-contained breathing apparatus and full protective equipment. All fires liberate toxic gases.

Unusual Fire & Explosion Hazards: None

Section IV. Ventilation

Respirator (Type): None
Gloves (Type): None
Eye Protection (Type): None
Other Protective Equipment: None

Local exhaust in the vicinity of hot processing

Section V. Physical Data

Boiling Point (760mm Hg): N/A
Specific Gravity (H

2

O = 1): 1.05 - 1.50
Vapor Pressure (mm Hg 20°C): N/A
pH: N/A
Vapor Density (Air = 1): N/A
Percent Volatile: Nonvolatile
Solubilty in Water (% by Wt.): Negligible
Evaporation Rate (Butyl Acetate = 1): Less than 1
Apperance and Color; Smooth rubber finish, Black

© 2008 DESCO INDUSTRIES INC.

Employee Owned

DESCO INDUSTRIES INC. • 3651 Walnut Avenue, Chino, CA 91710 • [phone] • Fax [phone] • Web Site: http://www.descoindustries.com

DESCO INDUSTRIES INC. Technical Bulletin TB-7017

Section VI. Hazardous Ingredients

Ingredients Presenting a Significant
Hazard: This material is an “article” under the definitions of the OSHA Hazard Communication Standard (29

CFR 1910.1200). As such, it does not release, or otherwise produce by exposure, a hazradous
chemical under normal conditions of use.

Threshold Limit Value %: Not applicable

Section VII. Hazardous Reactivity

Incompatiblity: Nonreactive.
Hazardous Decomposition Products: CO, CO

2

- This article can be forced to burn by continuous application of intense heat. The primary

combustion products will be CO and CO

2

. Other gases will include small amounts of aromatic and
aliphatic hydrocarbons, and oxides of nitrogen and sulfer. The major hazard is the asphyxiant carbon
monoxide.

Conditions to Avoid: Keep away from heat for prolonged periods.

Section VIII. Handling and Storage

Handling and Storage Precautions: Use applicable fire and safety code precautions for warehousing.

Section IX. Environmental Protection

Procedure in Case of Spill or Release: N/A
Waste Disposal Method: Submit for disposal in accordance with local, state, and federal regulations.

Section X. Regulatory Status

Not classified as a hazardous waste under RCRA

Section XI. Additional Information

Always wear rubber gloves when cleaning exhuast equipment or other surfaces. If using cleaning solvents, follow their specific MSDS
recommendations for use

Disclaimer
The information given in this publication has been worked up to the best of the knowledge of Desco Industries Inc, as well as taking into consideration the
applicable laws and regulations. We cannot anticipate all conditions under which this information and our products or the products of the manufacturers in
combination with our products may be used. We accept no responsibility for the results obtained by the application information or the safety and suitability of
our product or product combination with other products. Users are advised to make their own tests to determine the safety and suitability of each such product
or product combination for their own purposes. Unless otherwise agreed in writing, we sell the products without warranty, and buyers end users assume
responsibility and liability for loss or damage arising from the handling and use of our products, whether used alone or in combination with other products.

N/A = Not Applicable; NE = None Established

TB-7017 Page 2 of 2

© 2008 DESCO INDUSTRIES INC.

Employee Owned