Page 1
KN09105 – 2005-UP Nissan Xterra/Frontier 2" Lift
www.DaystarWeb.com
Tech Support: Tech@DaystarWeb.com
Phone: 623.907.0081 / Fax: 623.907.0088
841 South 71
st
Avenue; Phoenix, AZ 85043
Tools required
Description:
Standard sockets, hand tools Etc.
Hydraulic Lift is Recommended
Floor Jacks / Jack Stands
Ball joint separator
Shown above: S Model with KN09105 2” lift and 32X10.50X16 BFG AT’s
INSTALLATION INSTRUCTIONS
1. Read instructions completely, verify bill of materials
and determine if you have the correct tools before
beginning installation.
Front Installation
Part # Description Qty
S11014 SHACKLES (REAR) 2
M03678 SPRING BUSHING 4
M03679 SPRING BUSHING 4
S11010 STEEL TUBING 0.584X0.750X3.950 2
S11011 STEEL TUBING 0.584X0.750X2.865 2
S10205 9/16-12 NYLOCK NUTS 4
S10199 9/16-12 X 4-1/2" GR5 GREASABLE BOLT 2
S10388 9/16-12 X 5-1/2" GR5 GREASABLE BOLT 2
S11015 9/16 SAE NARROW WASHER 8
S11013 STRUT SPACER (FRONT) 2
S10203 7/16-14 NYLOCK NUTS (FRONT) 6
S11016 7/16 SAE NARROW WASHER (FRONT) 6
Bill of Materials
2. Raise vehicle until front tires are clear, support the vehicle.
3. Remove the front tire and wheel assembly.
4. Remove the lower stabilizer link bolt and move sway-bar assembly out of way.
5. Remove the upper ball joint nut.
6. Separate the upper ball joint from the spindle.
7. Remove the strut assembly and install the strut spacer see Fig. 1.
8. Rotate the strut (with spacer installed) 180 º.
9. Reassemble spindle and ball joint
Rear Installation
10. Remove spare tire.
11. Raise vehicle until rear tires are clear, support the vehicle.
12. Remove rear sway-bar bolt and swing the bar and linkage out of the way. Remove the shocks.
13. Support the rear axle and remove the OE shackles and OE spring bushings.
14. Install new Daystar Greaseable shackles. See Fig 2.
15. Reconnect the swaybar and install optional new shocks (22in. extend length, 13.5 compressed
Eylet/Eyelet)
16. Torque all bolts to factory specs and check after 50 miles.
17. After installation of kit; alignment should be checked and adjusted if necessary.
Instruction Sheet - P11074-01.doc
Page 1 of 2
© 20066 Daystar Products International Inc.
Page 2
KN09105 – 2005-UP Nissan Xterra/Frontier 2" Lift
Fig 1. OE STRUT WITH SPACER ON TOP
Tech Support: Tech@DaystarWeb.com
Phone: 623.907.0081 / Fax: 623.907.0088
841 South 71
Fig 2. Daystar Greaseable shackles
st
Avenue; Phoenix, AZ 85043
www.DaystarWeb.com
WARNING
This vehicle has been modified to enhance its performance.
The steering, braking and handling of this vehicle will differ
from standard passenger cars and trucks. This vehicle
handles differently from an ordinary vehicle in driving
conditions which may occur on streets, highways and off road.
Avoid unnecessary abrupt maneuvers, sudden stops, sharp
turns and other driving conditions that could cause loss of
control, possibly leading to a roll over or other accident that
could result in serious injury or death to driver and passengers.
If larger tires are installed the speedometer will read lower
than the vehicles actual speed.
DRIVE WITH CARE, REDUCE SPEED
AND WEAR SEAT BELTS AT ALL TIMES.
This kit should be installed by a professional mechanic.
Instruction Sheet - P11074-01.doc
Page 2 of 2
© 20066 Daystar Products International Inc.
Loading...