Datasheet TC4427AEOA, TC4427ACPA, TC4427ACOA, TC4426ACPA, TC4426ACOA Datasheet (Microchip Technology)

...
M
A
1.5A Dual High-Speed Power MOSFET Drivers
TC4426A/TC4427A/TC4428A
Features
• High Peak Output Current – 1.5A
• Wide Operating Range
- 4.5V to 18V
• High Capacitive Load Drive Capability – 1000pF in 25nsec Typ.
• Short Delay Times – 30nsec Typ.
• Matched Rise, Fall and Delay Times
• Low Supply Current:
- With Logic "1" Input – 1mA
- With Logic "0" Input – 100µA
• Low Output Impedance – 7
• Latch-Up Protected: Wi ll Withstand 0.5A Revers e Current
• Input Will Withstand Negative Inputs Up to 5V
• ESD Protected – 4kV
• Pinouts Sa me as TC426/TC427/TC428
Applications
Device Selection Table
Part Number Package Temp. Range
TC4426ACOA 8-Pin SOIC 0°C to +70°C TC4426ACPA 8- Pi n PDI P 0°C to +70°C TC4426AEOA 8-Pin SOIC -40°C to +85°C
TC4426AEPA 8-Pin PDIP -40°C to +85°C
TC4426AMJA 8-Pin CERDIP -55°C to +125°C TC4427ACOA 8-Pin SOIC 0°C to +70°C TC4427ACPA 8- Pi n PDI P 0°C to +70°C TC4427AEOA 8-Pin SOIC -40°C to +85°C
TC4427AEPA 8-Pin PDIP -40°C to +85°C
TC4427AMJA 8-Pin CERDIP -55°C to +125°C TC4428ACOA 8-Pin SOIC 0°C to +70°C TC4428ACPA 8- Pi n PDI P 0°C to +70°C TC4428AEOA 8-Pin SOIC -40°C to +85°C
TC4428AEPA 8-Pin PDIP -40°C to +85°C
TC4428AMJA 8-Pin CERDIP -55°C to +125°C
Package Type
8-Pin PDIP/SOIC/CERDIP
1
NC
2
IN A
TC4426A
3
GND
4
IN B
2,4 7,5
Inverting
NC
1
2
IN A
TC4427A
3
GND
4
IN B
2,4 7,5
Noninverting
NC = No internal connection. NOTE: SOIC pinout is identical to DIP.
8
7
6
5
8
7
6
5
NC
OUT A
V
DD
OUT B
NC
OUT A
V
DD
OUT B
NC
IN A
GND
IN B
1
2
TC4428A
3
4
2
4
Differential
NC
8
OUT
7
V
6
DD
5
OUT B
7
5
General Description
The TC4426A/TC4427A/TC4428A are improved versions of the earlier TC426/TC427/TC428 family of buffer/drivers (with which they are pin compatible). They will not latch up under any conditions within their power and voltage ratings. They are not subject to damage when up to 5V of noise spiking (of either polarity) occurs on the gro und pin. They c an accept, without damage or logic upset, up to 500m A of revers e current (of either polarity) being forced back into their outputs. All terminals are fully protected against up to 4kV of electrostatic discharge.
As MOSFET drivers, the TC4426A/TC4427A/ TC4428A can easily switch 1000pF gate capacitances in under 30nsec, and provide low enough impedances in both the ON and OFF states to ensure the MOSFET's intended state will not be affected, even by large transients.
2002 Microchip Technology Inc. DS21423B-page 1
TC4426A/TC4427A/TC4428A
Functional Block Diagram
Inverting
Outputs
2mA
300mV
Noninverting
Outputs
Input
4.7V
TC4426A/TC4427A/TC4428A
GND
Effective Input
C = 12pF
V
DD
Output
NOTES: 1. TC4426A has 2 inverting drivers; TC4427A has 2 noninverting drivers.
2. TC4428A has one inverting and one noninverting driver.
3. Ground any unused driver input.
DS21423B-page 2 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
1.0 ELECTRICAL CHARACTERISTICS
Absolute Maximum Ratings*
Supply Voltage.....................................................+22V
*Stresses above those listed under "Absolute Maximum Ratings" may cause permanent damage to the device. These are stress ratings only and functional operation of the device at these or any other conditions above those indicated in the operation sections of the specifications is not implied. Exposure to Absolute Maximum Rating conditions for extended periods may affect device reliability.
Input Voltage, IN A or IN B
..................................(V
Package Power Dissipation (T
+ 0.3V) to (GND – 5V)
DD
70°C)
A
PDIP........................................................ 730mW
CERDIP................................................... 800mW
SOIC........................................................ 470mW
Package Thermal Resistance CERDIP R CERDIP R PDIP R PDIP R SOIC R SOIC R
........................................ 150°C/W
θJ-A
......................................... 50°C/W
θJ-C
............................................. 125°C/W
θJ-A
............................................... 42°C/W
θJ-C
............................................ 155°C/W
θJ-A
.............................................. 45°C/W
θJ-C
Operating Temperature Range
C Version.........................................0°C to +70°C
E Version..................................... -40°C to +85°C
M Version................................... -55°C to +125°C
Storage Temperature Range ............. -65°C to +150°C
TC4426A/TC4427A/TC4428A ELECTRICAL SPECIFICATIONS
Electrical Characteristics: Over operating temperature range with 4.5V V
Symbol Parameter Min Typ Max Units Test Conditions
Input
V
IH
V
IL
I
IN
Output
V
OH
V
OL
R
O
I
PK
I
REV
Note 1: Switching times ensured by design.
Logic 1, High Input Voltage 2.4 ——V Logic 0, Low Input Voltage ——0.8 V Input Current -1
High Output Voltage VDD – 0.025 ——VDC Test Low Output Voltage ——0.025 V DC Test Output Resistance
Peak Output Current 1.5 AVDD = 18V Latch-Up Protection
Withstand Reverse Current
-10
— —
0.5 ——A Duty cycle2%, t 300µsec
— —
7 7 8
18V, unless otherwise noted.
DD
1
10
9 10 11
µA0VVIN ≤ V
I
= 10mA, VDD = 18V, TA = +25°C
OUT
TA ≤ +70°C
0°C
-40°C
= 18V
V
DD
DD
TA ≤ +85°C
2002 Microchip Technology Inc. DS21423B-page 3
TC4426A/TC4427A/TC4428A
Symbol Parameter Min Typ Max Units Test Conditions
Switching Time (Note 1)
t
R
t
F
t
D1
t
D2
Power Supply
I
S
Note 1: Switching times ensured by design.
Rise Time
Fall Time
Delay Time
Delay Time
Power Supply Current
— —
27 29
25
25
— —
27 29
30
— —
33 35
30
— —
33 35
1.0
0.1
35 40 40
35 40 40
35 40 45
35 40 45
2.0
0.2
nsec T
nsec T
nsec T
nsec TA = +25°C
mA VIN = 3V (Both inputs)
= +25°C
A
TA ≤ +70°C
0°C
TA ≤ +85°C, Figure 3- 1
-40°C = +25°C
A
TA ≤ +70°C
0°C
TA ≤ +85°C, Figure 3- 1
-40°C = +25°C
A
TA ≤ +70°C
0°C
TA ≤ +85°C, Figure 3- 1
-40°C
TA ≤ +70°C
0°C
TA ≤ +85°C, Figure 3- 1
-40°C
= 0V (Both inputs), VDD = 18V
V
IN
DS21423B-page 4 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
2.0 PIN DESCRIPTIONS
The descriptions of the pins are listed in Table 2-1.
TABLE 2-1: PIN FUNCTION TABLE
Pin No.
(8-Pin PDIP,
SOIC, CERDIP)
1 NC No connect. 2IN A 3 GND Ground. 4IN B 5OUT B 6V 7OUT A 8 NC No connect.
Symbol Description
DD
2002 Microchip Technology Inc. DS21423B-page 5
TC4426A/TC4427A/TC4428A
3.0 APPLICATIONS INFORMATION
FIGURE 3-1: SWITCHING TIME TEST CIRCUIT
Input
2
4
Input: 100kHz,
square wave,
= t
t
RISE
V
DD
FALL
= 18V
6
3
10nsec
4.7µF
7
5
0.1µF
Output
CL = 1000pF
Input
V
Output
+5V
Input
0V
V
DD
Output
0V
+5V
0V
DD
0V
10%
10%
t
D1
90%
t
D1
t
F
10%
Inverting Driver
90%
t
R
10%
Noninverting Driver
t
D2
90%
90%
t
D2
90%
10%
t
R
10%
90%
t
F
DS21423B-page 6 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
510.0
515.0
ge
T
5
)
C
pF
C
pF
pF
C
C
pF
00-50
0
t
t
SE
5.0
5
0
515.0
0
0
ge
5
)
C
pF
C
C
pF
5101520
t
50050100150
e
C
pF
8V
)
t
t
4.0 TYPICAL CHARACTERISTICS
Note: The graphs and tables provided following this note are a statistical summary based on a limited number of
samples and are pro vided for information al purposes only. The performance characteris tics listed herei n are not tested or guaranteed. In some graphs or tables, the data presented may be outside the specified operating range (e.g., outside specified power supply range) and therefore outside the warranted range.
Rise Time vs. Supply Volta
100
80
60
(nsec)
40
RISE
t
20
0
CL = 100
5.0
= 2200
7.
= 1500
12.
(V
= +2
= 470
Effect of Input Amplitude on Delay
110
100
90
80
70
60 50 40
Delay Time (nsec)
30 20
t
D1
t
D2
12 3 4 5 67 8 9
V
(V)
DD
CL = 1000pF
V
= 10V
DD
Fall Time vs. Supply Volta
°
C
17.5
100
80
60
(nsec)
40
FALL
t
2
= 1500
7.
10.
12.
(V
= 470
= +2
°C
17.5
Propagation Delay Time vs. Supply Voltage
60
55
50
45
40
35
30
Delay Time (nsec)
25
20
0
t
D1
V
(V)
DD
CL = 1000pF
Rise and Fall Times vs. Temperature
28
CL = 1000pF
26
V
DD
24
22
20
Time (nsec)
18
16
14
-1
= 18V
RI
50 100 150
TEMPERATURE (°C)
Propagation Delay Time vs. Temperatur
40
= 1000
35
30
25
Delay Time (nsec)
20
15
= 1
-100 -
TEMPERATURE (C
2002 Microchip Technology Inc. DS21423B-page 7
TC4426A/TC4427A/TC4428A
5
C
5
C
0
500100015002000
0
0
0
30
)
y
(
)
8V
C
pF
C
pF
C
pF
C
pF
)
0
500
000
5002000
30
0
0
0
y
C
pF
C
pF
C
pF
C
pF
5
0
520
5
C
5
C
0
5001000150020002500
0
0
0
30
0
50
60
d
8V
C
)
900MHz
600MHz
z
z
0
500
000
50020002500
60
50
0
30
0
0
0
C
)
900MHz
600MHz
z
z
TYPICAL CHARACTERISTICS (CONTINUED)
High-State Output Resistance
30
= 12
T
A
25
20
= 12
T
A
()
15
DS(ON)
10
R
5
0
0 5 10 15 20
V
(V)
DD
Supply Current vs. Frequenc
60
50
40
mA
PPLY
2
I
1
= 2200
FREQUENCY (KHz
= 1500
= 1000
= 1
= 100
2500
Low State Output Resistance
30
25
= 12
T
A
20
()
15
= 12
T
A
DS(ON)
10
R
5
0
0
1
V
(V)
DD
Supply Current vs. Capacitance Loa
4
(mA)
2
SUPPLY
I
1
(pF
1
= 1
200MH
20MH
80
70
60
50
(mA)
40
PPLY
I
2
1
Supply Current vs. Frequenc
V
= 12V
DD
1
FREQUENCY (KHz
1
= 2200
= 1500
= 1000
= 100
2500
Supply Current vs.Capacitance Load
80
V
= 12V
DD
70
(mA)
4
SUPPLY
I
2
1
1
1
(pF
200MH
20MH
DS21423B-page 8 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
0
500
000
1500
2000
5
0
5
0
(
)
C
pF
C
pF
C
pF
C
pF
5
C
BOTH INPUTS = 1
0
5
01520
800
00
600
500
00
00
00
0
300
900
ge
0
0
500
000
50020002500
30
5
5
0
5
0
C
L
)
900MHz
600MHz
z
20MHz
00-50050100150
000
900
800
00
600
00
300
00
00
0
500
00
e
V
8V
0
0
TYPICAL CHARACTERISTICS (CONTINUED)
40
V
35
30
25
(mA)
20
PPLY
1
I
1
7
(mA)
4
QUIESCENT
I
2
BOTH INPUTS =
1
Supply Current vs. Frequency
= 6V
DD
1
FREQUENCY
KHz
Quiescent Supply Current vs. Volta
1
V
(V)
DD
= 2200
= 1500
= 1000
= 100
= 2
2500
Supply Current vs. Capacitance Load
40
V
= 6V
DD
35
2
(mA)
1
SUPPLY
I
1
1
1
(pF
Quiescent Supply Current vs. Temperatur
11 1
BOTH INPUTS =
7
(mA)
4
QUIESCENT
I
BOTH INPUTS =
2 1
-1
TEMPERATURE (°C)
200MH
= 1
2002 Microchip Technology Inc. DS21423B-page 9
TC4426A/TC4427A/TC4428A
3
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
.
)
)
)
)
)
)
)
.
.
)
)
)
)
)
)
)
)
)
)
)
)
)
3
)
)
)
)
)
5.0 PACKAGING INFORMATION
Package mar k ing data not available at this time.
5.1 Package Dimensions
8-Pin Plastic DIP
.260 (6.60 .240 (6.10
.045 (1.14 .030 (0.76
.200 (5.08 .140 (3.56
.150 (3.81 .115 (2.92
8-Pin CDIP (Narrow
.400 (10.16
.348 (8.84
.110 (2.79 .090 (2.29
.022 (0.56 .015 (0.38
.110 (2.79 .090 (2.29
.070 (1.78 .040 (1.02
.040 (1.02 .020 (0.51
.300 (7.62 .230 (5.84
.310 (7.87 .290 (7.37
.015 (0.38 .008 (0.20
.400 (10.16
310 (7.87
Dimensions: inches (mm)
.055 (1.40) MAX
.200 (5.08 .160 (4.06
.200 (5.08 .125 (3.18
.400 (10.16
.370 (9.40
.065 (1.65 .045 (1.14
.020 (0.51 .016 (0.41
.020 (0.51) MIN
.040 (1.02 .020 (0.51
.150 (3.81
.015 (0.38 .008 (0.20
.320 (8.13 .290 (7.37
.400 (10.16
.320 (8.13
Dimensions: inches (mm)
DS21423B-page 10 2002 Microchip Technology Inc.
Package Dimensions (Continued)
.
8
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
)
8-Pin SOIC
TC4426A/TC4427A/TC4428A
.050 (1.27) TYP
.197 (5.00 .189 (4.80
.020 (0.51 .013 (0.33
.157 (3.99 .150 (3.81
.010 (0.25 .004 (0.10
.244 (6.20 .228 (5.79
.069 (1.75 .053 (1.35
.010 (0.25 .007 (0.18
.050 (1.27 .016 (0.40
Dimensions: inches (mm)
2002 Microchip Technology Inc. DS21423B-page 11
TC4426A/TC4427A/TC4428A
NOTES:
DS21423B-page 12 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
Sales and Support
Data Sheets
Products supported by a preliminary Data Sheet may have an errata sheet describing minor operational differences and recom­mended workarounds. To determine if an errata sheet exists for a particular device, please contact one of the following:
1. Your local Microchip sales office
2. The Microchip Corporate Literature Center U.S. FAX: (480) 792-7277
3. The Microchip Worldwide Site (www.microchip.com) Please specify which device, revision of silicon and Data Sheet (include Literature #) you are using.
New Customer Notification System
Register on our web site (www.microchip.com/cn) to receive the most current information on our products.
2002 Microchip Technology Inc. DS21423B-page13
TC4426A/TC4427A/TC4428A
NOTES:
DS21423B-page14 2002 Microchip Technology Inc.
TC4426A/TC4427A/TC4428A
Information contained in this publication regarding device applications and the like is intended through suggestion only and may be superseded by updates. It is your responsibility to ensure that your application meets with your specifications. No representation or warranty is given and no liability is assumed by Microchip Technology Incorporated with respect to the accuracy or use of such information, or infringement of patents or other intellectual property rights arising from such use or otherwise. Use of Microchips products as critical com­ponents in life support systems is not authorized except with express written approval by Microchip. No licenses are con­veyed, implicitly or otherwise, under any intellectual property rights.
Trademarks
The Microchip name and logo, the Microchip logo, FilterLab,
EELOQ, microID, MPLAB, PIC, PICmicro, PICMASTER,
K PICSTART, PRO MATE, SEEVAL and The Embedde d Control Solutions Company are registered trademarks of Microchip Tech­nology Incorporated in the U.S.A. and other countries.
dsPIC, ECONOMONITOR, FanSense, FlexROM, fuzzyLAB, In-Circuit Serial Programming, ICSP, ICEPIC, microPort, Migratable Memory, MPASM, MPLIB, MPLINK, MPSIM, MXDEV, PICC, PICDEM, PICDEM.net, rfPIC, Select Mode and T otal Endurance are trademarks of Microchip Technology Incorporated in the U.S.A.
Serialized Quick Turn Programming (SQTP) is a service mark of Microchip Technology Incorporated in the U.S.A.
All other trademarks mentioned herein are property of their respective companies.
© 2002, Microchip Technology Incorporated, Printed in the U.S.A., All Rights Reserved.
Printed on recycled paper.
Microchip received QS-9000 quality system certification for its worldwide headquarters, design and wafer fabrication facilities in Chandler and Tempe, Arizona in July 1999 and Mountain View, California in March 2002. The Company’s quality system processes and procedures are QS-9000 compliant for its PICmicro
devices, Serial EEPROMs, micrope ri ph era ls, non-volatile memory and ana l og pro duc ts. In addition, Microchips quality system for the design and manufacture of development systems is ISO 9001 certified.
®
8-bit MCUs, KEELOQ
®
code hoppin g
2002 Microchip Technology Inc. DS21423B-page 15
M
WORLDWIDE SALES AND SERVICE
AMERICAS
Corporate Office
2355 West Chandler Blvd. Chandler, AZ 85224-6199 Tel: 480-792-7200 Fax: 480-792-7277 Technical Support: 480-792-7627 Web Address: http://www.microchip.com
Rocky Mountain
2355 West Chandler Blvd. Chandler, AZ 85224-6199 Tel: 480-792-7966 Fax: 480-792-7456
Atlanta
500 Sugar Mill Road, Suite 200B Atlanta, GA 30350 Tel: 770-640-0034 Fax: 770- 640 -03 07
Boston
2 Lan Drive, Suite 120 Westford, MA 01886 Tel: 978-692-3848 Fax: 978- 692 -38 21
Chicago
333 Pierce Road, Suite 180 Itasca, IL 60143 Tel: 630-285-0071 Fax: 630-285-0075
Dallas
4570 Westgrove Drive, Suite 160 Addison, TX 75001 Tel: 972-818-7423 Fax: 972- 818 -29 24
Detroit
Tri-Atria Office Building 32255 Northwestern Highway, Suite 190 Farmington Hills, MI 48334 Tel: 248-538-2250 Fax: 248-538-2260
Kokomo
2767 S. Albright Road Kokomo, Indiana 46902 Tel: 765-864-8360 Fax: 765-864-8387
Los Angeles
18201 Von Karman, Suite 1090 Irvine, CA 92612 Tel: 949-263-1888 Fax: 949- 263 -13 38
New York
150 Motor Parkway, Suite 202 Hauppauge, NY 11788 Tel: 631-273-5305 Fax: 631- 273 -53 35
San Jose
Microchip Technology Inc. 2107 North First Street, Suite 590 San Jose, CA 95131 Tel: 408-436-7950 Fax: 408- 436 -79 55
Toronto
6285 Northam Drive, Suite 108 Mississauga, Ontario L4V 1X5, Cana da Tel: 905-673-0699 Fax: 905-673-6509
ASIA/PACIFIC
Australia
Microchip Technology Australia Pty Ltd Suite 22, 41 Rawson Street Epping 2121, NSW Australia Tel: 61-2-9868-6733 Fax: 61-2-9868-6755
China - Beij ing
Microchip Technology Consulting (Shanghai) Co., Ltd., Beijing Liaison Office Unit 915 Bei Hai Wan Tai Bldg. No. 6 Chaoyangmen Beidajie Beijing, 100027, No. China Tel: 86-10-85282100 Fax: 86-10-85282104
China - Chengdu
Microchip Technology Consulting (Shanghai) Co., Ltd., Chengdu Liaison Office Rm. 2401, 24th Floor, Ming Xing Financial Tower No. 88 TIDU Street Chengdu 610016, China Tel: 86-28-6766200 Fax: 86-28-6766599
China - Fuzhou
Microchip Technology Consulting (Shanghai) Co., Ltd., Fuzhou Liaison Of fice Unit 28F, World Trade Plaza No. 71 Wusi Road Fuzhou 350001, China Tel: 86-591-7503506 Fax: 86-591-7503521
China - Shanghai
Microchip Technology Consulting (Shanghai) Co., Ltd. Room 701, Bldg. B Far East International Plaza No. 317 Xian Xia Road Shanghai, 200051 Tel: 86-21-6275-5700 Fax: 86-21-6275-5060
China - Shenzhen
Microchip Technology Consulting (Shanghai) Co., Ltd., Shenzhen Liaison Office Rm. 1315, 13/F, Shenzhen Kerry Centre, Renminnan Lu Shenzhen 518001, China Tel: 86-755-2350361 Fax: 86-755-2366086
Hong Kong
Microchip Technology Hongkong Ltd. Unit 901-6, Tower 2, Metroplaza 223 Hing Fong Road Kwai Fong, N.T., Hong Kong Tel: 852-2401-1200 Fax: 852-2401-3431
India
Microchip Technology Inc. India Liaison Office Divyasree Chambers 1 Floor, Wing A (A3/A4) No. 11, OShaugnessey Road Bangalore, 560 025, India Tel: 91-80-2290061 Fax: 91-80-2290062
Japan
Microchip Technology Japan K.K. Benex S-1 6F 3-18-20, Shinyokohama Kohoku-Ku, Yokohama-shi Kanagawa, 222-0033, Japan Tel: 81-45-471- 6166 Fax: 81-45-471-6122
Korea
Microchip Technology Korea 168-1, Youngbo Bldg. 3 Floor Samsung-Dong, Kangnam-Ku Seoul, Korea 135-882 Tel: 82-2-554-7200 Fax: 82-2-558-5934
Singapore
Microchip Technology Singapore Pte Ltd. 200 Middle Road #07-02 Prime Centre Singapore, 188980 Tel: 65-6334-8870 Fax: 65-6334-8850
Taiwan
Microchip Technology Taiw an 11F-3 , No. 20 7 Tung Hua North Road Taipei, 105, Taiwan Tel: 886-2-2717-7175 Fax: 886-2-2545-0139
EUROPE
Denmark
Microchip Technology Nordic ApS Regus Business Centre Lautrup hoj 1-3 Ballerup DK-2750 Denmark Tel: 45 4420 9895 Fax: 45 4420 9910
France
Microchip Technology SARL Parc dActivite du Moulin de Massy 43 Rue du Saule Trapu Batiment A - ler Etage 91300 Massy, France Tel: 33-1-69-53-63-20 Fax: 33-1-69-30-90-79
Germany
Microchip Technology GmbH Gustav-Heinemann Ring 125 D-81739 Munich, Germany Tel: 49-89-627-144 0 Fax: 49-89-627-144-44
Italy
Microchip Technology SRL Centro Direzionale Colleoni Palazzo Taurus 1 V. Le Colleoni 1 20041 Agrate Brianza Milan, Italy Tel: 39-039-65791-1 Fax: 39-039-6899883
United Kingdom
Arizona Microchip Technology Ltd. 505 Eskdale Road Winnersh Triangle Wokingham Berkshire, England RG41 5TU Tel: 44 118 921 5869 Fax: 44-118 921-5820
03/01/02
'! '
DS21423B-page 16 2002 Microchip Technology Inc.
Loading...