Datasheet TBEN-S2-8DXP Datasheet (Turck)

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

■ Pin1 switchable per I/O port

■ Diagnosis of supply to each I/O port

■ Two freely selectable digital channels

per port

■ Max. 0.5A per output

■ Output diagnostics per channel

■ FLC/ARGEE programmable

■ PROFINET® device, EtherNet/IP™ de-

vice or Modbus® TCP slave

■ Integrated Ethernet switch

■ Supports 10 Mbps/100 Mbps

■ 2x M8, 4-pin, Ethernet fieldbus connec-

tion

Type designation TBEN-S2-8DXP

Ident-No. 6814076

Supply

Supply voltage 24 VDC
Admissible range 18…30 VDC

Total current max. 4 A per voltage group
Total current V1 + V2 max. 5.5 A at 70 °C per mod-

ule
Voltage supply connection 2 × M8, 4-pin
Operating current V1: max. 150 mA mA
Sensor/Actuator supply V

Sensor/Actuator supply V

Electrical isolation galvanic isolation of the voltage groups V1 and V2,

AUX1

AUX2

Ports C0-C1 powered by V1

Pin1 supply switchable for each port

Short-circuit proof, 0.5 A per port

Ports C2-C3 powered by V2

Pin1 supply switchable for each port

Short-circuit proof, 0.5 A per port

voltages up to 500 VAC

■ Male M8, 4-pin, for power supply

■ Separated power groups for safety

shutdown

■ Glass-fiber reinforced housing

■ Shock and vibration tested

■ Fully potted module electronics

■ Protection classes IP65 / IP67 / IP69K

System data

Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 × M8, 4-pin
Protocol detection automatic
Web server default: 192.168.1.254
Service interface Ethernet via P1 or P2

Field Logic Controller (FLC)

Supported from firmware version 3.0.1.0
Released from ARGEE version 2.0.25.0

Modbus TCP

Addressing Static IP, DHCP
Supported function codes FC1, FC2, FC3, FC4, FC5, FC6, FC15, FC16, FC23
Number of TCP connections 8
Input register start address 0 (0x0000 hex)
Output register start address 2048 (0x0800 hex)

EtherNet/IP™

Addressing acc. to EtherNet/IP™ specification
Quick Connect (QC) < 500 ms
Device Level Ring (DLR) supported
Class 3 connections 3
Class 1 connections 10
Input Assembly Instance 103
Output Assembly Instance 104
Configuration Assembly Instance 106

Edition • 2019-01-21T19:24:07+01:00

1 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

PROFINET

Addressing DCP
Conformance class B (RT)
MinCycleTime 1 ms
Fast Start-Up (FSU) < 500 ms
Diagnostics acc. to PROFINET alarm handling
Topology detection supported
Automatic addressing supported
Media Redundancy Protocol (MRP) supported

Digital inputs

Number of channels 8
Connectivity inputs M12, 5-pin
Input type PNP
Type of input diagnostics Channel diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 0.2 ms / 3 ms
Electrical isolation galvanic isolation to P1/P2

, voltages up to 500 VDC

Digital outputs

Number of channels 8
Connectivity outputs M12, 5-pol
Output type PNP
Type of output diagnostics Channel diagnostics
Output voltage 24 VDC from potential group
Output current per channel 0.5 A, short-circuit proof
Load type EN 60947-5-1: DC-13
Short-circuit protection yes
Electrical isolation galvanic isolation to P1/P2

, voltages up to 500 VDC

Standard/Directive conformity

Vibration test acceleration to 20 g

acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE, FCC
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.

General Information

Dimensions (W x L x H) 32 x 144 x 32mm
Operating temperature -40…+70 °C
Storage temperature -40…+85 °C
Altitude max. 5000 m
Protection class IP65

IP67

IP69K
MTTF 238 years acc. to SN 29500 (Ed. 99) 20 °C
Housing material PA6-GF30
Housing color Black
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes Ø 4.6 mm

Edition • 2019-01-21T19:24:07+01:00

2 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

Accessories

It is strongly recommended to use only ready-made Ethernet ca-

bles!

Ethernet cable (example):

M8-M8:

PSGS4M-PSGS4M-4413-1M

Ident. no. U-55718

M8-RJ45:

PSGS4M-RJ45S-4413-1M

Ident. no.: U-55725

M8-M12:

RSSD-PSGS4M-4413-1M

Ident. no.: U-58840

Accessories

V

(Pin1) supply switchable for each port

AUX

Actuator and sensor cable/PUR connection cable (example):

RKC4.4T-2-RSC4.4T/TXL

ID number 6625608

Connection cable with Y piece for single assignment

FSM4-2WAK3-1/1/P00

ID number 8009560

M8 x 1 Ethernet

M12 x 1 Input

Accessories

Power supply cable (example):

M8-M8 2 m

PKG 4M-2-PSG 4M

Ident. no. U99-10815

M8 x 1 Voltage Supply

Edition • 2019-01-21T19:24:07+01:00

3 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

Module LED Status

LED Color Status Description

ETH1 / ETH2 Green ON Ethernet link (100 Mbps)

flashing Ethernet communication (100 Mbps)

Yellow ON Ethernet link (10 Mbps)

flashing Ethernet communication (10 Mbps)

OFF No Ethernet link

BUS Green ON Active connection to a master

Flashing Steady flashing: Ready

Sequence of 3 flashes in 2 seconds: FLC/ARGEE active

Red ON IP address conflict or Restore Mode or Modbus timeout

Flashing Blink/Wink command active

Red/

Green

ERR Green ON Diagnostics disabled

Red ON Diagnostics enabled

PWR Green ON V1 and V2 power on

Red ON V2 power off or below defined tolerance of 18 V

LED Status I/O

LED Color Status Description

LED 0 … 7 Green ON Input or output active

LED 7 White Flashing Blink/Wink command active

Alternating Waiting for assignment of an IP address, DHCP or BootP

OFF Power off

V2 undervoltage diagnosis is parameter-dependent

OFF V1 power off or below defined tolerance of 18 V

ON Output active with overload/short circuitRed

Flashing Power overload at the corresponding port. Both port LEDs are flashing.

OFF Input or output inactive

Edition • 2019-01-21T19:24:07+01:00

4 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

Process Data Mapping of the Single Protocols

For more details on the corresponding protocols see manual.

Modbus TCP

Register Addressing (16-bit)

Offset Process Input Data: 0x0000, structure acc. to general register mapping

Offset Process Output Data: 0x0800: Structure acc. to general register mapping

EtherNet/IP

Word addressing (16-bit)

Process input data (station -> scanner):

Status word is located in front of the general process data!

GW status 0x0000 - FCE - - CFG COM V1 - V2 - - - - - - Diag

Process output data (scanner -> station):

Control word is located in front of the general process data!

Control 0x0000 reserved

PROFINET:

Byte addressing (8-bit)

Offset Process Input Data: 0x0000, structure acc. to general register mapping

Offset Process Output Data: 0x0000: Structure acc. to general register mapping

General register mapping:

Address details are relative, offset of the respective protocol is to be observed.

Channel assignment/port/pin:

Port

Pin

Process input data:

Digital inputs 0x0000 0x0000 - - - - - - - - DX7 DX6 DX5 DX4 DX3 DX2 DX1 DX0

Diagnostics 0x0001 0x0002 ERR7 ERR6 ERR5 ERR4 ERR3 ERR2 ERR1 ERR0 - - - - VERR

Latch input 0x0002 0x0004 - - - - - - - - DX7 DX6 DX5 DX4 DX3 DX2 DX1 DX0

Counter Ch0 0x0003 0x0006 Counter value LSB

Frequency Ch0 0x0005 0x000A Frequency MSB Frequency LSB

Status 0x0006 0x000C - - - - - - - - Status

PWM diagnos-

tics

Ch3

PWM diagnos-

tics

Ch7

Module status 0x0009 0x0012 - FCE - - - COM V1 - V2 - - - - - - DIAG

Process output data:

Edition • 2019-01-21T19:24:07+01:00

Digital outputs 0x0000 0x0000 - - - - - - - - DX7 DX6 DX5 DX4 X3 DX2 DX1 DX0

5 / 6 TURCK Inc.

TM

Reg/

Word

0x0001

…

Reg/

Word

0x0001

…

Reg/

word

0x0004 0x0008 Counter value MSB

0x0007 0x000E - - - - - - - - - - - - - - - PWM

0x0008 0x0010 - - - - - - - - - - - - - - - PWM

Reg/

word

Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0

Structure according to general register mapping

Bit15Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0

Structure according to general register mapping

- - - - - - - - Ch7 Ch6 Ch5 Ch4 Ch3 CH2 CH1 CH0Channel

- - - - - - - - DX7 DX6 DX5 DX4 DX3 DX2 DX1 DX0

- - - - - - - - C3P2C3P4C2P2C2P4C1P2C1P4C0P2C0

Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

MSB LSB

VERR

VERR

V2

V2

P1C3

P1C2

P1C1

Bit15Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

MSB LSB

V1

Warn

P4

VERR

V1

P1C0

OUT

ERR

OUT

ERR

Compact Multiprotocol I/O Module for Ethernet
8 Universal Digital Channels, Configurable as PNP Inputs or 0.5 A Outputs
TBEN-S2-8DXP

Latch reset 0x0001 0x0002 - - - - - - - - DX7 DX6 DX5 DX4 DX3 DX2 DX1 DX0

Control 0x0002 0x0004 - - - - - - - - - - - - - - - CNT_

RST

PWM Ch3 0x0003 0x0006 - - - - - - - - Duty cycle

PWM Ch7 0x0004 0x0008 - - - - - - - - Duty cycle

VAUX control 0x0005 0x000F - - - - - - - - - - - - VAUX2

Legend:

V1 Undervoltage V1 CFG I/O configuration error

V2 Undervoltage V2 FCE I/O-ASSISTANT Force Mode active

Cx Port x Px Pin x

DIx Digital input channel x DOx Digital output channel x

Diag Module diagnostics available ERR x Overcurrent output channel x

VERRVxCHyz Overcurrent supply VAUXx channel y to z PWMOUTERR Overcurrent PWM output

VERRVxPyCz Overcurrent supply VAUXx, pin y, port z VAUXxPyCz Supply VAUXx, pin y, port z

CNT_RST Counter reset

P1

C3

VAUX2

P1

C2

VAUX1

P1

C1

VAUX1

P1

C0

Edition • 2019-01-21T19:24:07+01:00

6 / 6 TURCK Inc.