Datasheet TBEN-S1-8DIP Datasheet (Turck)

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

Type designation TBEN-S1-8DIP

Ident-No. 6814020

Supply

Supply voltage 24 VDC
Admissible range 18…30 VDC

Total current max. 4 A per voltage group V1
Voltage supply connection 2 × M8, 4-pin
Operating current V1: max. 150 mA mA
Sensor/Actuator supply V

Electrical isolation galvanic isolation of the voltage groups V1 and V2,

AUX1

supply of ports C0-C7 from V1

short-circuit proof, 0.5 A for group C0-C3, C4-C7

voltages up to 500 VAC

■ Male M8, 4-pin, for power supply

■ Input diagnostics by group

■ FLC/ARGEE programmable

■ PROFINET® device, EtherNet/IP™ de-

vice or Modbus® TCP slave

■ Integrated Ethernet switch

■ Supports 10 Mbps/100 Mbps

■ 2x M8, 4-pin, Ethernet fieldbus connec-

tion

■ Glass-fiber reinforced housing

■ Shock and vibration tested

■ Fully potted module electronics

■ Protection classes IP65 / IP67 / IP69K

System data

Fieldbus transmission rate 10 Mbps/100 Mbps
Fieldbus connection technology 2 × M8, 4-pin
Protocol detection automatic
Web server default: 192.168.1.254
Service interface Ethernet via P1 or P2

Field Logic Controller (FLC)

Supported from firmware version 3.1.4.0
Released from ARGEE version 2.0.24.0

Modbus TCP

Addressing Static IP, DHCP
Supported function codes FC1, FC2, FC3, FC4, FC5, FC6, FC15, FC16, FC23
Number of TCP connections 8
Input register start address 0 (0x0000 hex)
Output register start address 2048 (0x0800 hex)

EtherNet/IP™

Addressing acc. to EtherNet/IP™ specification
Quick Connect (QC) < 500 ms
Device Level Ring (DLR) supported
Class 3 connections 3
Class 1 connections 10
Input Assembly Instance 103
Output Assembly Instance 104
Configuration Assembly Instance 106

Edition • 2019-01-21T19:00:46+01:00

1 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

PROFINET

Addressing DCP
Conformance class B (RT)
MinCycleTime 1 ms
Fast Start-Up (FSU) < 500 ms
Diagnostics acc. to PROFINET alarm handling
Topology detection supported
Automatic addressing supported
Media Redundancy Protocol (MRP) supported

Digital inputs

Number of channels 8
Connectivity inputs M8, 3-pin
Input type PNP
Type of input diagnostics Group diagnostics
Switching threshold EN 61131-2 Typ 3, PNP
Low level signal voltage < 5 V
High level signal voltage > 11 V
Low level signal current < 1.5 mA
High level signal current > 2 mA
Input delay 0.2ms / 3 ms ms
Electrical isolation galvanic isolation to P1/P2

, voltages up to 500 VDC

Standard/Directive conformity

Vibration test acceleration to 20 g

acc. to EN 60068-2-6
Shock test acc. to EN 60068-2-27
Drop and topple acc. to EN 60068-2-31/IEC 60068-2-32
Electromagnetic compatibility acc. to EN 61131-2
Approvals and certificates CE, FCC
UL Certificate cULus LISTED 21 W2, Encl.Type 1 IND.CONT.EQ.

General Information

Dimensions (W x L x H) 32 x 144 x 32mm
Operating temperature -40…+70 °C
Storage temperature -40…+85 °C
Altitude max. 5000 m
Protection class IP65

IP67

IP69K
MTTF 319 years acc. to SN 29500 (Ed. 99) 20 °C
Housing material PA6-GF30
Housing color Black
Material label Polycarbonate
Halogen-free yes
Mounting 2 mounting holes � 4.6 mm

Note the numbering of the IO range:

From firmware version 3.1.4.0 and higher ports C0

to C7 and channels CH0 to CH7 are counted. For

more details on the corresponding change see man-

ual.

Edition • 2019-01-21T19:00:46+01:00

2 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

Accessories

It is strongly recommended to use only pre-assembled Ethernet

cables!

Ethernet cable (example):

M8-M8:

PSGS4M-PSGS4M-4413-1M

Ident. no. U-55718

M8-RJ45:

PSGS4M-RJ45S-4413-1M

Ident. no.: U-55725

M8-M12:

RSSD-PSGS4M-4413-1M

Ident. no.: U-58840

Accessories

Actuator and sensor cable/PUR cable (example):

M8 - open end

ID No. 6625562 PSG3M-2/TXL

M8-M8

ID No. 6625665 PKG3M-0,3-PSG3M/TXL

ID No. 6627137 PKG3M-3-PSG3M/TXL

M8 x 1 Ethernet

M8 x 1 Input

Accessories

Power supply cable (example):

M8-M8 2 m

PKG 4M-2-PSG 4M

Ident. no. U99-10815

M8 x 1 Voltage Supply

Edition • 2019-01-21T19:00:46+01:00

3 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

Module LED Status

LED Color Status Description

ETH1 / ETH2 Green ON Ethernet link (100 Mbps)

flashing Ethernet communication (100 Mbps)

Yellow ON Ethernet link (10 Mbps)

flashing Ethernet communication (10 Mbps)

OFF No Ethernet link

BUS Green ON Active connection to a master

Flashing Steady flashing: Ready

Sequence of 3 flashes in 2 seconds: FLC/ARGEE active

Red ON IP address conflict or Restore Mode or Modbus timeout

Flashing Blink/Wink command active

Red/

Green

ERR Green ON Diagnostics disabled

Red ON Diagnostics enabled

PWR Green ON Power supply V1 OK

LED Status I/O

LED Color Status Description

LED 0 … 7 Green ON Input active

Red Flashing Overload of the port supply. All LEDs of the affected group C0-C3 or C4-C7 are flashing.

LED 7 White Flashing Blink/Wink command active

Alternating Waiting for assignment of an IP address, DHCP or BootP

OFF Power off

V2 undervoltage diagnosis is parameter-dependent

OFF V1 power off or below defined tolerance of 18 V

OFF Input inactive

Edition • 2019-01-21T19:00:46+01:00

4 / 6 TURCK Inc.

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

Process Data Mapping of the Single Protocols

For more details on the corresponding protocols see manual.

Modbus TCP

Register Addressing (16-bit)

Offset Process Input Data: 0x0000, structure acc. to general register mapping

Offset Process Output Data: 0x0800: Structure acc. to general register mapping

EtherNet/IP

Word addressing (16-bit)

Process input data (station -> scanner):

Status word is located in front of the general process data!

GW status 0x0000 - FCE - - CFG COM V1 - V2 - - - - - - Diag

Process output data (scanner -> station):

Control word is located in front of the general process data!

Control 0x0000 reserved

PROFINET:

Byte addressing (8-bit)

Offset Process Input Data: 0x0000, structure acc. to general register mapping

Offset Process Output Data: 0x0000: Structure acc. to general register mapping

General register mapping:

Address details are relative, offset of the respective protocol is to be observed.

Channel/port/pin assignment:

Port

Pin

Process input data:

Digital inputs 0x0000 0x0000 - - - - - - - - DI7 DI6 DI5 DI4 DI3 DI2 DI1 DI0

Diagnostics 0x0001 0x0002 - - - - - - - - - - - - - - VERR

Latch input 0x0002 0x0004

Counter Ch0 0x0003 0x0006 Counter value LSB

Frequency Ch0 0x0005 0x000A Frequency MSB Frequency LSB

Status 0x0006 0x000C - - - - - - - - reserved

Module status 0x0007 0x000E - FCE - - - COM V1 - V2 - - - - - - DIAG

Process output data:

Latch reset 0x0000 0x0000 - - - - - - - - DI7 DI6 DI5 DI4 DI3 DI2 DI1 DI0

Control 0x0001 0x0002 - - - - - - - - - - - - - - - CNT_

Legend:

V1 Undervoltage V1 CFG I/O configuration error

V2 Undervoltage V2 FCE I/O-ASSISTANT Force Mode active

Edition • 2019-01-21T19:00:46+01:00

Cx Port x

5 / 6 TURCK Inc.

TM

Reg/

Word

0x0001

…

Reg/

Word

0x0001

…

Reg/

word

0x0004 0x0008 Counter value MSB

Reg/

word

Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0

Structure according to general register mapping

Bit15Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0

Structure according to general register mapping

- - - - - - - - Ch7 Ch6 Ch5 Ch4 Ch3 CH2 CH1 CH0Channel

- - - - - - - - DI7 DI6 DI5 DI4 DI3 DI2 DI1 DI0

- - - - - - - - C7P4C6P4C5P4C4P4C3P4C2P4C1P4C0

Bit 15 Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

MSB LSB

Bit15Bit 14 Bit 13 Bit 12 Bit 11 Bit 10 Bit 9 Bit 8 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

Byte Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0 Bit 7 Bit 6 Bit 5 Bit 4 Bit3 Bit 2 Bit 1 Bit 0

MSB LSB

V1

CH47

Warn

P4

VERR

V1

CH03

RST

Compact Multiprotocol I/O Module for Ethernet
8 Digital PNP Inputs, Input Diagnostics per Group
TBEN-S1-8DIP

DIx Digital input channel x DOx Digital output channel x

Diag Module diagnostics available ERR x Overcurrent output channel x

VERRVxCHyz Overcurrent supply VAUXx channel y to z PWMOUTERR Overcurrent PWM output

VERRVxPyCz Overcurrent supply VAUXx, pin y, port z VAUXxPyCz Supply VAUXx, pin y, port z

CNT_RST Counter reset

Edition • 2019-01-21T19:00:46+01:00

6 / 6 TURCK Inc.