SDS Number: 00015008001 Revision Date: 3/15/2017
24 Hour Emergency Phone Numbers
Medical/Poison Control:
In U.S.: Call 1-800-222-1222
Outside U.S.: Call your local poison
control center
Transportation/National Response
Center:
Safety Data Sheet
1-800-535-5053
1-352-323-3500
NOTE: The National ResponseCenter emergency
numbers to be used only in the event of chemical
emergencies involving a spill, leak, fire, exposure or
accident involving chemicals.
IMPORTANT: Provide this information to employees, customers, and users of this product. Read this SDS before handling or disposing of this
product. This product is covered by the OSHA Hazard Communication Standard and this document has been prepared in accordance with
requirements of this standard. All abbreviated terms used in this SDS are further described in Section 16.
1. Identification
This Safety Data Sheet is available in American Spanish upon request.
Los Datos de Serguridad pueden obtenerse en Espanol si lo riquiere.
Product Name: DAP High Temp 100% RTV Silicone Sealant Revision Date: 3/15/2017
Product UPC Number:
Product Use/Class: Caulking Compound
Manufactured For
Emergency Telephone:
Safety Data Sheet Coordinator:
070798080133
DAP Products Inc.
2400 Boston Street Suite 200
Baltimore, MD 21224-4723
888-327-8477 (non - emergency matters)
1-800-535-5053, 1-352-323-3500, 1-800-222-1222
MSDS@DAP.com
Supercedes Date:
SDS No: 00015008001
Preparer: Regulatory Department
New SDS
2. Hazards Identification
EMERGENCY OVERVIEW: Under normal use conditions, this product is not expected to cause adverse health effects. High
concentration of vapors may cause irritation to eyes and respiratory system.
Page 1 / 6
SDS Number: 00015008001 Revision Date: 3/15/2017
2.5-10
GHS07-GHS08
2.5-10
GHS07
1.0-2.5
GHS02-GHS06
1.0-2.5
No Information
0.1-1.0
No Information
GHS Classification
Carc. 1B
Symbol(s) of Product
Signal Word
Danger
Possible Hazards
1% of the mixture consists of ingredients of unknown acute toxicity
GHS HAZARD STATEMENTS
Carcinogenicity, category 1B H350 May cause cancer.
GHS LABEL PRECAUTIONARY STATEMENTS
P201 Obtain special instructions before use.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P308+P313 IF exposed or concerned: Get medical advice/attention.
P405 Store locked up.
P501 Dispose of contents/container to …
3. Composition/Information on Ingredients
Chemical Name CAS-No. Wt. % GHS Symbols GHS Statements
64742-46-7
7631-86-9
7429-90-5
13463-67-7
1333-86-4
The text for GHS Hazard Statements shown above (if any) is given in the "Other information" Section.
4. First-aid Measures
FIRST AID - INHALATION: Material is not likely to present an inhalation hazard at ambient conditions. If you experience difficulty in
breathing, leave the area to obtain fresh air. If continued difficulty is experienced, get medical attention immediately.
FIRST AID - SKIN CONTACT: Wash skin with soap and water for 15 minutes. Get medical aid if symptoms persist.
FIRST AID - EYE CONTACT: In case of contact, immediately flush eyes with large quantities of water for at least 15 minutes until
irritation subsides. Get medical attention immediately.
FIRST AID - INGESTION: If swallowed, DO NOT INDUCE VOMITING. Get medical attention immediately.
5. Fire-fighting Measures
UNUSUAL FIRE AND EXPLOSION HAZARDS: No Information
SPECIAL FIREFIGHTING PROCEDURES: Wear self-contained breathing apparatus pressure-demand (NIOSH approved or
equivalent) and full protective gear. Use water spray to cool exposed surfaces.
EXTINGUISHING MEDIA: None Known
6. Accidental Release Measures
ENVIRONMENTAL MEASURES: No Information
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Contain spilled material and remove with inert absorbent.
Dispose of contaminated absorbent, container and unused contents in accordance with local, state and federal regulations. Scrape
up dried material and place into containers. Use personal protective equipment as necessary. In case of spillage, absorb with inert
material and dispose of in accordance with applicable regulations.
7. Handling and Storage
HANDLING: KEEP OUT OF REACH OF CHILDREN!DO NOT TAKE INTERNALLY. Avoid breathing vapor and contact with eyes,
Page 2 / 6
SDS Number: 00015008001 Revision Date: 3/15/2017
skin and clothing. Use only with adequate ventilation. Ensure fresh air entry during application and drying. Wash thoroughly after
handling. Remove contact lenses before using. Do not handle contact lenses until all sealant has been cleaned from fingertips, nails
and cuticles. Residual sealant may transfer to contact lenses and cause severe eye irritation.
STORAGE: Avoid excessive heat and freezing. Do not store at temperatures above 120 degrees F. Store away from caustics and
oxidizers.
8. Exposure Controls/Personal Protection
Ingredients with Occupational Exposure Limits
Chemical Name ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA
Hydrotreated middle distillate N.E. N.E. N.E. N.E.
Silica, amorphous N.E. N.E. N.E. N.E.
Aluminum 1 mg/m3 TWA
respirable
particulate matter
Titanium dioxide 10 mg/m3 TWA N.E. 15 mg/m3 TWA
Carbon black 3 mg/m3 TWA
inhalable particulate
matter
Further Advice: MEL = Maximum Exposure Limit OES = Occupational Exposure Standard SUP = Supplier's Recommendation
Sk = Skin Sensitizer N.E. = Not Established
N.E. 15 mg/m3 TWA
total dust, 5 mg/m3
TWA respirable
fraction
total dust
N.E. 3.5 mg/m3 TWA N.E.
OSHA PEL-CEILING
N.E.
N.E.
Personal Protection
RESPIRATORY PROTECTION: No personal respiratory protective equipment normally required.
SKIN PROTECTION: Wear nitrile or neoprene gloves.
EYE PROTECTION: Goggles or safety glasses with side shields.
OTHER PROTECTIVE EQUIPMENT: Not required under normal use.
HYGIENIC PRACTICES: Wash hands before breaks and at the end of workday. Remove and wash contaminated
clothing before re-use.
Page 3 / 6
SDS Number: 00015008001 Revision Date: 3/15/2017
9. Physical and Chemical Properties
Appearance: Red Physical State: Paste
Odor: Acetic Acid Odor Threshold: Not Established
Density, g/cm3: 1.01 - 1.01 pH: Not Applicable
Freeze Point, °C: Not Established Viscosity (mPa.s): Not Established
Solubility in Water: No Information Partition Coeff., n-octanol/water: Not Established
Decomposition Temperature, °C: Not Established Explosive Limits, %: N.I. - N.I.
Boiling Range, °C: N.I. - N.I. Auto-Ignition Temperature, °C Not Established
Minimum Flash Point, °C: 100 Vapor Pressure, mmHg: Not Established
Evaporation Rate: Slower Than n-Butyl Acetate Flash Method: Pensky-Martens
Closed Cup
Vapor Density: Heavier Than Air
Combustibility: Does not support combustion
(See "Other information" Section for abbreviation legend)
(If product is an aerosol, the flash point stated above is that of the propellant.)
Flammability: Non-Flammable
10. Stability and Reactivity
STABILITY: Stable under recommended storage conditions.
CONDITIONS TO AVOID: Oxidizing agents. Excessive heat and freezing.
INCOMPATIBILITY: Incompatible with strong bases and oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: Normal decomposition products, i.e., COx, NOx.
11. Toxicological Information
EFFECT OF OVEREXPOSURE - INHALATION: Under normal use conditions, this product is not expected to cause adverse health
effects. During application and cure, this product releases acetic acid. Inhalation of vapors in high concentration may cause mild
irritation of respiratory system (nose, mouth, mucous membranes).
EFFECT OF OVEREXPOSURE - SKIN CONTACT: Under normal use conditions, this product is not expected to cause adverse
health effects. Prolonged or repeated contact with skin may cause mild irritation.
EFFECT OF OVEREXPOSURE - EYE CONTACT: Under normal use conditions, this product is not expected to cause adverse
health effects. Direct eye contact may cause irritation.
EFFECT OF OVEREXPOSURE - INGESTION: Under normal use conditions, this product is not expected to cause adverse health
effects. Single dose oral toxicity is very low. Amounts ingested incidental to industrial handling are not likely to cause injury; however,
ingestion of large amounts may cause injury. Ingestion may result in obstruction when material hardens.
CARCINOGENICITY: No Information
EFFECT OF OVEREXPOSURE - CHRONIC HAZARDS: Repeated or prolonged exposure may cause mild irritation of eyes and
skin.
PRIMARY ROUTE(S) OF ENTRY: No Information
Acute Toxicity Values
The acute effects of this product have not been tested. Data on individual components are tabulated below
CAS-No. Chemical Name Oral LD50 Dermal LD50 Vapor LC50
64742-46-7 Hydrotreated middle distillate 7400 mg/kg Rat >2000 mg/kg Rabbit >20 mg/L
7631-86-9 Silica, amorphous >3300 mg/kg Rat >5000 mg/kg Rabbit >20 mg/L
7429-90-5 Aluminum >2000 mg/kg Rat 2000 mg/kg Rat 7.6 mg/l Rat
13463-67-7 Titanium dioxide >10000 mg/kg Rat >5000 mg/kg Rabbit >20 mg/L
1333-86-4 Carbon black >8000 mg/kg Rat >3000 mg/kg Rabbit > 20 mg/L
N.I. = No Information
Page 4 / 6
SDS Number: 00015008001 Revision Date: 3/15/2017
12. Ecological Information
ECOLOGICAL INFORMATION: Ecological injuries are not known or expected under normal use.
13. Disposal Information
DISPOSAL INFORMATION: This product does not meet the definition of a hazardous waste according to U.S. EPA Hazardous
Waste Management Regulation, 40 CFR Section 261. Dispose as hazardous waste according to all local, state, federal and provincial
regulations. State and Local regulations/restrictions are complex and may differ from Federal regulations. Responsibility for proper
waste disposal is with the owner of the waste.
14. Transport Information
SPECIAL TRANSPORT PRECAUTIONS: No Information
DOT UN/NA Number: N.A.
DOT Proper Shipping Name: Not Regulated
DOT Technical Name: N.A.
DOT Hazard Class: N.A.
Hazard SubClass: N.A.
Packing Group: N.A.
15. Regulatory Information
U.S. Federal Regulations:
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA ‘Hazard Categories’ promulgated under Sections 311 and 312 of the
Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under applicable definitions, to
meet the following categories:
None Known
SARA SECTION 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the
Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Chemical Name CAS-No.
Aluminum 7429-90-5
TOXIC SUBSTANCES CONTROL ACT:
All ingredients in this product are either on TSCA inventory list, or otherwise exempt.
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
No TSCA 12(b) components exist in this product.
CALIFORNIA PROPOSITION 65 CARCINOGENS AND REPRODUCTIVE TOXINS
CALIFORNIA PROPOSITION 65:
None known.
International Regulations: As follows -
CANADIAN WHMIS:
This SDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16 headings.
WHMIS Class
Not Controlled
Page 5 / 6
SDS Number: 00015008001 Revision Date: 3/15/2017
16. Other Information
Revision Date:
Reason for revision: HazCom2012/GHS Conversion
Datasheet produced by: Regulatory Department
3/15/2017
Supersedes Date:
New MSDS
HMIS Ratings:
Health: 1 Flammability: 0 Reactivity: 1 Personal Protection: X
VOC Less Water Less Exempt Solvent, g/L
VOC Material, g/L:
VOC as Defined by California Consumer Product Regulation, Wt/Wt%:
30.2
30
3.0
Text for GHS Hazard Statements shown in Section 3 describing each ingredient:
H228 Flammable solid.
H250 Catches fire spontaneously if exposed to air.
H261 In contact with water releases flammable gases.
H312 Harmful in contact with skin.
H331 Toxic if inhaled.
H332 Harmful if inhaled.
H350 May cause cancer.
Icons for GHS Pictograms shown in Section 3 describing each ingredient:
GHS02
GHS06
GHS07
GHS08
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
DAP believes the data and statements contained herein are accurate as of the date hereof. They are offered in good faith as typical
values and not as a product specification. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF FITNESS FOR ANY
PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR IMPLIED, IS MADE WITH REGARD TO THE
INFORMATION HEREIN PROVIDED OR THE PRODUCT TO WHICH THE INFORMATION REFERS. Since thisdocument is intended
only as a guide to the appropriate use and precautionary handling of the referenced product by a properly trained person, it is
therefore the responsibility of the user to (i) review the recommendations with due consideration for the specific context of the
intended use and (ii) determine if they are appropriate.
Page 6 / 6
Loading...