SDS Number: 00030406004 Revision Date: 3/15/2018
24 Hour Emergency Phone Numbers
Medical/Poison Control:
In U.S.: Call 1-800-222-1222
Outside U.S.: Call your local poison
control center
Transportation/National Response
Center:
Safety Data Sheet
1-800-535-5053
1-352-323-3500
NOTE: The National ResponseCenter emergency
numbers to be used only in the event of chemical
emergencies involving a spill, leak, fire, exposure or
accident involving chemicals.
IMPORTANT: Provide this information to employees, customers, and users of this product. Read this SDS before handling or disposing of this
product. This product is covered by the OSHA Hazard Communication Standard and this document has been prepared in accordance with
requirements of this standard. All abbreviated terms used in this SDS are further described in Section 16.
1. Identification
This Safety Data Sheet is available in American Spanish upon request.
Los Datos de Serguridad pueden obtenerse en Espanol si lo riquiere.
Product Name: DAP RapidFuse Adhesive Revision Date:
Product UPC Number:
Product Use/Class: Adhesive
Manufactured For
070798001558, 070798001565,
070798001572, 070798001589,
070798001701, 070798001732
DAP Products Inc.
2400 Boston Street Suite 200
Baltimore, MD 21224-4723
888-327-8477 (non - emergency matters)
SDS Coordinator: MSDS@dap.com
Emergency Telephone: 1-800-535-5053,
1-352-323-3500, 1-800-222-1222
Supercedes Date:
SDS No:
Preparer:
2. Hazards Identification
3/15/2018
8/8/2016
00030406004
Regulatory and Environmental
Affairs
EMERGENCY OVERVIEW: WARNING!Combustible liquid and vapor. Keep container closed and away from heat, sparks, and open
flame. Store away from caustics and oxidizers. Cyanoacrylate. Danger. Bonds skin and eyes in seconds. Keep out of the reach of
children. May cause skin irritation.
Page 1 / 6
SDS Number: 00030406004 Revision Date: 3/15/2018
75-100
GHS07
2.5-10
GHS07
1.0-2.5
No Information
GHS Classification
Eye Irrit. 2, Skin Irrit. 2, STOT SE 3 RTI
Symbol(s) of Product
Signal Word
Warning
Possible Hazards
6% of the mixture consists of ingredients of unknown acute toxicity
GHS HAZARD STATEMENTS
Skin Irritation, category 2 H315 Causes skin irritation.
Eye Irritation, category 2 H319 Causes serious eye irritation.
STOT, single exposure, category 3, RTI H335 May cause respiratory irritation.
GHS LABEL PRECAUTIONARY STATEMENTS
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P264 Wash thoroughly after handling.
P271 Use only outdoors or in a well-ventilated area.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P302+P352 IF ON SKIN: Wash with plenty of soap and water.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing.
P312 Call a POISON CENTER or doctor/physician if you feel unwell.
P321 Specific treatment (see … on this label).
P332+P313 If skin irritation occurs: Get medical advice/attention.
P337+P313 If eye irritation persists: Get medical advice/attention.
P362 Take off contaminated clothing.
P403+P233 Store in a well-ventilated place. Keep container tightly closed.
P405 Store locked up.
P501 Dispose of contents/container to …
3. Composition/Information on Ingredients
Chemical Name CAS-No. Wt. % GHS Symbols GHS Statements
7085-85-0
106-79-6
68909-20-6
The text for GHS Hazard Statements shown above (if any) is given in the "Other information" Section.
4. First-aid Measures
FIRST AID - INHALATION: If you experience difficulty in breathing, leave the area to obtain fresh air. If continued difficulty is
experienced, get medical attention immediately.
FIRST AID - SKIN CONTACT: Do not pull bonded skin apart. Soak in warm soapy water. Gently peel apart using a blunt object such
as spoon.
FIRST AID - EYE CONTACT: If the eye is bonded shut, apply warm water with a wet pad to release the eyelashes. Adhesive will
bond to eye protein and will cause the eye to periodically shed tears. This will help debond the adhesive. Keep eye covered until
debonding is complete. Do not force eye open. Solid particles of cyanoacrylate may be trapped behind the eyelids and cause
abrasive damage. Seek medical attention.
FIRST AID - INGESTION: Make sure airways are clear. Adhesive will immediately polymerize in mouth and will be impossible to
swallow. Saliva will slowly separate the adhesive from mouth.
5. Fire-fighting Measures
UNUSUAL FIRE AND EXPLOSION HAZARDS: Vapor from this material will readily ignite at temperatures above 150 degrees F if an
ignition source is present. Vapors may form an explosive mixture with air at temperatures above 150 degrees F. Eliminate sources of
Page 2 / 6
SDS Number: 00030406004 Revision Date: 3/15/2018
ignition: heat, electrical equipment, sparks and flames.
SPECIAL FIREFIGHTING PROCEDURES: Wear self-contained breathing apparatus pressure-demand (NIOSH approved or
equivalent) and full protective gear. Use water spray to cool exposed surfaces.
EXTINGUISHING MEDIA: Carbon Dioxide, Dry Chemical, Water Fog
6. Accidental Release Measures
ENVIRONMENTAL MEASURES: No Information
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Immediately eliminate sources of ignition. Contain spilled
material and remove with inert absorbent. Dispose of contaminated absorbent, container and unused contents in accordance with
local, state and federal regulations. Dike to prevent entering any sewer or waterway. Transfer liquid to a holding container. Read all
product instructions before using. Personal protective equipment should include impervious gloves, protective eye wear, and suitable
work clothes. In case of spillage, absorb with inert material and dispose of in accordance with applicable regulations. Use absorbent
material or scrape up dried material and place in container.
7. Handling and Storage
HANDLING: KEEP OUT OF REACH OF CHILDREN!DO NOT TAKE INTERNALLY. Keep away from open flames, hot surfaces and
sources of ignition. Provide adequate ventilation. Wear appropriate personal protection. Avoid contact with eyes, skin and clothing.
STORAGE: Store away from sources of ignition and heat. Do not store at temperatures above 120 degrees F. Store containers
away from excessive heat and freezing. Store away from caustics and oxidizers. Keep containers tightly closed.
8. Exposure Controls/Personal Protection
Ingredients with Occupational Exposure Limits
Chemical Name ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA
OSHA PEL-CEILING
Ethyl cyanoacrylate 0.2 ppm TWA N.E. N.E. N.E.
Dimethyl sebacate N.E. N.E. N.E. N.E.
Fumed silica N.E. N.E. N.E. N.E.
Further Advice: MEL = Maximum Exposure Limit OES = Occupational Exposure Standard SUP = Supplier's Recommendation
Sk = Skin Sensitizer N.E. = Not Established
Personal Protection
RESPIRATORY PROTECTION: No personal respiratory protective equipment normally required.
SKIN PROTECTION: Chemical-resistant gloves and chemical goggles should be used to prevent skin and eye contact.
None Required.
EYE PROTECTION: Safety glasses with side-shields.
OTHER PROTECTIVE EQUIPMENT: Wear suitable gloves and eye/face protection. Not required under normal use.
HYGIENIC PRACTICES: Avoid breathing vapor. Avoid skin contact. Avoid eye contact. Wash contaminated clothing
before re-use.
Page 3 / 6
SDS Number: 00030406004 Revision Date: 3/15/2018
9. Physical and Chemical Properties
Appearance: Clear Physical State: Liquid
Odor: Sharp Odor Threshold: Not Established
Density, g/cm3: 1.08 - 1.08 pH: Not Established
Freeze Point, °C: Not Established Viscosity (mPa.s): ca. 4000 cps
Solubility in Water: No Information Partition Coeff., n-octanol/water: Not Established
Decomposition Temperature, °C: Not Established Explosive Limits, %: N.I. - N.I.
Boiling Range, °C: N.I. - N.I. Auto-Ignition Temperature, °C Not Established
Minimum Flash Point, °C: 88 Vapor Pressure, mmHg: Not Established
Evaporation Rate: Faster Than n-Butyl Acetate Flash Method: Seta Closed Cup
Vapor Density: Heavier Than Air
Combustibility: Does not support combustion
(See "Other information" Section for abbreviation legend)
(If product is an aerosol, the flash point stated above is that of the propellant.)
Flammability: Combustible
10. Stability and Reactivity
STABILITY: Stable under normal conditions.
CONDITIONS TO AVOID: Protect from water. Keep away from open flames, hot surfaces and sources of ignition. Keep away from
oxidizing agents, strongly alkaline and strongly acid materials in order to avoid exothermic reactions.
INCOMPATIBILITY: Water, alcohols, bases, cotton, wool, cellulosic materialsOpen flames, hot surfaces and sources of ignition.
Keep away from strong oxidizing agents, heat and open flames. Strong bases.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide
11. Toxicological Information
EFFECT OF OVEREXPOSURE - INHALATION: Inhalation may cause irritation to the respiratory tract (nose, mouth, mucous
membranes).
EFFECT OF OVEREXPOSURE - SKIN CONTACT: Immediate bonding of skin may result upon contact.
EFFECT OF OVEREXPOSURE - EYE CONTACT: Immediate bonding of eyelids may result upon contact.
EFFECT OF OVEREXPOSURE - INGESTION: Immediate bonding of mouth may result upon contact.
CARCINOGENICITY: No Information
EFFECT OF OVEREXPOSURE - CHRONIC HAZARDS: Chronic exposure may cause dermatitis.
PRIMARY ROUTE(S) OF ENTRY: Eye Contact, Inhalation, Skin Contact
Acute Toxicity Values
The acute effects of this product have not been tested. Data on individual components are tabulated below
CAS-No. Chemical Name Oral LD50 Dermal LD50 Vapor LC50
7085-85-0 Ethyl cyanoacrylate 5000 mg/kg Rat 2000 mg/kg Rabbit <21.1 mg/L Rat
106-79-6 Dimethyl sebacate 2000 mg/kg Rat N.I. N.I.
68909-20-6 Fumed silica N.I. N.I. N.I.
N.I. = No Information
12. Ecological Information
ECOLOGICAL INFORMATION: Ecological injuries are not known or expected under normal use.
13. Disposal Information
DISPOSAL INFORMATION: This product does not meet the definition of a hazardous waste according to U.S. EPA Hazardous
Page 4 / 6
SDS Number: 00030406004 Revision Date: 3/15/2018
Waste Management Regulation, 40 CFR Section 261. Dispose as hazardous waste according to all local, state, federal and provincial
regulations. State and Local regulations/restrictions are complex and may differ from Federal regulations. Responsibility for proper
waste disposal is with the owner of the waste.
14. Transport Information
SPECIAL TRANSPORT PRECAUTIONS: Not regulated for transport as packaged. Not regulated for transport in nonbulk containers
(<= 450 liters (119 gallons). The U.S. Department of Transportation (DOT) classification above is ONLY when transported in bulk
containers (> 450 liters, 119 gallons).
Not a dagerous good under Internation Air Transport (IATA).
Not a dagerous good under Internation Maritime Transport (IMO).
DOT UN/NA Number: NA1993
DOT Proper Shipping Name: Combustible liquid, n.o.s.
DOT Technical Name: (Ethyl cyanoacrylate)
DOT Hazard Class: Combustible
Hazard SubClass: N.A.
Packing Group: III
15. Regulatory Information
SARA SECTION 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title III of the
Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
No Sara 313 components exist in this product.
TOXIC SUBSTANCES CONTROL ACT:
All ingredients in this product are either on TSCA inventory list, or otherwise exempt.
This product contains the following chemical substances subject to the reporting requirements of TSCA 12(B) if exported from
the United States:
No TSCA 12(b) components exist in this product.
16. Other Information
Revision Date: 3/15/2018
Reason for revision: Revision Description Changed
Substance and/or Product Properties Changed in Section(s):
01 - Product Information
08 - Exposure Controls/Personal Protection
11 - Toxicological Information
15 - Regulatory Information
16 - Other Information
Substance Regulatory CAS Number Changed
Substance Hazardous Flag Changed
Substance Hazard Threshold % Changed
Revision Statement(s) Changed
Datasheet produced by: Regulatory Department
HMIS Ratings:
Health: 2 Flammability: 1 Reactivity: 0 Personal Protection: X
VOC Less Water Less Exempt Solvent, g/L:
VOC as Defined by California Consumer Product Regulation, Wt/Wt%:
Supersedes Date: 8/8/2016
VOC Material, g/L:
VOC Actual, Wt/Wt%:
5.0
5
0.5
0.5
Text for GHS Hazard Statements shown in Section 3 describing each ingredient:
Page 5 / 6
SDS Number: 00030406004 Revision Date: 3/15/2018
H302 Harmful if swallowed.
H312 Harmful in contact with skin.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
H335 May cause respiratory irritation.
Icons for GHS Pictograms shown in Section 3 describing each ingredient:
GHS07
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
DAP believes the data and statements contained herein are accurate as of the date hereof. They are offered in good faith as typical
values and not as a product specification. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF FITNESS FOR ANY
PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR IMPLIED, IS MADE WITH REGARD TO THE
INFORMATION HEREIN PROVIDED OR THE PRODUCT TO WHICH THE INFORMATION REFERS. Since thisdocument is intended
only as a guide to the appropriate use and precautionary handling of the referenced product by a properly trained person, it is
therefore the responsibility of the user to (i) review the recommendations with due consideration for the specific context of the
intended use and (ii) determine if they are appropriate.
Page 6 / 6
Loading...