Danfoss DEVIpipeguard 30, DEVIpipeguard 60 Data sheet

DataEVIpipeguard™SheetIndus ry

DEVIpipeguard™ 30 Industry,

DEVIpipeguard™ 60 Industry

DEVIpipeguard™ Industry is a self-limiting heating cable that is mainly used for frost protection of pipes and for temperature maintenance in applications up to 120 °C powered or 190 °C unpowered cable.

The cable allows steam cleaning in pipes. The heating element, the insulation and the outer jacket of DEVIpipeguard™ Industry are made of fluoropolymers.

Fluoropolymer outer jacket offers increased protection against chemicals (oil and fuel) and abrasion.

A temperature-dependent resistance element between two parallel-guided copper conductors regulates and limits the heat output of the heating cable. This power setting takes place at every point of the heating cable, according to the ambient temperature prevailing there.

If the temperature rises, the power of the cable is reduced. This self-limiting prevents overheating of the cable, even if it is overlaid. The heating cable can be cut off at desired length by the parallel current supply. This simplifies planning and installation. All selflimiting heating cables must be over-temperature protected by a thermostat, as the output will decrease, but never be zero.

The installation of a thermostat is recommended. The cable is not approved for use in drinking water.

Benefits:

•Cut to length on site

•PVC free

Standard compliance:

• VDE E 0254: 94

Approvals:

	Type	Value
	Nominal voltage	230 V AC (max. 254 V AC)
	Nominal output (min-max):
	DEVIpipeguard™ 30 Industry	30 W/m @ 10 °C (30-39 W/m @ 10 °C)
	DEVIpipeguard™ 60 Industry	60 W/m @ 10 °C (54-72 W/m @ 10 °C)
	Maximum permissible use temperature	120 °C, powered
		190 °C, unpowered
	Temperature rating conform IEC 60079-30	DEVIpipeguard™ 30 Industry – T3 (max 200°C)
		DEVIpipeguard™ 60 Industry – T2 (max 300°C)
	Minimum installation and switched on temperature	-5 °C
	Cable dimensions	11,8 x 5,8 mm
	Outer sheath	Red, Fluorpolymer
	Minimum braid coverage	70 %
	Maximum resistance protective braid	18,2 Ω/Km
	Bending Ø, min.	50 mm (Ø to the inside of the tape)
	IP Class	IPX7

Types DEVIpipeguard™ 30 Industry

	Item no.	Length	Min-max length per	Number of length	Nominal	EAN no.
			drum	allowed on drum, max	output @ 10 °C
	00109025	Drum, 270 m	270-330 m	1	30 W/m	5703466195673
	98300673	Cut-to-length	1 m	-	30 W/m	5703466197257

Types DEVIpipeguard™ 60 Industry

	Item no.	Length	Min-max length per	Number of length	Nominal	EAN no.
			drum	allowed on drum, max	output @ 10 °C
	00109027	Drum, 270 m	270-330 m	1	60 W/m	5703466163498
	98300674	Cut-to-length	1 m	-	60 W/m	5703466197264

AI239086497888en-010104

Produced by Danfoss ©

Maximum heating circuit length on a pipe, with circuit breaker with C-characteristic

<![if ! IE]> <![endif]>Switch on temperature	<![if ! IE]> <![endif]>Power W/m
30 °C
	25,5
20 °C	27,7
10 °C	30,0
0 °C	32,3
-10 °C	34,5
-20 °C	36,8
-30 °C	39,0

DEVIpipeguard™ 30 Industry

10 A	16 A	20 A		25 A		32 A
65		130		133		133
	104
61	98	122		133		133
58	92	115		133		133
54	87	109		133		133
52	83	103		129		133
49	79	98		123		133
47	75	94		117		133

<![if ! IE]>

<![endif]>Power W/m

52,4

56,2

60,0

63,8

67,6

71,4

75,2

DEVIpipeguard™ 60 Industry

10 A	16 A	20 A		25 A		32 A
36		73		75		75
	58
34	55	69		75		75
32	52	65		75		75
31	49	61		75		75
29	47	58		73		75
28	45	56		70		75
27	43	53		67		75

Power output characteristic

Output of heating cable installed and measured on a pipe.

			W/m
			80
			70
									DEVIpipeguard™ 30 Industry
			60						DEVIpipeguard™ 60 Industry
			50
			40
			30
			20
			10
			0
			-20 -10 0 10 20			30 40 50 60 70 80 90 100 110				120
									Pipe temperature (°C)
Accessories
Item no.		EAN no.			Type				Description					Image
			Connection kit for DEVI-			With clamping block for the connection of cold lead and
00109007		5703466167397	pipeguard 30/60 Industry			heating cable, shrink end-cap, shrink tubes, bitumen
			(PT-30/60) heating cables						gaskets and ferrules.
			Connection kit for DEVI-			For mounting in connection box with screw connections.
00109026		5703466135778	pipeguard 30/60 Industry			With cable gland M20x1,5 with locknut, shrink end-cap,
			(PT-30/60) heating cables			shrink tubes, bitumen gasket and ferrules.
			Polyester box ABSC for
19400167		5703435002858	DEVIiceguard™ and			For SLC (DEVIiceguard, DEVIpipeguard)
			DEVIpipeguard™
19405851		5703435002964			Bracket	Fitting for connection of housing (19400167) to pipes
11010410		5703435031001	Insulation introduction			With mounting plate M20 60x60x1 mm AISI304;
						Cable gland U17 M20x1,5; Cable gland M25
19805076		5703435003053	Tape aluminium			Self-adhesive, with 2-colour warning label, max. 75 °C
			38 mm x 50 m

AI239086497888en-010104

Produced by Danfoss ©