Dakota Ultrasonics Couplant User Manual

SAFETY DATA SHEET

UltraSoniX ™

SECTION 1 – IDENTIFICATION

Product Name: UltraSoniX™
Recommended Use: Industrial Ultrasound Couplant
Restrictions on Use: For Industrial Use Only

Manufacturer: Echo Ultrasonics® LLC

774 Marine Drive, Bellingham, WA 98225
360-758-2702

Emergency: 360-758-2702

SECTION 2 – HAZARDS

General

Information:

Emergency

Overview:

Potential

Health

Hazards:

Hazard status: UltraSoniX is not hazardous by OSHA HazCom 2012 Criteria
Color: Light blue green

Physical State: High Viscosity liquid
Odor: Mild
Hazards: May cause allergic skin reaction in sensitive individuals.

Slippery

Eye: May cause irritation.
Skin: Essentially nonirritating
Inhalation: Not applicable at room temperature.

Vapor from high temperatures may cause irritation of upper respiratory tract.

Ingestion: Low toxicity, potentially harmful if ingested in large quantities, which is unlikely given taste and viscosity.
Label Elements according to OSHA HazCom 2012: NONE APPLICABLE

SECTION 3 – COMPOSITION/INGREDIENTS

Component

Propylene Glycol
Polymers
Corrosion Inhibitors
Sodium Molybdate
Water

CAS #

57-55-6
9003-01-4
84812-94-2
7631-95-0
7732-18-5

WT %

<35.0%
<2.0 %
<4.0 %
< 2.0 %
Balance

SECTION 4 – FIRST-AID MEASURES

General

Information

To avoid irritation, use good industrial hygiene including eye protection, protecting open wounds and avoid contact with
mucus membranes. Keep away from children and adults with dementia.

Eyes:

Skin:

Inhalation:

Ingestion:

Symptoms/Effects

Irritation
None expected

Not normally a hazard
Not normally a hazard

Treatment Recommendations

Flush eyes with plenty of water. Remove contacts after 1-2 minutes; flush for several minutes.
Remove with dry cloth or paper towel; rinse away residue with water. Seek medical attention if
irritation persists.
If exposed to excessive vapors, move to fresh air; get medical attention if cough or symptoms .
If conscious, give several glasses of water or milk and induce vomiting by touching finger to
back of throat. Seek medical attention.

SECTION 5 – FIRE-FIGHTING MEASURES

Suitable Extinguishing Equipment:

Specific Hazards from Combustion:

Unusual Hazards:

NFPA Rating:

All Types.
None

None

SECTION 6 – ACCIDENTAL RELEASE MEASURES

Personal Precautions:

Emergency Procedures:

Containment Procedures:

Cleanup Procedures:

Spilled material may cause a slipping hazard. Prevent entry into spill area by unauthorized persons.
Keep unnecessary people away. Sprinkle with traction material if spill cannot be cleaned up immediately.
Minimize entry of material into storm sewers and drainage systems.
Sweep or shovel spilled material into containers, wipe area with wet rags or hose with water to remove
completely. UltraSoniX is slippery.

SECTION 7 – HANDLING AND STORAGE

Precautions:

Recommendations:

Although this material does not present a major skin or eye concern, skin and eye contact should be
avoided as a general industrial practice. Gloves are not required, but may be desirable for repeated
or long-term contact. Wearing eye protection is required. Wash hands and contaminated skin after
handling.
Store in original closed containers. Keep away from children and adults with dementia.

SECTION 8 – EXPOSURE CONTROLS / PERSONAL PROTECTION

Permissible Exposure Limits:

Engineering Controls:

Personal Protection:

Special Requirements:

None established
None required

Eyes: Use safety glasses with side shields or other chemical appropriate eye protection.
Skin: Wear protective gloves if sensitive to any listed ingredients.
Respiratory: Not required.
Additional: It is good general practice to provide eyewash stations or rinse bottles.

None

SECTION 9 – PHYSICAL AND CHEMICAL PROPERTIES

Appearance:

Odor:

Odor Threshold:

Solubility:

pH:

Light blue green high viscosity liquid
Mild
No data
100% in water
8

Page 1 of 2

SAFETY DATA SHEET

UltraSoniX ™

Viscosity:

Flammable Limits:

Vapor Pressure:

Vapor Density:

Relative Density:

Melting Point:

Freezing point:

Boiling Point:

Evaporation Rate:

Flammability:

Flash Point:

Partition Coefficient:

Auto-Ignition Temperature:

Volatile Organic Compounds (VOC)

60,000 cps Brookfield
Non Flammable
Not applicable
1

1.1 – 1.4 g/cc (water = 1)
Not applicable
5F, -15C
>220F, 104C
No data
Non Flammable
Not Applicable
No data
Not Applicable
Less than 1.5% (Calculated)

SECTION 10 – STABILITY AND REACTIVITY

Reactivity:

Chemical Stability:

Potential Hazards:

Conditions to Avoid:

Incompatible Materials:

Hazardous Polymerization:

Hazardous Decomposition Products:

Stable
Stable
No significant hazards expected
None
None Known
None known
None known

SECTION 11 – TOXICOLOGICAL INFORMATION

Likely Routes and Effects of Exposure:

Immediate:

Delayed or Chronic:

Symptoms:

Carcinogenicity:

See section 2
See section 2
No data
No data
No data

SECTION 12 – ECOLOGICAL INFORMATION

Toxicology Data:

Bioaccumulation Potential:

Soil to Groundwater Motility:

Other Adverse Effects:

Not expected to be acutely toxic to aquatic organisms
No bioaccumulation is expected
Not expected
None expected

SECTION 13 – DISPOSAL CONSIDERATIONS

General Information:

Disposal Containers:

Disposal Methods:

Physical, Chemical properties affecting disposal:

Sewage Disposal:

Special precautions for landfills or incinerators:

All disposal practices must be in compliance with all federal, state, and local laws
and regulations.
Any
Landfill, municipal sewer if permissible
None
Generally permissible
None

SECTION 14 – TRANSPORT INFORMATION

UN Number and Proper Shipping Name:

UN Proper Shipping Name:

Transport Hazard Class:

Packing Group:

Environmental and Special Hazards:

Bulk Transport Guidance:

Not assigned
Not assigned
None
None
None
None

SECTION 15 – REGULATORY INFORMATION

Regulatory Information not included

elsewhere:

TSCA Inventory: All ingredients listed
CEPA: All ingredients listed on DSL
Section 311 SARA Title III/CERCLA
Immediate (acute): No
Delayed (chronic): No
Fire Hazard: No
Reactive: No
Sudden Release of Pressure: No
SARA 313

This product does not contain chemicals which require reporting nor listing under California
Proposition 65.

SECTION 16 – OTHER INFORMATION

SDS Preparation Date:

Last Revision:

Changes from Last Revision:

Other Information:

8 December 2013
22 May 2015
Compliance with GHS Guidelines
None

All information herein is provided in good faith and believed to be accurate and reliable. However, no warranty, express or implied, is given.
Regulatory requirements are subject to change and may differ according to location. It is the buyer’s/user’s responsibility to ensure that this
product is used in compliance with all federal, state, and local laws.

Page 2 of 2