Daewoo KOR-181G Operating Instructions Manual

MICROWAVE OVEN

KOR-181G

OPERATING
INSTRUCTIONS

Before operating this oven, please read these instructions completely.

TABLE OF CONTENTS

1. PRECAUTIONS TO AVOID POSSIBLE EXPOSURE TO EXCESSIVE
MICROWAVE ENERGY 2

2. IMPORTANT SAFETY INSTRUCTIONS 3

3. ARCING 4

4. FEDERAL COMMUNICA TIONS COMMISSION RADIO FREQUENCY

INTERFERENCE ST ATEMENT (U.S.A. ONLY) 4

5. GROUNDING INSTRUCTIONS 5

6. SAFETY PRECAUTIONS 6

7. INST ALLATION 7

8. CARE OF YOUR MICROWAVE OVEN SAFETY 8

9. HOW TO USE YOUR MICROW AVE OVEN SAFELY 9

10. OPERA TION PROCEDURE 9
1 1. FEATURES 10

12. HOW TO SET THE OVEN CONTROLS 1 1

13. TO STOP THE OVEN WHILE THE OVEN OPERATING 17

14. COOKING GUIDE 18

15. COOKING UTENSILS 18

16. COOKING TECHNIQUES 18

17. DEFROSTING 19

18. DEFROSTING CHART 20

19. COOKING CHART 21

20. REHEA TING CHAR T 22

21. WEIGHT & MEASURE CONVERSION CHART 24

22. SPECIFICA TIONS 25

23. BEFORE YOU CALL FOR SERVICE 25

24. QUESTIONS AND ANSWERS 26

25. LIMITED WARRANTY 27

1

PRECAUTIONS TO AVOID POSSIBLE EXPOSURE
TO EXCESSIVE MICROWAVE ENERGY

(a) Do not attempt to operate this oven with the door open since open-door operation can result in

harmful exposure to microwave energy. It is important not to defeat or tamper with the safety
interlocks.

(b) Do not place any object between the oven front face and the door or allow soil or cleaner residue to

accumulate on sealing surfaces.

(c) Do not operate the oven if it is damaged. It is particularly important that the oven door close properly

and that there is no damage to the: (1) door (bent), (2) hinges and latches (broken or loosened), (3)
door seals and sealing surfaces.

(d) The oven should not be adjusted or repaired by anyone except properly qualified service personnel.

2

IMPORTANT SAFETY INSTRUCTIONS

When using electrical appliances, basic safety precautions should be followed, including the following:
WARNING-To reduce the risk of burns, electric shock, fire, injury to persons or exposure to excessive

microwave energy:

11. Read all instructions before using the appliance.

12. Read and follow the specific “PRECAUTIONS TO

AVOID POSSIBLE EXPOSURE TO EXCESSIVE
MICROWAVE ENERGY” found on page 1.

13. This appliance must be grounded. Connect only to

properly grounded outlet. See “GROUNDING
INSTRUCTIONS” found on page 3.

14. Install or locate this appliance only in accor-dance

with the provided installation instructions.

15. Some products such as whole eggs and sealed

containers - for example, closed glass jars-are
able to explode and should not be heated in this
oven.

16. Use this appliance only for its intended use as

described in this manual. Do not use corrosive
chemicals or vapors in this appliance. This type of
oven is specifically designed to heat, cook, or dry
food. It is not designed for industrial or laboratory
use.

17. As with any appliance, close supervision is

necessary when used by children.

18. Do not operate this appliance if it has a damaged

cord or plug, if it is not working properly, or if it has
been damaged or dropped.

19. This appliance should be serviced only by

qualified service personnel.
Contact nearest authorized service facility for
examination, repair or adjustment.

10. Do not cover or block any openings on the
appliance.

11. Do not store this appliance outdoors. Do not use
this product near water — for example, near a
kitchen sink, in a wet basement, or near a
swimming pool, or similar locations.

12. Do not immerse cord or plug in water.

13. Keep cord away from heated surfaces.

14. Do not let cord hang over edge of table or counter.

15. Either:
a) When cleaning surfaces of door and oven that

comes together on closing the door, use only
mild, non-abrasive soaps or detergents applied
with a sponge or soft cloth , or

b) When separate cleaning instructions are

provided, See door surface cleaning
instructions on.

16. To reduce the risk of fire in the oven cavity:
a) Do not overcook food. Carefully attend

appliance when paper, plastic, or other com­bustible materials are placed inside the

oven to facilitate cooking.

b) Remove wire twist-ties from paper or plastic

bags before placing bag in oven.

c) If materials inside the oven ignite, keep oven

door closed, turn oven off, and disconnect the
power cord, or shut off power at the fuse or
circuit breaker panel.

d) Do not use the cavity for storage purposes. Do

not leave paper products, cooking utensils, or
food in the cavity when not in use.

17. Do not use this microwave oven to heat corrosive
chemicals (for example, sulfides and chlorides).
Vapours from such corrosive chemicals may
interact with the contact and springs of the safety
interlock switches thereby rendering them
inoperable.

18. Keep the waveguide cover clean at all times.
Wipe the oven interior with a soft damp cloth after
each use. If you leave grease or fat anywhere in
the cavity it may overheat, smoke or even catch
fire when next using the oven.

19. Never heat oil or fat for deep frying as you cannot
control the temperature and doing so may lead to
overheating and fire.

20. Liquids, such as water, coffee, or tea are able to
be overheated beyond the boiling point without
appearing to be boiling due to surface tension of
the liquid. Visible bubbling or boiling when the
container is removed from the microwave oven is
not always present. THIS COULD RESULT IN
VERY HOT LIQUIDS SUDDENLY BOILING
OVER WHEN A SPOON OR OTHER UTENSIL
IS INSERTED INTO THE LIQUID. To reduce the
risk of injury to persons:
a) Do not overheat the liquid.
b) Stir the liquid both before and halfway through

heating it

c) Do not use straight-sided containers with

narrow necks.

d) After heating, allow the container to stand in the

microwave oven for a short time before
removing the container.

e) Use extreme care when inserting a spoon or

other utensil into the container.

SAVE THESE INSTRUCTIONS

3

ARCING

If you see arcing, press Door Open Button and correct the problem.

Arcing is the microwave term for sparks in the oven. Arcing is caused by:

• Metal or foil touching the side of the oven.

• Foil not molded to food (upturned edges act like antennas).

• Metal, such as twist-ties, poultry pins, or gold rimmed dishes, in the microwave.

• Recycled paper towels containing small metal pieces being used in the microwave.

FEDERAL COMMUNICATIONS COMMISSION
RADIO FREQUENCY INTERFERENCE
STATEMENT (U.S.A ONLY)

WARNING:

This equipment generates and uses ISM frequency energy and if not installed and used properly,
that is in strict accordance with the manufacturer’s instructions, may cause interference to radio
and television reception.
It has been type-tested and found to comply with limits for an ISM Equipment pursuant to part 18
of FCC Rules, which are designed to provide reasonable protection against such interference in a
residential installation.
However, there is no guarantee that interference will not occur in a particular installation.
If this equipment does cause interference to radio or television reception, which can be
determined by turning the equipment off and on, the user is encouraged to try to correct the
interference by one or more of the followings.

• Reorient the receiving antenna of radio or television.

• Relocate the Microwave oven with respect to the receiver.

• Move the microwave oven away from the receiver.

• Plug the microwave oven into a different outlet so that microwave oven and receiver are on
different branch circuits.

THE MANUFACTURER is not responsible for any radio or TV interference caused by
UNAUTHORIZED MODIFICATION to this microwave oven.
It is the responsibility of the user to correct such interference.

4

GROUNDING INSTRUCTIONS

This appliance must be grounded. In the event of an electrical short circuit, the grounding plug reduces
the risk of electric shock by providing an escape wire for electric current. This appliance is equipped with
a cord having a grounding wire with a grounding plug. The plug must be plugged into an outlet that is
properly installed and grounded.’

WARNING:

Improper use of the grounding can result in a risk of electric shock. Consult a qualified electrician
or serviceman if the grounding instructions are not completely understood, or if doubt exists as to
whether the appliance is properly grounded, and either :

(1) If it is necessary to use an extension cord, use only a 3-wire extension cord that has a 3-blade

grounding plug, and a 3-slot receptacle that will accept the plug on the appliance. The marked
rating of the extension cord shall be equal to or greater than the electrical rating of the
appliance. or

(2) Do not use an extension cord, if the power supply cord is too short, have a qualified electrician

or serviceman install an outlet near the appliance.

WARNING:

Do not cut or remove the third(ground) prong from the power cord under any circumstances.

USING AN ADAPTER

Due to potential safety hazards, we strongly recommend against the use of an adapter plug.
However, if the still elect to use an adapter, where local codes may permit, a TEMPORARY
CONNECTION may be made to a properly grounded two prong wall receptacle by the use of a
UL/CSA listed adapter, which is avilable at most hardware stores.

5

SAFETY PRECAUTIONS

GENERAL USE

DO NOT attempt to temper with or make any adjustment or repair to door, control panel or any other part
of the oven. DO NOT remove outer case from oven.
Repairs should only be done by a qualified service person.
If a fire occurs in the oven, touch the STOP/CLEAR pad and LEAVE THE DOOR CLOSED. Disconnect
the power cord, or shut off power at the fuse or circuit breaker panel.
DO NOT operate the oven empty. The microwave energy will reflect continuously throughout the oven if
no food or water is present to absorb energy.
DO NOT attempt to dry clothes, newspapers or other materials in the oven. They may catch on fire.
DO NOT use recycled paper products as they may contain impurities which may cause sparks and/or
fires when used.
DO NOT hit or strike the control panel, damage to controls may occur.
AVOID inserting nails, wire, etc. through any holes in the unit while operating the oven. Never insert a
wire, nails or any other metal object through the holes on the cavity or any other holes or gaps because
such objects may cause electric shock and microwave leakage.

UTENSILS

METAL CONTAINERS or dishes with metallic rims should not be used. Arcing may occur.
METAL TWIST-TIE must not be used in the microwave oven.
DO NOT use SEALED JARS or NARROW NECK buttles for cooking or reheating. They may shatter.
DO NOT use CONVENTIONAL THERMOMETERS in the microwave oven. They may cause arcing.
Remove PLASTIC STORE WRAPS before cooking or defrosting in the oven.
For FURTHER INFORMATION on proper cooking utensils, refer to the Introduction in the Microwave
cooking guide.

FOOD

Never use your microwave oven for HOME CANNING. The oven is not designed to permit proper
canning. Improperly canned food may spoil and be dangerous to consume.
COOKING TIMES given in the cooking guide are APPROXIMATE. Factors that may affect cooking are:
starting temperature, altitude, volume, size and shape of foods and utensils used. As you become
familiar with the oven, you will be able to adjust for these factors.
It is better to UNDERCOOK RATHER THAN OVENCOOK foods. If food is undercooked, it can always
be returned to the oven for further cooking. If food is overcooked, nothing can be done. Always start with
minimum cooking times.
SMALL QUANTITIES of food or foods with LOW MOISTURE content can burn, dry out or catch on fire if
cooked too long.
DO NOT boil eggs in their shell. Pressure may build up and the eggs will explode.
Potatoes, apples, egg yolks, whole acom squash and sausage are examples of food with NONPOROUS
SKINS. These must be pierced before cooking to prevent bursting.
POPCORN must be popped in a microwave corn popper. Microwave popped corn produces a lower
yield than conventional popping. Do not pop popcorn unless popped in a microwave approved popcorn
utensils or unless it’s commercially packaged and recommended especially for microwave ovens. Do not
use oil unless specifed by the manufacturer.
DO NOT attempt to deep fat fry in your oven.
HEATED LIQUIDS can ERUPT if not mixed with air. Do not heat liquids in your microwave oven without
first stirring.

6

INSTALLATION

Examine the oven after unpacking.

1

Check for damage such as a misaligned door, broken door or dent in the cavity.
If any damage is visible, DO NOT INSTALL, and notify your dealer immediately.

Level, flat location.

2

Install the microwave oven on a level, flat surface.

Ventilation.

3

Do not block air vents. If they are blocked during operation, the oven may overheat and eventually
cause a failure.
For proper ventilation, allow 3 inches of space between oven top, sides, rear and adjacent
surfaces. The minimum height of free space necessary above the top surface of the oven is
100mm.

Away from radio and TV sets.

4

Poor television reception and radio interference may result if the oven is located close to a TV,
radio, antenna, feeder, etc. Place the oven as far from them as possible.
Away from heating appliances and water taps.
Keep the oven away from heat, steam or splashing liquids. These things can adversely affect oven
wiring and contacts.

Power supply.

5

This microwave oven requires a power supply of approximately 13 Amperes, 120 Volts, 60Hz and
a grounded outlet.
A short power cord is provided to reduce the risk of the user becoming entangled in or tripping
oven longer cord. Longer cord sets or extension cords are available and may be used if care to
exercised.
If an extension cord is used, the marked electrical rating of the cord should be at least as great as
the electrical rating of the oven. The extension cord must be a grounding-type 3-wire cord. The
longer cord should be arranged so it does not drape over the table top or counter where children
can pull on it or trip over it.

7

CARE OF YOUR M.W.O

Turn the oven off before cleaning.
Keep the inside of the oven clean. When food spatters or spilled liquids adhere to oven walls, wipe with a

damp cloth. Mild detergent may be used if the oven gets very dirty. The use of harsh detergent or
abrasives is not recommended.

The outside oven surface should be cleaned with soap and water, rinsed and dried with a soft cloth. To
prevent damage to the operating parts inside the oven, water should not be allowed to seep into the
ventilation openings.

If the Control Panel becomes wet, clean with a soft, dry cloth. Do not use harsh detergents or abrasives
on Control Panel.

If steam accumulates inside or around the outside of the oven door, wipe with a soft cloth. This may
occur when the microwave oven is operated under high humidity conditions and in no way indicates
malfunction of the unit.

It is occasionally necessary to remove the glass tray for cleaning. Wash the tray in warm sudsy water or
in a dishwasher.

The roller guide and oven cavity floor should be cleaned regularly to avoid excessive noise. Simply wipe
the bottom surface of the oven with mild detergent water or window cleaner and dry. The roller guide
may be washed in mild sudsy water.

Glass Tray

Roller Guide

8