Daewoo DW-3610, DW-3600, DW-3620P Service Manual
DAEWOO ELECTRONICS CO., LTD.
Service Manual
DW-3600 (P)
DW-3610 (P)
DW-3620 (P)
Washing Machine
DW-3600 (P)
DW-3610 (P)
DW-3620 (P)
SPECIFICATIONS ..........................................................................................................................................................................2
CAUTION ON THE OPERATION...................................................................................................................................................3
WIRING AND CIRCUIT DIAGRAM................................................................................................................................................4
CIRCUIT DIAGRAM OF WASH TIMER.........................................................................................................................................6
TROUBLE SHOOTING GUIDE......................................................................................................................................................7
HOW TO DISASSEMBLE...............................................................................................................................................................9
EXPLODED VIEWS ......................................................................................................................................................................11
PARTS LIST..................................................................................................................................................................................14
1
CONTENTS
1. SPECIFICATIONS
NO ITEM SPECIFICATIONS
1
Voltage 100V ~ 110V ~ 127/220V ~ 220V ~ 230 ~ 240V ~ 110/220V
Frequency 50/60Hz 60Hz 50 Hz
Washer 240/300 W 305 W 305 W 305W
2 Spindryer 100/130 W 120 W 140 W 120 W
pump model – 210 W 210 W 210W
DWM-3600(P) 784(W) x 454(D) x 894(H) mm
3 DWM-3610(P)
784(W) x 454(D) x 934(H) mm
DWM-3620(P)
4
26.8 Kg
pump model 28.1 Kg
5
Washer 3.6 Kg
Spin dryer 3.6 Kg
6 Impeller Type
7 Centrifugal Separated Type
8 Max. 15min, Manual Operation
9 Max. 5min, Manual Operation
10
High 43 §⁄
Low 31§⁄
11
Wash motor 338/400 400 r.p.m. 338 r.p.m.
Spin motor 1400/1600 1600 r.p.m. 1400 r.p.m.
12 Manual
2
Power
Source
Power
Consumption
Dimemsions
Weight (net)
Capacity
Wash Type
Spin Type
Wash Time
Spin Time
Water level
R.P.M
Water Supply
A. Caution on Installtion
• Install the washer in the place easy access to water, electrical power and drainage.
• Install the washer on a firm, and flat floor.
• Connect the grounding wire to a water faucet if the pipe is made of metal before plugging the power cord into the
socket.
• Avoid installing the machine where it can be exposed to rain or direct ray of the sun, that may cause a trouble or
discoloration. In case the machine has to be installed in such a place, provide a shield to protect machine from rain or
direct rays of the sun.
• Be sure that inside of panel are enough tightened to prevent water leakage.
• In summer or other periods when there is a great difference between the water temperature and the air temperature,
drops of water may condense on the outside of the tub, and the floor might become wet from dripping; be careful of
this.
• Please disconnect the power cord plug after washing.
B. Grounding
• Connect the grounding wire to a water faucet if the pipe is made of metal before plugging the power cord into the
socket.
• Make sure that the power cord is unplugged during ground work.
• Be sure to wind grounding wire on the metal pipe like Fig 1. (Do not
connect the grounding wire end to a gas tube).
• For maximum security, attatch the grounding wire to a copper plate or
grounding rod and bury it at least 20cm in the ground like Fig. 2.
C. Caution on Use
• Do not use water which contains rust.
• Never put your hands into the tub through wash and rinse process.
• Do not allow water to contact the switches in the control panel.
• Drain the water in the wash tub fitting selector switch on the drain position.
• Use only water above 0°C
CAUTION ON USE
CAUTION ON THE OPERATION
Grounding Wire
Fig. 1
Fig. 2
3
Putting in the clothes
distribute the clothes in the
tub being sure that nothing is
protruding out of the top.
Pocket Check
Check the pockets of the
laundry and remove contents
that shouldn't be washed
before putting the laundry into
the tub.
Detergent Amount
If you use too much detergent,
excessive amount of suds and
rinsing may be arisen: limit the
amount of detergent you use.
Acting time of pulsator
Wash Action Move Stop.
Normal Reverse
30" 4"
Soft Reverse 4.5" 6.8"
More than 20cm
Grounding Rod
4
WIRING AND CIRCUIT DIAGRAM
5
CIRCUIT DIAGRAM OF WASH TIMER
Loading...