Dacor EOG52, OGC36, EOG36, OGC52 User Manual

0 (0)
Dacor EOG52, OGC36, EOG36, OGC52 User Manual

Use & Care

Outdoor Grill

SAFETY IS EVERYONE’S RESPONSIBILITY. ALL DACOR APPLIANCES ARE DESIGNED AND CONSTRUCTED TO GIVE YOU MANY YEARS OF SAFE OPERATION. THE OPERATION WILL BE FURTHER ENHANCED IF PROPER CARE AND JUDGEMENT ARE EXERCISED IN THE USE AND MAINTENANCE OF THIS APPLIANCE.

IMPORTANT INFORMATION

Operating Instructions

Care and Cleaning Instructions

Safety Tips

WARNINGS:

Must be followed carefully to avoid personal injury or damage.

NOTES:

Contains helpful hints and tips.

Using

 

Read

Before

Please

 

 

 

 

 

 

Your

Outdoor

Grill

 

 

 

Place Serial Number Label Here

Part No. 65250 Rev. D

2

TABLE OF CONTENTS....................................

1

Purpose of this Manual ................................

1

Product Registration ....................................

1

IMPORTANT INSTRUCTIONS .........................

1

GRILL OPERATION.......................................

2-5

Safety...........................................................

2

Liquid Propane Tanks...................................

2

Grill/Cart Features.....................................

2-3

Install Liquid Propane Tank..........................

3

Lighting Liquid Propane Grills......................

3

Lighting Natural Gas Grills........................

3-4

Manual Lighting............................................

4

Canopy Mounted Temperature Gauge.........

4

Preheating Instructions ................................

4

Grill Cooking ................................................

4

Smoker Cooking .......................................

4-5

Rotisserie Cooking.......................................

5

Side Burners ................................................

5

CARE AND CLEANING.................................

5-6

Cleaning Tips ...............................................

5

Exterior Surfaces .........................................

5

Interior Surfaces...........................................

6

PROBLEM SOLVING.....................................

7-8

Troubleshooting ...........................................

7

Product Maintenance...................................

8

If You Need Service .....................................

8

PRODUCT WARRANTY...................................

8

What Is Covered ..........................................

8

What Is Not Covered....................................

8

Purpose of This Manual

This Use & Care Manual is designed to enable you to properly operate and maintain your new grill. Please keep this manual handy for easy access and quick reference.

Additional information may be requested by e-mailing, writing or phoning the DACOR

Customer Service Department. The address and phone number of this department are listed on the inside front cover of this manual.

Product Registration

Important Instructions

WARNINGS:

1.If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death.

2.Do not store or use gasoline or other flammable liquids in the vicinity of the appliance.

3.If you smell gas:

Shut off gas to the appliance.

If odor continues, immediately phone your gas supplier.

Extinguish any open flame.

If you cannot reach your gas supplier, call the fire department.

Open Lid.

4.Installation and service must be performed by a qualified installer, service agency or the gas supplier.

5.This unit is for outdoor use only in a well-ventilated area. Not to be used in a building, garage or any other enclosed area.

6.Tested in accordance with ANSI Z21.581998, standard for outdoor cooking gas appliances and CAD/CGA 1.6-M98, standard for outdoor cooking gas appliances.

7.Check your local building codes for proper method of installation. In the absence of local codes, this unit should be installed in accordance with National Fuel Gas Code No. Z223.1 Current Issue and National Electrical Code ANSI/NFPA No. 70 Current Issue or the CAN/CGA

- B149.1 Natural Gas Installation Code or CAN/CGA - B149.2 Propane Gas Installation Code and C22.1 Canadian Electrical Code Part 1.

8.CALIFORNIA PROPOSITION 65 B The burning of cooking fuel generates some by-products that are on the

list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn

customers of potential exposure to such substances. To minimize exposure to these substances, always operate this unit to the instructions contained in this manual and provide good ventilation when cooking with gas.

IMPORTANT:

1.Keep the area around the appliance clear and free from combustible materials, gasoline and other flammable liquids.

2.This outdoor gas cooking appliance is not intended to be installed in or on a recreational vehicle or boat.

3.Do not leave the grill unattended while cooking.

4.Do not place any items in front of the unit while in use. This could obstruct the proper flow of air needed for combustion and ventilation.

5.Keep the ventilation openings of the enclosure free and clear of obstructions and debris.

6.Always inspect the natural gas or LP gas hose assembly before each use of the appliance. If you see evidence of abrasion, wear, or a cut gas connection hose then immediately replace the hose prior to operation of the appliance.

7.Keep any electrical supply cords and the fuel gas supply lines away from heating surfaces.

If you received a damaged product, immediately contact your dealer or builder. Do not install or use a damaged appliance.

Please enter the information requested in the spaces provided below. This information will be required in the unlikely event that a service call becomes necessary:

Model No.

 

 

 

 

Serial No.

 

 

Date Purchased

 

 

 

Date Installed

 

Purchased From

 

 

 

 

 

Address

 

 

 

 

 

Phone

 

 

 

 

 

1

Safety

IMPORTANT:

Your Dacor grill is designed to be safe when installed properly. However, care must be used as these grills can produce very high temperatures which increases the potential for injury or accidents. We recommend you always follow the safety notes listed below.

NOTES:

1.Carefully read this manual before using the grill, this will reduce the risk of injury due to fire or electric shock.

2.Proper installation is extremely important. Refer to the installation instructions included within the literature kit which shipped with your grill. Your installer should show you the location of the gas shut off valve and the electrical connection. You should also be familiar with the correct and easiest way to shut off these utilities in case of an emergency. Minimum clearances to combustible materials should always be observed. Reference the correct clearances in the installation instructions.

3.Repair and replacement of any parts within this appliance should be referred to an authorized Dacor service technician.

4.Children should never be allowed to sit, stand, or play around the grill at any time. Children should never be allowed to crawl inside the grill cart. Remember, when in use, the grill will get hot enough to cause severe burns.

5.Avoid the potential for grease fires by frequently cleaning the grease tray. Always allow the unit to completely cool down before removing the grease tray for cleaning.

6.Keep hands and fingers away from all edges of the canopy while in the raised position.

7.Never move the grill during cooking.

8.Always keep the canopy closed when moving the grill cart.

9.Spiders and insects can nest in the burners of this grill. This can obstruct the proper flow of gas into the burner and cause improper operation, fire hazard and potential damage to the unit. Periodically inspect the burners. If any of these symptoms occur, immediately refer to service or the troubleshooting section of this manual.

10.Your outdoor grill is equipped with a three-prong grounding plug to protect animals against shock hazard. This plug should be plugged directly into a properly grounded three-prong receptacle. Never cut or remove the grounding prong from this plug.

11.The grill canopy should be closed during the pre-heating period.

12.Gas Smells:

If you smell gas when the unit is not in use, immediately shut off the gas at the main valve, open the canopy and call your local service agency to inspect the unit. Finding a leak is not a do-it-yourself process.

If you smell gas when the unit is in use, immediately shut off the gas at the main valve, open the canopy, and dissipate for at least five minutes. Relight the burners and verify that they are operating properly. If the burners fail to light

or are not functioning properly, shut off the main gas supply valve and call your local service agency for inspection.

13.Never block the vents located on the back of the grill or the opening at the rear of the canopy. Blocking any or all of these vents during cooking, will result in damage to the unit and may cause a fire or injury.

IMPORTANT:

1.For your safety, the gas supply must be turned off at the LP-gas supply tank when your grill is not in use.

2.The LP-gas supply cylinder must be disconnected when this barbecuing appliance is not in use.

3.If the appliance is to be stored indoors, the LP tank must be disconnected and removed from the appliance.

4.LP tanks not connected for use shall not be stored in the vicinity of this or any other appliance.

5.Detach and leave the tank outdoors if storing the unit indoors. These grills are for outdoor use only.

6.Check for leaks after every tank change.

Grill Features

7

Liquid Propane Tanks

1.Dacor LP model grills are set at the factory for LP tank installations. Use only the Dacor supplied regulator. DO NOT ATTEMPT FIELD CONVERSIONS.

Approved field conversions from natural to LP or LP to natural will only be approved when completed by an authorized Dacor servicer.

2.Dacor grills are approved for a maximum LP tank capacity of 20 pounds (5 gallons). The tank must be constructed and marked in accordance with the specifications for LP-gas tanks of the U.S. Department

of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, tank, Spheres and Tubes of the Transportation of Dangerous Goods. To minimize the potential for fire or an explosion, the following precautions should be observed when using, filing, or storing an LP tank:

Never use a dented or rusty LP tank. If there is any question as to the soundness of the tank, have it checked by your LP supplier.

Never use a tank with a damaged or defective shut off valve.

Do not over fill the LP tank. Never fill the tank beyond eighty percent (80%) of its capacity. Overfilling will cause the pressure relief valve on the tank to vent excess gas vapor. This vapor is combustible and can ignite, causing a fire.

When transporting an LP tank, ensure it is in an upright position and away from any sources of high heat.

Do not store additional LP tanks inside the cart of the unit. Tanks must be stored outdoors in a well-ventilated area out of the direct sunlight and/or sources of high heat, and out of the reach of children.

LP tank supply systems must be arranged for vapor withdrawal.

LP tank used must include a collar to protect the tank valve.

8

 

6

6

10

 

9

11

14

12

5

13

4

3

2

1

Built in Model EOG36 Features

EOG36 Features:

1.Rotisserie control knob

2.Grill and Smoker control knobs

3.Drip retrieval tray

4.Interior lights on/off switch

5.Stainless steel grills

6.Halogen cooking lights

7.Infrared rotisserie burner (13,000 BTU)

8.Canopy mounted temperature gauge

9.Keep warm rack

10.Rotisserie Rod and forks

11.Rotisserie Motor

12.Rotisserie Bracket

13.Removable smoker box

14.Heat control channels

8

7

6

5

11

10

9

4

3

2

1

 

 

 

 

 

Built in Model EOG52 Features

2

Loading...
+ 8 hidden pages