Culligan Good Water Machine H30 Series Owner's Manual

O

WN

E

R

S

G

U

ID

E

H-30 MODEL SERIES

NOTICE: This system is intended for use on potable water
supplies or disinfected water containing cysts. Do not use where
water is microbiologically unsafe or with water of unknown
quality. If bacterial contamination is present, a recognized
method of water disinfection is required.

i

Check with your public works department for applicable local plumbing and
sanitation codes. F ollow your local codes if they differ from the standar ds
used in this manual.

Operational, maintenance and replacement requirements are essential for this
product to perform properly . The Good W ater Machine™ contains replaceable
particulate and activated carbon filters. It also includes a replaceable reverse
osmosis membrane filter which is critical for the effective reduction of Total
Dissolved Solids. The filtered water should be tested periodically to verify that
the system is performing properly .

CULLIGAN INTERNATIONAL COMPANY
One Culligan P arkway
Northbrook, Illinois USA 60062-6209
847/205-6000
www.culligan.com

Safety/Warnings ...............................................ii

System Specifications ....................................... 1

Introduction

About Y our System .............................. 2

Component Description........................ 2

Certified P erformance .......................... 3

How to Use Y our System ...................... 4

P erformance Check.............................. 4

Installation

Application Guidelines ......................... 5

Servicing Y our System

Service Schedule ................................. 7

Filter Replacement ............................... 7

P arts List .......................................... 11

Service Log .................................................. 12

Warranty...................................................... 13

Table of Contents

GOOD WATER MACHINE

™

DRINKING WATER SYSTEM

®

SYSTEM SPECIFICATIONS

System Flow Sequence...................... P article/Activated Carbon Filter(s),

Reverse Osmosis Membrane F ilter ,
Storage T ank, P olishing F ilter ,
Dispensing F aucet

P article/Activated Carbon Filter

H-30S-R .................................. Filter cloth wrapped activated carbon

block

P article Filter , H-30PR V -C ................ 5 Micron Spun P olypropylene

Activated Carbon F ilter , H-30PRV -C.. Cullar® G Activated Carbon

Reverse Osmosis Membrane Filter ..... Culligan® Aqua-Cleer® Thin Film

Composite

Production Rate1 - H-30 Models ....... 30 gpd (114 L/day)

Ratio of Product to Flush Flow2......... 1:3 - 1:5

P olishing F ilter ................................ Cullar G Activated Carbon

Dispensing F aucet ............................ Culligan Aqua-Cleer Faucet:

Rotary Operation, Stainless Steel

and Resin Flow P assages, with

Built-in Siphon Break

Colors ......................... Polished Chrome, White

Storage Capacity - Standard Tank ...... 2 gallons

- Medium T ank ....... 3 gallons

- Large T ank ........... 9 gallons

Dimensions - Filter Assembly

(H-30S-R) ............... 7"W x 4.3"D x 16.3"H

(H-30PRV-C)........... 15.8"W x 4.3"D x 16.3" H

- Storage Tank .............. 9" Diameter x 14" H

- Medium..................... 11"Diameter x 14" H

- Large......................... 15.5" Diameter x 24" H

1

Rating at 50 psi, 77°F, 500 mg/L TDS Influent, Without Storage Tank

2

May vary with pressure.

1

INTRODUCTION

Thank you for choosing a Culligan® Good W ater Machine™ drinking water
system. Y our new system is designed to bring you years of healthful,
deliciously crystal-clear Culligan® water . W ith its special faucet installed on
your sink, it’s like getting bottled water straight from your kitchen tap.

2

Particle F ilter (Model H-30PRV -C)

The particle filter screens out dirt, sand, rust, and other microscopic particles
15 times smaller than a grain of sand.

Activated Carbon Filter (Model H-30PR V -C)

The activated carbon filter gets rid of bad tastes and odors, including chlorine.
If present in your untreated water supply .

Particle/A ctivated Carbon Filter (Model H-30S-R)

The particle/activated carbon filter combines the filtration capabilities of
separate particle and activated carbon filters into one space efficient package.

Reverse Osmosis Membrane Filter

The reverse osmosis (RO) membrane filter squeezes out dissolved substances,
including lead, asbestos, and many others. These substances may not be in
your water . See P erformance Data Sheet for list of substances and removal
percentages.

Storage T ank

The storage tank holds up to 2 gallons of triple-filtered Culligan® water under
pressure for rapid delivery . Optional three and nine-gallon tanks are available.

Polishing F ilter

The Good W ater Machine™ includes a second activated carbon filter as added
assurance that your water will be crystal clear .

GOOD W ATER MACHINE SYSTEM COMPONENTS

Refer to Figure 1, page 6

ABOUT YOUR SYSTEM

The reverse osmosis method of water treatment has long been regarded as one
of the most efficient and effective ways to reduce impurities. It’s the technology
we’ve used to build your new Culligan Good W ater Machine. In addition, we’ve
incorporated activated carbon and fine particle filtration to bring you one of the
most effective systems available today .