Cuisinart CPO-600 User Manual

Outdoor Grilling Pro ducts

Outdoor Pizza Oven

MODEL: CPO-600
ASSEMBLY AND OPERATING INSTRUCTIONS

m WARNING: FOR OUTDOOR USE ONLY

m This instruction manual contains important information necessary for the
proper assembly and safe use of the appliance

m Read and follow all warnings and instructions before
assembling and using the appliance

m Follow all warnings and instructions when using the appliance
m Keep this manual for future reference

Note to installer: Leave this Owner’s Manual with the consumer after delivery and/or installation.
Note to customer: Leave this Owner’s Manual in a convenient place for future reference.

m DANGER

1. Do not store or use gasoline or
other flammable liquids or vapors
in the vicinity of this or any
other appliance.

2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.

m DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open lid.

4. If odor continues, keep away from
the appliance and immediately call
your fire department.

Failure to follow these instructions
could result in fire, explosion or burn
hazard, which could cause property
damage, personal injury or death.

m DANGER

1. Never operate this appliance unattended.

2. Never operate this appliance within 10 feet (3.05m) of any other gas cylinder.

3. Never operate this appliance with 25 feet (7.5m) of any flammable liquid.

4. lf a fire should occur, keep away from the appliance and immediately call
your fire department . Do not attempt to extinguish an oil or grease fire with water.

5. Heated liquids remain at scalding temperatures long after the cooking process.
Never touch cooking appliance until liquids have cooled to 115oF (45ºC) or less.

Failure to follow these instructions could result in fire, explosion or burn hazard,
which could cause property damage, personal injury or death.

1

Table of Contents

1. Warnings and Safety Instructions 3

1. Warnings and Safety Instructions y Instructions

If these instructions are ignored, there is a possibility of a hazardous fire or explosion which
could result in physical injury or property damage! It is your responsibility to assemble,
operate and maintain your gas grill properly.

READ ALL WARNINGS AND INSTRUCTIONS PRIOR TO ASSEMBLING

2. Illustrated Parts List 4

3. Exploded View 5

4. Assembly Instructions 6

5. Operating Your Grill

5.1 Choosing a location for installation 8

5.2 Special Instructions for the use of regulator and cylinder 8

5.3 Installing the LP gas cylinder 9

5.4 Checking for leak 9

5.5 Lighting instructions 10

5.6 Match lighting 10

5.7 Using the grill 10

5.8 Warming Tray 11

5.9 Tool Hooks 11

6. Care and Maintenance 11

7. Frequently Asked Questions 12

8. Troubleshooting 12

9. What To Expect 13

10. Warranty Program and Replacement Parts 14

AND OPERATING YOUR GRILL

WARNINGS:

m This grill is for outdoor use only. It should NOT be used in a building, garage or
any other enclosed area.
m The use of alcohol, prescription or non-prescription drugs may impair an individual’s
ability to properly assemble or safely operate this appliance.

m Do not leave the grill unattended. Keep children and pets away from the grill all the times.
m Do not use the grill in high wind.
m This grill must be used with propane gas only. Liquid propane is not natural gas. The conversion

or attempted use of natural gas in a liquid propane grill is dangerous and will void your warranty.

m Do not attempt to attach this grill to the self-contained propane system of a camper, trailer, motor

home or house.

m Do not use charcoal or lighter fluid.
m Do not use gasoline, kerosene or alcohol for lighting. The LP-gas cylinder must be constructed

and marked in accordance with the specifications for propane gas cylinder of the U.S. Department
of Transportation (DOT).

m Do not move appliance when in use.
m Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and

tightened. If there are any missing or damaged parts, contact customer service for a replacement.

m Do not alter the grill in any manner.
m Do not operate the grill if there is gas leak present.
m The use and installation of this product must conform to local codes. In the absence of local

codes, use the National Fuel Gas Code: ANSI Z223.1/NFPA54, Storage and Handling of Liquefied
Petroleum Gases, ANSI.NFPA 58 or Natural Gas and Propane Installation Code, CSA C149.1;
Propane Storage and Handling, CSA B149.2.

m This appliance is not intended to be installed in or on a boat or recreational vehicle.
m Locate the grill away from any combustible or non-combustible materials or

construction by at least 24 inches (61cm) from the back and sides.
m When cooking with oil or grease, have a type BC or ABC fire extinguisher readily available. In the

event of an oil or grease fire do not attempt to extinguish with water. Immediately call the fire
department. A type BC or ABC fire extinguisher may, in some circumstances contain the fire.

m This appliance shall not be used under overhead unprotected combustible construction.
m This appliance is not intended for and should never be used as a heater.
m This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection

from hot surfaces or splatter from cooking liquids.

m This appliance is not intended for commercial use.
m The pressure regulator supplied with the Cuisinart Gas Grill must be used.
m Do not touch or open the lid without a glove when the grill is hot. Only open the lid for cleaning

when it is completely cool down.
CALIFORNIA PROPOSITION 65
Warning:
Combustion by-products produced when using this product contains chemicals known to State

of Californian to cause cancer, birth defects, and other reproductive harm. To reduce the risk of
exposure to these substances, always use the grill in a well ventilated area.

2 3

2. Illustrated Parts List 3. Exploded View

Lid and Fire Box 1 pc

Leg Assembly 1 pc

Warming Tray 1 pc

Flame Tamer 1 pc

Pizza Stone 1 pc

Control Knob 1 pc

Smoke Chip Cup 1 pc

Pizza Peel 1 pc

Screw M6*12 2 pcs

Nut M6 2 pcs

Black Washer M6 8 pcs

Flame Tamer
Lock Pin

2 pcs

Pizza Stone
Holder

1 pc

1 Thermometer’s Bezel 13 Tools Hook 25 Pin

2 Thermometer 14 Tube Axis 26 Electrode

3 Lid Side Panel - Left 15 Fire Box 27 Rear Support Bracket - Right

4 Front Lid Panel 16 Lid Stopper 28 Handle’s Grip

5 Lid Support Panel 17 Control Panel 29 Carrying Handle

6 Pizza Stone 18 Leg Assembly 30 Regulator’s Support Bracket

7 Pizza Stone Holder 19 Rubber Feet 31 Regulator

8 Smoke Chip Cup 20 Pizza Peel 32 Control Knob

9 Flame Tamer Lock Pin 21 Match Holder 33 Control Knob’s Grip

10 Flame Tamer 22 Lid Panel - Top 34 Warming Tray

11 Rear Support

Bracket - Left

12 Burner 24 Lid Side Panel - Right

23 Lid Panel - Inner 35 Warming Tray’s Handle

4 5