Outdoor Grilling Pro ducts
VERTICAL 30" ELECTRIC SMOKER
MODEL: COS-330
ASSEMBLY AND OPERATING INSTRUCTIONS
m DANGER
Do not store or use gasoline or other flammable liquids
or vapors in the vicinity of this or any other appliance.
m WARNING
Do not use 16 or 18 gauge extension cords. Damage to
household wiring and/or fire could result. DO NOT USE
CHARCOAL. A charcoal fire will result and the grill is not
designed for charcoal. The fire will create an unsafe condition and damage the smoker.
m DANGER
Failure to follow these instructions could
result in fire, explosion or burn hazard,
which could cause property damage, personal injury or death.
m DANGER
Some parts may contain sharp edges –
especially as noted in the manual! Wear
protective gloves if necessary.
m WARNING
Burning wood chips gives off carbon
monoxide, which has no odor and can
cause death.
DO NOT burn wood chips inside homes,
vehicles, tents, garages, or any enclosed
areas.
Use only outdoors where it is well
ventilated.
m DANGER
1. Never operate this appliance unattended.
2. Never operate this appliance within 10 feet (3.05m) of any other gas cylinder.
3. Never operate this appliance within 25 feet (7.5m) of any flammable liquid.
4. lf a fire should occur, keep away from the appliance and immediately call your fire department.
Do not attempt to extinguish an oil or grease fire with water.
5. Heated liquids remain at scalding temperatures long after the cooking process. Never touch
cooking appliance until liquids have cooled to 115ºF (45ºC) or less.
m DANGER
Failure to follow these instructions could result in fire, explosion or burn hazard, which
could cause property damage, personal injury or death.
m WARNING: FOR OUTDOOR USE ONLY
m
This instruction manual contains important information necessary for the
proper assembly and safe use of the appliance
m Read and follow all warnings and instructions before
assembling and using the appliance
m Follow all warnings and instructions when using the appliance
m Keep this manual for future reference
Note to installer:
Leave this Owner’s Manual with the consumer after delivery and/or installation.
Note to customer: Leave this Owner’s Manual in a convenient place for future reference.
1
m WARNING
CALIFORNIA PROPOSITION 65
1. Combustion by-products produced when using this
product contain chemicals known to the State of
California to cause cancer, birth defects, and other
reproductive harm.
2. This product contains chemicals, including lead and
lead compounds, know to the State of California to
cause cancer, birth defects or other reproductive harm.
Wash your hands after handling this product.
Table of Contents
1. Warnings and Safety Instructions 3
2. Exploded View 6
3. Assembly Instructions 7
4. Operating Your Smoker 10
5. Care And Maintenance 12
6. Storage 12
7. FAQ and Troubleshooting 12
8. Warranty and Replacement Parts 13
3
1. Warnings and Safety Instructions
If these instructions are ignored, there is a possibility of a hazardous fire or explosion which
could result in physical injury or property damage! It is your responsibility to assemble,
operate and maintain your gas smoker properly.
READ ALL WARNINGS AND INSTRUCTIONS PRIOR TO ASSEMBLING
AND OPERATING YOUR SMOKER
WARNINGS:
m This smoker is for outdoor use only. It should NOT be used in a building, garage or any other
enclosed area.
m The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability to
properly assemble or safely operate this appliance.
m Do not leave the smoker unattended.
m Keep children and pets away from the smoker at all times.
m Do not use the smoker in high wind.
m Do not use charcoal or lighter fluid.
m Do not use gasoline, kerosene or alcohol for lighting.
m Do not move appliance when in use. Allow the smoker to cool to 115 F° (45 C°) before moving or storing.
m Do not use the smoker unless it is COMPLETELY assembled and all parts are securely fastened and
tightened. If there are any missing or damaged parts, contact customer service for a replacement.
m Do not alter the smoker in any manner.
m This appliance is not intended to be installed in or on a boat or recreational vehicle.
m Locate the smoker away from any combustible or non-combustible materials or construction by at
least 24 inches (61cm) from the back and sides.
m The appliance shall not be used under overhead unprotected combustible construction.
m This appliance is not intended for and should never be used as a heater.
m This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection
from hot surfaces or splatter from cooking liquids.
m This appliance is not intended for commercial use.
m PROPOSITION 65 WARNING: Handling the brass material on this product exposes you to lead,
a chemical known to the state of California to cause cancer, birth defects or other reproductive
harm. (Wash hands after handling this product.)
m This smoker is to be used outdoors only. Do not operate this smoker indoors or in an enclosed
area.
m Do not use this smoker in the rain or on wet surfaces. Do not immerse cord, plug or electric
element in water or other liquids. Keep this smoker and all electrical appliances away from
swimming pools, hot tubs, etc. Hazard of electrical shock if used on a wet surface, in the rain
or if appliance has been exposed to moisture.
m For household use only. Do not use this product for other than its intended purpose.
2
4
5
m To prevent accidental electrical shock, this smoker should always be used on a GFCI (Ground Fault
Circuit Interrupter) outlet or circuit, do not plug this appliance into an indoor circuit.
m Always use a 3-wire grounded outlet wired for 120 volts which is GFCI protected at 15 or 20 amps.
If in doubt, contact a qualified electrician. Do not operate this smoker with any other appliance or
electrical device on the same circuit.
m Always turn the unit “OFF” by unplugging cord from outlet on thermostat when adding water and
wood or when finished cooking.
m Do not use an extension cord unless absolutely necessary. If you must use one, the following care
should be exercised:
a. Use the shortest length possible. Use a 12/3 or 14/3 grounded-type extension cord with a rating
of at least 15 amps.
b. The cord should be marked with suffix letter “W-A” and with a tag stating “Suitable for Use with
Outdoor Appliances”.
c. Keep cord connection dry and off the ground. Appliance and/or extension cord should be placed
in such a manner so it will not be tripped over, tugged on by children or pets. Do not allow cord
to touch hot surfaces.
m Do not operate this smoker if:
a. The cord or plug is damaged.
b. The electric element has been damaged in any manner.
c. The smoker has malfunctioned.
d. The smoker has been exposed to moisture or if grease and drippings were not cleaned from
element after each use. Refer to “Proper Care & Maintenance” section of this manual.
e. There is any damage to the smoker.
f. The GFCI circuit trips when the electric element is plugged into the electric outlet.
m Proper clearance of 5 feet between the smoker and combustible construction should be
maintained at all times when this product is in use.
m In windy weather, this product should be located in an outdoor area that is protected from the wind.
m Do not leave smoker unattended when in use.
m Do not place smoker on or near a gas or electric burner, or a heated oven.
m Do not store or use smoker near gasoline or other flammable liquids, gases or where flammable
vapors may be present.
m Use smoker only on a hard, level, noncombustible, stable surface (concrete, ground, etc.). Never
use smoker on wooden or other surfaces that could burn.
m A drip pan/ash guard will not prevent fires from occurring on a wooden or other combustible
surface. A drip pan/ash guard is designed for use with a smoker for easy clean up of drippings that
can cause discoloration of surface and to catch falling ashes and embers.
m Smoker should be placed in an area where children and pets cannot come into contact with unit.
Close supervision is necessary when this smoker is in use.
m Use caution when reaching into or under smoker. Always wear oven mitts/gloves to protect your
hands from burns. Avoid touching hot surfaces.
m Do not wear loose clothing or allow hair to hang freely when operating smoker.
m Always wear shoes when operating smoker.
m When in operation, smoker contains hot liquid in water pan. Extreme caution should be used at all
times. Do not move smoker when water pan contains hot liquids. Tilting or other slight movement
could cause hot liquid to spill from water pan causing serious bodily injury.
m When opening door, keep hands, face and body safe from hot steam or possible flame flare-ups .
Do not use water to extinguish flames.
m Use extreme caution when adding liquid to water pan being careful not to spill any liquid onto
electric element. Always unplug smoker before adding water. Follow instructions in Step 8 of
“Smoking” section of this manual.
m Water pan should always be used when smoking. Do not allow liquid in water pan to completely
evaporate. Check water pan every 2 hours and add water if level is low (a sizzling sound may
indicate a need for water). Follow instructions in Step 8 of “Smoking” section of this manual.
m Use caution when assembling or operating your smoker to avoid cuts or scrapes from sharp edges
of metal parts.
m Never add charcoal, lighter fluid, fuel or material of any kind, other than flavoring wood to the wood
chip pan.
m Unplug the smoker from electric outlet when not in use. Allow smoker to cool completely before
cleaning. Make sure embers are completely extinguished. Dispose of remaining embers and ashes
in a noncombustible container. Do not allow ashes to build up in smoker.
m Do not use the smoker if the electric element has been exposed to moisture. Do not clean
electric element with a water spray or the like. Failure to adhere to this safety warning could result
in the electric element shorting out and in some cases, exploding. Clean the electric element as
instructed in the “Care and Maintenance” section of this manual.
m Store the smoker indoors in a dry location when not in use-out of the reach of children.
m Accessory attachments not manufactured for use with this smoker are not recommended and may
lead to personal injury or property damage.
m Use caution when lifting or moving smoker to prevent strains and back injuries.
m We advise that you have a fire extinguisher designed for use with electrical appliances on hand.
Refer to your local authority to determine proper size and type of fire extinguisher.
m Do not attempt to service smoker other than normal maintenance as explained in “Care &
Maintenance” section of this manual.
m Properly dispose of all packaging material.
1. Warnings and Safety Instructions (cont.)
Loading...