Cuisinart CGG-240 User Manual
Outdoor Grilling Pro ducts
MODEL: CGG-240
Roll-Away Portable LP Gas Grill
ASSEMBLY AND OPERATING INSTRUCTIONS
m WARNING: FOR OUTDOOR USE ONLY
m This instruction manual contains important information necessary for the
proper assembly and safe use of the appliance
m Read and follow all warnings and instructions before
assembling and using the appliance
m Follow all warnings and instructions when using the appliance
m Keep this manual for future reference
Note to installer: Leave this Owner’s Manual with the consumer after delivery and/or installation.
Note to customer: Leave this Owner’s Manual in a convenient place for future reference.
m DANGER
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
m DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your fire
department.
Failure to follow these instructions could
result in fire, explosion or burn hazard,
which could cause property damage,
personal injury or death.
m DANGER
1. Never operate this appliance unattended.
2. Never operate this appliance within 10 feet (3.05m) of any other gas cylinder.
3. Never operate this appliance with 25 feet (7.5m) of any flammable liquid.
4. lf a fire should occur, keep away from the appliance and immediately call your fire
department . Do not attempt to extinguish an oil or grease fire with water.
5. Heated liquids remain at scalding temperatures long after the cooking process.
Never touch cooking appliance until liquids have cooled to 115oF (45oC) or less.
Failure to follow these instructions could result in fire, explosion or burn hazard,
which could cause property damage, personal injury or death.
1
Table of Contents
1. Warnings and Safety Instructions 3
1. Warnings and Safety Instructions y Instructions
If these instructions are ignored, there is a possibility of a hazardous fire or explosion which
could result in physical injury or property damage! It is your responsibility to assemble,
operate and maintain your gas grill properly.
READ ALL WARNINGS AND INSTRUCTIONS PRIOR TO ASSEMBLING AND
2. Illustrated Parts List 4
3. Exploded View 5
4. Assembly Instructions 6
5. Operating Your Grill
5.1 Select a Proper Location 11
5.2 Special Instructions for the Use of Regulator and Propane Cylinder 12
5.3 Installing the gas cylinder 12
5.4 Checking for Gas Leaks 13
5.5 Lighting Instructions 13
5.6 Match lighting 14
5.7 Using the Grill 14
6. Care and Maintenance 14
7. Frequently Asked Questions 15
8. Troubleshooting 15
9. Warranty Program and Replacement Parts 16
OPERATING YOUR GRILL
WARNINGS:
m This grill is for outdoor use only. It should NOT be used in a building, garage or any other
enclosed area.
m The use of alcohol, prescription or non-prescription drugs may impair an individual’s ability
to properly assemble or safely operate this appliance.
m Do not leave the grill unattended. Keep children and pets away from the grill all the times.
m Do not use the grill in high wind.
m This grill must be used with propane gas only. Liquid propane is not natural gas. The
conversion or attempted use of natural gas in a liquid propane grill is dangerous and will void
your warranty.
m Do not attempt to attach this grill to the self-contained propane system of a camper, trailer,
motor home or house.
m Do not use charcoal or lighter uid.
m Do not use gasoline, kerosene or alcohol for lighting .The LP-gas cylinder must be con-
structed and marked in accordance with the specications for propane gas cylinder of the
U.S. Department of Transportation (DOT).
m Do not attempt to move the grill when in use.
m Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened
and tightened .if there are any missing or damaged parts, contact customer service for a
replacement.
m Do not alter the grill in any manner.
m Do not operate the grill if there is gas leak present.
m The use and installation of this product must conform to local codes. In the absence of
local codes, use the National Fuel Gas Code: ANSI Z223.1/NFPA54, Storage and Handling
of Liqueed Petroleum Gases, ANSI.NFPA 58 or Natural Gas and Propane Installation Code,
CSA B149.1; Propane Storage and Handling, CSA B149.2.
m This appliance is not intended to be installed in or on a boat or recreational vehicle.
m Locate the grill away from any combustible or non-combustible materials or construction by
at least 24 inches (61cm) from the back and sides.
m The appliance shall not be located usdunder overhead unprotected combustible construction.
m When cooking with oil or grease, have a type BC or ABC re extinguisher readily available.In
the event of an oil or grease re do not attempt to extinguish with water. Immediatelycall the re
department. A Type BC or ABC re extinguisher may, in some circumstancescontain the re.
m The appliance shall not be located used under overhead unprotected combustible construction.
m This appliance is not intended for and should never be used as a heater.
m This appliance will be hot during and after use. Use insulated oven mitts or gloves for
protection from hot surfaces or splatter from cooking liquids.
m This appliance is not intended for commercial use.
m The pressure regulator supplied with the Cuisinart Gas Grill must be used.
2
3
2. Illustrated Parts List
A. Grill Body 1 pc
B. Flame Tamer 1 pc
C. Grill Grate 1 pc
D. Drip Tray 1 pc
E. Grill Body Connector Pins 2 pcs
F. Connector Pin Cotter Pins 2 pcs
3. Exploded View
G. Wheel 2 pcs
H. Axle Bolt 2 pcs
I. Axle Bolt Hex Nut 2 pcs
J. Cart Leg Assembly 1 pc
K. Bottom Leg Connector 2 pc
L. Bottom Leg Assembly 1 pc
M. Left Up Tube Assembly 1 pc
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Lid
Flame Tamer
Cooking Grate
Thermometer
Thermometer Bezel
Burner Assembly
Right Side Table
Spring Pad
Rubber Pad
Right Handle Assembly
Regulator
Gas Valve Assembly
Control Panel
Control Knob
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
Rubber Pad
Left Leg Assembly
M6X15 Screw
Leg Spring
Right Leg Tube
Bottom Leg Connector
Foot
Bottom Leg Assembly
M5X10 Screw
Wheel
Axle Bolt Hex Nut
Axle Bolt
Shaft
Bushing
Right Leg Tube
30
31
32
33
34
35
36
37
38
39
40
41
42
43
Left Up Tube Assembly
Drip Tray
Hook
Grill Body Connector Pin
Connector Pin Cotter Pin
Firebox Assembly
Left Handle Assembly
M6 Screw
Left Handle Support
M6 Nut
Left Side Table
Plastic Washer
Wave Washer
Side Table Screw
N. Screw 20 pcs
4 5
Loading...