CTM ETRIKE-LI 24/20 Owner's Manual

12

Phone: [phone]

Fax: [phone]

E-mail: [e-mail]

www.electric-bicycles.com.au

6 KLAUER ST SEAFORD VIC

AUSTRALIA 3198

C H I T U M A A U S T R A L I A P T Y LT D

•

C H IT U M A A U S T R A L I A P T Y L T D

OWNER MANUAL

Da te: 01/01/2015

ETRIKE-LI
24/20

2

Page 2

THANK YOU FOR CHOOSING OUR ELECTRIC ASSISTED
TRICYCLE
OUR E-TRIKE CAN BE OPERATED VERY EASILY.IT CAN
BE OPERATED BY THE MOTOR ALONE OR BY PEDALING
ALONE OR A COMBINATION OF BOTH AT THE SAME
TIME.IN ORDER TO GIVE YOU A LONG AND SAFE US­AGE PLEASE READ THE INSTRUCTIONS BEFORE USING.

SAFTEY CHECK BEFORE RIDING

YOUR

BICYCLE

1.CHECK AND TIGHTEN ALL NUTS ,BOLTS,
STRAPS
AND FASTENERS

2.CHECK THAT BRAKES OPERATE CORRECTLY

3.CHECK TYRES FOR WEAR, DAMAGE AND
CORRECT PRESSURES.PRESSURES ARE USUALY
WRITTEN ON TYRE WALLS.

4.CHECK WHEELS FOR TRUENESS

5.CHECK LIGHTS FOR OPERATION AND AD­JUSTMENT

6.CHECK AUDIABLE WARNING DEVICE [BELL
OR HORN

ALWAYS WEAR AN APPROVED

BICYCLE HELMET AND OBEY THE

ROAD RULES AT ALL TIMES

11

10

3

Page 3

YOUR TRICYCLE IS DESIGNED FOR USE
ONLY ON PAVED ROADS OR PATHS
(WHERE THE LAWS PERMIT)
DO NOT USE OFF THESE SURFACES
OPERATION

PERFORM SAFTEY CHECKS AND ADJUST SEAT
FOR COMFORTABLE RIDING
THE ROCKER SWITCH ON THROTTLE HANDLE
TURNS THE MOTOR ON OR OFF
SQUEEZE LEFT HAND BRAKE AND ALIGHT TRIKE
FROM SAME SIDE
POSITION YOUR SELF ON TRIKE WITH BOTH FEET
ON THE PEDALS NOT ON THE GROUND. USE
HANDBRAKE TO MAINTAIN A STATIONARY POSI­TION
YOUR TRIKE IS NOW READY TO GO.YOU MAY
EITHER PEDAL OR BY TWISTING THE R/HAND GRIP
BACK
TOWARDS YOU USE THE ELECTRIC MOTOR.THE
FURTHER YOU TWIST THE FASTER YOU WILL
TRAVEL
APPLYING EITHER HANDBRAKE WILL CUT MOTOR
POWER AUTOMATICALLY.
TRIKES REQUIRE YOU TO TURN HANDLE BAR
MUCH MORE THAN A 2WHEEL BIKE AND REQUIRE
YOU TO MANUALLY TURN THE HANDLE BAR BACK
TO THE STRAIGHT AHEAD POSITION OTHERWISE
YOU WILL KEEP TRAVELLING IN CIRCLES

4

Page 4

CHARGING

YOU MUST ONLY USE THE CHARGER THAT WE
SUPPLY WITH TRICYCLE

ONLY USE IN A DRY WELL VENTILATED
ENVIROMENT .

WITH THE LEAD UNPLUGGED FROM 240V POWER SUPPLY PLUG
INTO POINT LOCATED ON RIGHTHAND SIDE OF BATTERY ..PLUG
INTO STANDARD 240V HOUSE HOLD POWER SUPPLY AND SWITCH
ON.YOU WILL SEE A RED LIGHT ON CHARGER ,THIS INDICATES THE
UNIT IS ON AND CHARGING THE BATTERY.WHEN CHARGED LIGHT
WILL CHANGE TO GREEN AND CHARGER WILL SWITCH AND GO
INTO MAINTENANCE MODE.I T IS ALRIGHT TO LEAVE IT IN THIS
MODE FOR A SHORT PERIOD OF TIME BUT WE RECOMMEND THAT
YOU TURN IT OFF AND UNPLUG FROM POWER POINT AND BIKE
AFTER 12 HOURS

REMEMBER ALWAYS SWITCH OFF AT POWER POINT BEFORE
PLUGING OR UNPLUGING FROM TRICYCLE

MAXIMUN BATTERY LIFE WILL BE ACHIEVED BY CHARGING EVERY
DAY AFTER BEING USED . BATTERIES LEFT IN A SEMI DISCHARGED
STATE COULD PREMATURALLY FAIL.

Operation of TILT feature

This trike is fitted with a unique feature
which allows you to lean into corners or
lean on uneven sloping paths as you can
on a 2 wheeled bike but with the ability
to lock into fixed position when extra
balance is required by simply moving
the lever located on gooseneck forward
to lock or back to release.

When locking the tilt feature, some
slight left or right movement may be
needed for the lock to catch.

9

8

5

OPERATING INSTRUCTIONS FOR MOTOR

ASSISTANCE

After completing safety check insert key into battery and turn
clockwise .
Making sure tilt mechanism is in locked position alight tricycle
and place both feet on pedals.

Press the on/off switch
on display (located left
side handlebar).
Battery level indicator
LEDs will light up and
mode LEDs will light.
Press mode button to
set level of pedal assist
required. One light is

least, three is highest.
Release handbrake and slowly twist throttle towards you by
dropping your wrist backwards. The further you twist the
faster you will go. You may also simply pedal away and allow
the pedal assist feature to cut in motor as you pedal.

If you wish to corner slightly faster or are riding on a sideways
sloping path you may use tilt lever to make easier. Only use
tilt lever if you have good balance or you can ride a bicycle.

6

PERIODIC MAINTENANCE

ITEM 500klms 1000klms 1500klms 2000klms
3000klms

BRAKES A A A A
ALL CABLES L I L I
CHAIN L I I L I
TYRES I I I I
FRONT FORKS L I I L I I
PEDAL ASSYS I I I I
ALL NUTS BOLTS
FASTENERS ETC I I I I

A = ADJUST L= LUBRICATE I = INSPECT FOR WEAR ,TIGHTNESS AND
CONDITION

PLEASE NOTE THE ABOVE MAINTENANCE IS A SUGGESTED MINIMUMN
AND IS NOT IN PLACE OF DAILY SAFTEY CHECKS PRIOR TO RIDING

FOR ADVICE ON BRAKE ADJUSTMENT CHECK WITH YOUR DEALER OR
LOCAL BIKE SHOP

7

Page 7

SPECIFICATIONS