12
Phone: 61 03 97863982
Fax: 61 03 97852347
E-mail:ebike@optusnet.com.au
3/6 KLAUER ST
SEAFORD
VICTORIA
3198
chituma australia pty ltd
1
chituma australia pty ltd
OWNERS
MANUAL
COLT series V
IMPORTANT
PLEASE READ THIS MANUAL BEFORE USING YOUR
ELECTRIC BICYCLE
2
Page 2
THANK YOU FOR CHOOSING OUR ELECTRIC ASSISTED BICYCLE
OUR EBIKE CAN BE OPERATED VERY EASILY.IT CAN BE OPERATED BY THE MOTOR ALONE OR BY PEDALING ALONE OR A
COMBINATION OF BOTH AT THE SAME TIME.IN ORDER TO GIVE
YOU A LONG AND SAFE USAGE PLEASE READ THE INSTRUCTIONS BEFORE USING.
ALWAYS WEAR AN APPROVED BICYCLE
HELMET AND OBEY THE ROAD RULES
SAFTEY CHECK BEFORE RIDING YOU BICYCLE
1.CHECK AND TIGHTEN ALL NUTS ,BOLTS, STRAPS
AND FASTENERS
2.CHECK THAT BRAKES OPERATE CORRECTLY
3.CHECK TYRES FOR WEAR, DAMAGE AND CORRECT
PRESSURES.PRESSURES ARE USUALY WRITTEN ON
TYRE WALLS.
4.CHECK WHEELS FOR TRUENESS
5.CHECK LIGHTS FOR OPERATION AND ADJUSTMENT
6.CHECK AUDIABLE WARNING DEVICE [BELL OR
HORN
7.CHECK HANDLE BARS AND SEAT MAKING SURE
THEY ARE CORRECTLY ALIGHNED AND CANT TWIST
OR TURN
11
FIRST SERVICE DUE 21/09/2015 RING PRIOR TO BOOK IN
COMPLETED ___/___/____
A COMPLEMENTORY FREE SERVICE IS AVAILABLE WITHIN 30 DAYS OF PURCHASE
3 MONTH SERVICE DUE __/__/____
6 MONTH SERVICE DUE __/__/____
9 MONTH SERVICE DUE __/__/____
12 MONTH SERVICE DUE __/__/____
SERVICE DUE __/__/____
10
NOTES
3
chituma australia pty ltd Page 3
ASSEMBLY
FULL INSTRUCIONS IN ASSY MAN
IF YOU BICYCLE COMES IN A BOX IT MAY NEED SOME MINOR ASSEMBLEY SUCH
AS ATTACHING FRONT WHEEL,PEDALS,MIRRORS,BASKETS AND ALIGNING SEATS
AND HANDLE BARS.YOU SHOULD ALWAYS USE AND CONSULT A QUALIFIED BICYCLE MECHANIC TO DO THIS,
IF IT COMES FULLY ASSEMBLED CHECK ALL FASTENINGS AND FITTINGS FOR
TIGHTNESS AND ALIGHNMENT,ONCE AGAIN USE AND CONSULT A QUALIFIED
BICYCLE MECHANIC.
FRONT WHEEL SHOULD BE ATTACHED AFTER FIRST FITTING BRAKE ASSEMBLY
INSIDE HUB
ALWAYS TURN ON THE POWER VIA THE KEY EVEN IF YOU ONLY INTEND TO PEDAL
MANUALLY.
ALWAYS TURN ON THE LIGHTS IF RIDING AT NIGHT.
ALWAYS WEAR AN APROVED HELMET AND OBEY ALL ROAD RULES
YOU CAN EITHER MOVE OFF BY PEDALING OR BY GRADUALLY AND SMOOTHLY
ROTATING THE THROTTLE GRIP ON THE RIGHT HANDLEBAR.THE MORE YOU ROTATE THE FASTER YOU CAN GO.IF YOU HOLD BRAKE LEVER NO POWER WILL BE
TRANSMITTED TO THE MOTOR.
The instrument panel shows speed ,distance and battery
volts as well as indicator and hlamp warning lamps
OPERATING INSTRUCTIONS
4
Page 4
BRAKE ADJUSTMENT
FRONT BRAKES ARE ADJUSTED BY
ROTATING THE NUT ON CABLE END
ROD UNTILL THE WHEEL JUST BINDS
AND BACKING OFF 1 TO1 1/2 TURNS
THEN APPLY BRAKES SEVERAL TIMES
AND RECHECK AND RE ADJUST IF
NEEDED
REMEMBER CHECK BRAKE OPERATION EVERY TIME
BEFORE RIDING AND INSPECT CABLES AND PADS ETC
AT LEAST ONCE EVERY MONTH
9
8
chituma australia pty ltd
SPECIFICATIONS
MODEL SORRENTO LS SERIES III
MOTOR TYPE BRUSHLESS HI TORQUE HUB MOTOR
POWER 200WATT
BATTERY 48VOLT [4 X 12V 14AH IN SERIES]
RECHARGE TIMES 300 TO 400 TIMES
RECHARGE PERIOD 3-8 HRS DEPENDING ON USAGE
RANGE <40-50KLMS WITH INTELLIGENT ASSISTANCE
SPEED <25-30KPH
WHEELS 18in
TYRES 18in X 2.50in PNUEMATIC WITH TUBES
WEIGHT 45KGS
LOAD 110KGS
PERIODIC MAINTENANCE
ITEM 500klms 1000klms 2000klms 3000klms
BRAKES A I A I
ALL CABLES L I L I
CHAIN L I I L I
TYRES I I I I
FRONT FORKS L I I L I I
PEDAL ASSYS I I I I
ALL NUTS BOLTS
FASTENERS ETC I I I I
A = ADJUST L= LUBRICATE I = INSPECT FOR WEAR ,TIGHTNESS AND CONDITION
PLEASE NOTE THE ABOVE MAINTENANCE IS A SUGGESTED MINIMUMN AND IS NOT
IN PLACE OF DAILY SAFTEY CHECKS PRIOR TO RIDING
CHARGING BATTERIES
ALWAYS ONLY USE THE CHAR GER SUPPLIED DO NOT USE AUTOMOT IVE TYPE TRICKLE
CHARGERS AS OVER HEATING,DAMA GE AND POSSIBLE EXPLOSION CAN OCCUR
NEVER ALLOW CHARGER TO BE WET .ALWAYS USE UNDERCOVER AND IN WELL VENTI LLATED
AREAS
ALWAYS CONNECT CHARGER TO BI CYCLE BEFORE PLUGGING IN TO POWER OUTLET
ALWAYS SWITCH OFF AND UNP LUG FROM POWER OUTLET BEFO RE UNPLUGGING FROM
BICYCLE
NEVER LEAVE ON FOR OVER 24H RS
STATUS LIGHT ON CHARGER WI LL CHANGE TO GREEN WHEN BAT TERY IS FULLY CHARGED
IF THIS TAKES MORE THAN 24 HRS DISCONNECT AND CONSU LT SUPPLIER
5
chituma australia pty ltd Page 5
SWITCHES
CHARGE POINT AND FUSE FOUND UNDER SEAT AREA
CHARGING BATTERIES
ALWAYS ONLY USE THE CHAR GER SUPPLIED DO NOT USE AUTOMOT IVE TYPE TRICKLE
CHARGERS AS OVER HEATING,DAMA GE AND POSSIBLE EXPLOSION CAN OCCUR
NEVER ALLOW CHARGER TO BE WET .ALWAYS USE UNDERCOVER AND IN WELL VENTI LLATED
AREAS
ALWAYS CONNECT CHARGER TO BI CYCLE BEFORE PLUGGING IN TO POWER OUTLET
ALWAYS SWITCH OFF AND UNP LUG FROM POWER OUTLET BEFO RE UNPLUGGING FROM
BICYCLE
NEVER LEAVE ON FOR OVER 24H RS
STATUS LIGHT ON CHARGER WI LL CHANGE TO GREEN WHEN BAT TERY IS FULLY CHARGED
IF THIS TAKES MORE THAN 24 HRS DISCONNECT AND CONSU LT SUPPLIER
6
THE ALARM SYSTEM ON YOUR SORRENTO LS series .
THE ALARM IS REMOTE CONTROL WITH A REAR WHEEL
IMMOBILIZER.WHEN SET ANY ATTEMPT TO MOVE THE BIKE WILL
RESULT IN SIREN SOUNDING AND THE REAR WHEEL BEING
ELECTRONICALLY LOCKED.
1. ALARM ON
2. ALARM OFF
3. PANIC ALARM
4. PRESS QUICKLY TWICE FOR KEYLESS START
Press either alarm on or off to switch off keyless start
ALARM SYSTEMS
KEYS
ON/OFF , SEAT AND
FRONT COMPARTMENT KEY
REAR BRAKE LOCK
KEY WITH LIGHT
7
Page 7
Loading...