CRC 03150 User Manual

Download

Page 1

SAFETY DATA SHEET

www.crcindustries.com

with adequate ventilation. Open doors and windows or use other means to ensure a fresh air

well-ventilated area. Wear eye/face protection. Wear protective gloves. Avoid release to the

1. Identification

Contact Cleaner 2000® Precision Cleaner - 13 ozProduct identifier

Other means of identification

Product Code

Recommended use

Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

Manufactured or sold by:

Company name

Address

Telephone

General Information

Technical Assistance

Customer Service

24-Hour Emergency (CHEMTREC)

Website

No. 03150 (Item# 1003419)

Precision electronics cleaner

None known.

CRC Industries, Inc.

885 Louis Dr.

Warminster, PA 18974 US

215-674-4300

800-521-3168

800-272-4620

800-424-9300 (US)

2. Hazard(s) identification

Physical hazards

Health hazards

Environmental hazards

OSHA defined hazards

Label elements

Signal word

Hazard statement

Precautionary statement

Prevention

Category 2Flammable aerosols

Compressed gasGases under pressure

Category 4Acute toxicity, oral

Category 2Skin corrosion/irritation

Category 2Serious eye damage/eye irritation

Category 3 narcotic effectsSpecific target organ toxicity, single exposure

Category 1Aspiration hazard

Category 3Hazardous to the aquatic environment,

long-term hazard

Not classified.

Danger

Flammable aerosol. Contains gas under pressure; may explode if heated. Harmful if swallowed. May be fatal if swallowed and enters airways. Causes skin irritation. Causes serious eye irritation. May cause drowsiness or dizziness. Harmful to aquatic life with long lasting effects.

Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn, even after use. Use

supply during use and while product is drying. If you experience any symptoms listed on this label, increase ventilation or leave the area. Avoid breathing mist or vapor. Wash hands thoroughly after handling. Do not eat, drink or smoke when using this product. Use only outdoors or in a

environment.

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

SDS US

1 / 10

Page 2

Response

CAS number

Chemical name

Common name and synonyms

water to prevent vapor pressure build up.

Storage

Disposal

Hazard(s) not otherwise classified (HNOC)

Supplemental information

If swallowed: Immediately call a poison center/doctor. Rinse mouth. Do NOT induce vomiting. If on skin: Wash with plenty of water. If skin irritation occurs: Get medical advice/attention. Take off contaminated clothing and wash before reuse. If inhaled: Remove person to fresh air and keep comfortable for breathing. Call a poison center/doctor if you feel unwell. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical attention.

Store in a well-ventilated place. Keep container tightly closed. Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50°C/122°F. Exposure to high temperature may cause can to burst.

Dispose of contents/container in accordance with local/regional/national regulations.

None known.

When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen fluoride, hydrogen chloride, and possibly phosgene.

3. Composition/information on ingredients

Mixtures

156-60-5trans-1,2-dichloroethylene 50 - 60

138495-42-8decafluoropentane 5 - 10

124-38-9carbon dioxide 3 - 5

67-56-1methanol < 0.1

Specific chemical identity and/or percentage of composition has been withheld as a trade secret.

4. First-aid measures

Inhalation

Skin contact

Eye contact

Ingestion

Most important symptoms/effects, acute and delayed

Indication of immediate medical attention and special treatment needed

General information

5. Fire-fighting measures

Suitable extinguishing media

Unsuitable extinguishing media

Specific hazards arising from the chemical

Special protective equipment and precautions for firefighters

Fire-fighting equipment/instructions

General fire hazards

Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a poison center or doctor/physician if you feel unwell.

Remove contaminated clothing. Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention. Wash contaminated clothing before reuse.

Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.

Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If vomiting occurs, keep head low so that stomach content doesn't get into the lungs.

Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness or dizziness. Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Skin irritation. May cause redness and pain.

Provide general supportive measures and treat symptomatically. Keep victim warm. Keep victim under observation. Symptoms may be delayed.

Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves.

Foam. Powder. Carbon dioxide (CO2). Use fire-extinguishing media appropriate for surrounding materials.

Do not use water jet as an extinguisher, as this will spread the fire.

Contents under pressure. Pressurized container may rupture when exposed to heat or flame. When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen fluoride, hydrogen chloride, and possibly phosgene.

Firefighters must use standard protective equipment including flame retardant coat, helmet with face shield, gloves, rubber boots, and in enclosed spaces, SCBA.

Move containers from fire area if you can do so without risk. Containers should be cooled with

Flammable aerosol.

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

SDS US

2 / 10

Page 3

6. Accidental release measures

waste disposal, see section 13 of the SDS.

while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or

well-ventilated areas. Wear appropriate personal protective equipment. When using, do not eat,

US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)

US. ACGIH Threshold Limit Values

Personal precautions, protective equipment and emergency procedures

Methods and materials for containment and cleaning up

Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Wear appropriate protective equipment and clothing during clean-up. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Avoid inhalation of vapors or mists. Avoid breathing gas. Ventilate closed spaces before entering them. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS.

Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep combustibles (wood, paper, oil, etc.) away from spilled material. This product is miscible in water. Stop the flow of material, if this is without risk. Collect spillage. Dike far ahead of spill for later disposal. Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Prevent entry into waterways, sewer, basements or confined areas. For

Environmental precautions

Avoid release to the environment. Contact local authorities in case of spillage to drain/aquatic environment. Prevent further leakage or spillage if safe to do so. Do not contaminate water. Avoid discharge into drains, water courses or onto the ground. Use appropriate containment to avoid environmental contamination.

7. Handling and storage

Precautions for safe handling

Conditions for safe storage, including any incompatibilities

Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke

expose containers to heat, flame, sparks, or other sources of ignition. Use caution around energized equipment. The metal container will conduct electricity if it contacts a live source. This may result in injury to the user from electrical shock and/or flash fire. Do not taste or swallow. Avoid breathing mist or vapor. Avoid contact with eyes. Avoid prolonged exposure. Use only in

drink or smoke. Wash hands thoroughly after handling. Observe good industrial hygiene practices. Avoid release to the environment. Do not empty into drains. For product usage instructions, see the product label.

Level 1 Aerosol.

Pressurized container. Protect from sunlight and do not expose to temperatures exceeding 50 °C/122 °F. Do not puncture, incinerate or crush. Do not handle or store near an open flame, heat or other sources of ignition. This material can accumulate static charge which may cause spark and become an ignition source. Store away from incompatible materials (see Section 10 of the SDS).

8. Exposure controls/personal protection

Occupational exposure limits

PEL 9000 mg/m3carbon dioxide (CAS

124-38-9)

PEL 260 mg/m3methanol (CAS 67-56-1)

PEL 790 mg/m3trans-1,2-dichloroethylene

(CAS 156-60-5)

STEL 30000 ppmcarbon dioxide (CAS

124-38-9)

TWA 5000 ppm

STEL 250 ppmmethanol (CAS 67-56-1)

TWA 200 ppm

TWA 200 ppmtrans-1,2-dichloroethylene

(CAS 156-60-5)

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

ValueComponents Type

5000 ppm

200 ppm

ValueComponents Type

SDS US

3 / 10

Page 4

US. NIOSH: Pocket Guide to Chemical Hazards

124-38-9)

ACGIH Biological Exposure Indices

(CAS 156-60-5)

Biological limit values

ValueComponents Type

STEL 54000 mg/m3carbon dioxide (CAS

30000 ppm

TWA 9000 mg/m3

5000 ppm

STEL 325 mg/m3methanol (CAS 67-56-1)

250 ppm

TWA 260 mg/m3

200 ppm

TWA 790 mg/m3trans-1,2-dichloroethylene

200 ppm

ValueComponents Determinant Specimen Sampling Time

methanol (CAS 67-56-1)

15 mg/l Methanol Urine

* - For sampling details, please see the source document.

Exposure guidelines

US - California OELs: Skin designation

methanol (CAS 67-56-1) Can be absorbed through the skin.

US - Minnesota Haz Subs: Skin designation applies

methanol (CAS 67-56-1) Skin designation applies.

US - Tennessee OELs: Skin designation

methanol (CAS 67-56-1) Can be absorbed through the skin.

US ACGIH Threshold Limit Values: Skin designation

methanol (CAS 67-56-1) Can be absorbed through the skin.

US NIOSH Pocket Guide to Chemical Hazards: Skin designation

methanol (CAS 67-56-1) Can be absorbed through the skin.

Appropriate engineering controls

Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. Provide eyewash station.

Individual protection measures, such as personal protective equipment

Eye/face protection

Wear safety glasses with side shields (or goggles).

Skin protection

Hand protection

Other

Respiratory protection

Wear protective gloves such as: Nitrile. Neoprene. Polyvinyl alcohol (PVA). Viton/butyl.

Wear appropriate chemical resistant clothing.

If engineering controls are not feasible or if exposure exceeds the applicable exposure limits, use a NIOSH-approved cartridge respirator with an organic vapor cartridge. Use a self-contained breathing apparatus in confined spaces and for emergencies. Air monitoring is needed to determine actual employee exposure levels.

Thermal hazards

General hygiene considerations

Wear appropriate thermal protective clothing, when necessary.

When using do not smoke. Keep away from food and drink. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants.

9. Physical and chemical properties

Appearance

Physical state

Form

Color

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

Liquid.

Aerosol.

Clear. Colorless.

SDS US

4 / 10

Page 5

Odor

Skin contact

Eye contact

toxicological characteristics

Odor threshold

Melting point/freezing point

Initial boiling point and boiling

Slight ethereal.

Not available.

-119.2 °F (-84 °C) estimated

104.2 °F (40.1 °C) estimated

range

Flash point

Evaporation rate

Flammability (solid, gas)

None.

Fast.

Not available.

Upper/lower flammability or explosive limits

Flammability limit - lower

2 % estimated

(%)

Flammability limit - upper

19.9 % estimated

(%)

Vapor pressure

Vapor density

Relative density

3248.6 hPa estimated

> 1 (air = 1)

1.27 estimated

Solubility(ies)

Solubility (water)

Partition coefficient

Slight.

Not available.

(n-octanol/water)

Auto-ignition temperature

Decomposition temperature

Percent volatile

860 °F (460 °C) estimated

Not available.

95 % estimated

10. Stability and reactivity

Reactivity

Chemical stability

Possibility of hazardous reactions

Conditions to avoid

Incompatible materials

Hazardous decomposition products

The product is stable and non-reactive under normal conditions of use, storage and transport.

Material is stable under normal conditions.

No dangerous reaction known under conditions of normal use.

Heat, flames and sparks. When exposed to extreme heat or hot surfaces, vapors may decompose to harmful or fatal corrosive gases such as hydrogen fluoride, hydrogen chloride, and possibly phosgene. Contact with incompatible materials.

Strong oxidizing agents. Aluminum.

Carbonyl halides. Hydrogen fluoride. Hydrogen chloride. Phosgene. Formaldehyde. Carbon oxides.

11. Toxicological information

Information on likely routes of exposure

Inhalation

Ingestion

Symptoms related to the physical, chemical and

May cause drowsiness and dizziness. Headache. Nausea, vomiting. Prolonged inhalation may be harmful.

Causes skin irritation.

Causes serious eye irritation.

Harmful if swallowed. May be fatal if swallowed and enters airways. Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious chemical pneumonia.

Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Skin irritation. May cause redness and pain.

Information on toxicological effects

Acute toxicity

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

May be fatal if swallowed and enters airways. In high concentrations, vapors are anesthetic and may cause headache, fatigue, dizziness and central nervous system effects.

SDS US

5 / 10

Page 6

1,1,1,3,3-pentafluorobutane (CAS 406-58-6)

Respiratory sensitization

Carcinogenicity

Aspiration hazard

Chronic effects

Acute

Oral

LD50 Rat > 2000 mg/kg

methanol (CAS 67-56-1)

Acute

Dermal

LD50 Rabbit 12800 mg/kg

Oral

LD50 Rat 5628 mg/kg

trans-1,2-dichloroethylene (CAS 156-60-5)

Acute

Oral

LD50 Rat 1235 mg/kg

* Estimates for product may be based on additional component data not shown.

Skin corrosion/irritation

Serious eye damage/eye

Causes skin irritation.

Causes serious eye irritation.

irritation

Respiratory or skin sensitization

Not a respiratory sensitizer.

Skin sensitization

Germ cell mutagenicity

This product is not expected to cause skin sensitization.

No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic.

This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.

IARC Monographs. Overall Evaluation of Carcinogenicity

Not listed.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

Not regulated.

US. National Toxicology Program (NTP) Report on Carcinogens

Not listed.

Reproductive toxicity

Specific target organ toxicity -

This product is not expected to cause reproductive or developmental effects.

May cause drowsiness and dizziness.

single exposure

Specific target organ toxicity -

Not classified.

repeated exposure

May be fatal if swallowed and enters airways.

Prolonged inhalation may be harmful.

Test ResultsComponents Species

12. Ecological information

Ecotoxicity

Components Test ResultsSpecies

methanol (CAS 67-56-1)

Aquatic

trans-1,2-dichloroethylene (CAS 156-60-5)

Aquatic

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

Harmful to aquatic life with long lasting effects.

EC50Crustacea > 10000 mg/l, 48 hoursWater flea (Daphnia magna)

LC50Fish > 100 mg/l, 96 hoursFathead minnow (Pimephales promelas)

LC50Fish 120 - 160 mg/l, 96 hoursBluegill (Lepomis macrochirus)

SDS US

6 / 10

Page 7

Components Test ResultsSpecies

Acute

Partition coefficient n-octanol / water (log Kow)

EC50Crustacea 220 mg/l, 48 hoursWater flea (Daphnia magna)

* Estimates for product may be based on additional component data not shown.

Persistence and degradability

Bioaccumulative potential

No data is available on the degradability of this product.

No data available.

methanol -0.77 trans-1,2-dichloroethylene 2.06

Mobility in soil

Other adverse effects

No data available.

The product contains volatile organic compounds which have a photochemical ozone creation potential.

13. Disposal considerations

Hazardous waste code

Disposal instructions

Contaminated packaging

Not regulated.

The dispensed liquid product is not a RCRA hazardous waste (See 40 CFR Part 261.20 - 261.33). Empty container can be recycled. Consult authorities before disposal. Contents under pressure. Do not puncture, incinerate or crush. Do not allow this material to drain into sewers/water supplies. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose in accordance with all applicable regulations.

Empty containers should be taken to an approved waste handling site for recycling or disposal. Since emptied containers may retain product residue, follow label warnings even after container is emptied.

14. Transport information

DOT

UN number UN proper shipping name Transport hazard class(es)

Class Subsidiary risk

Label(s) Packing group Special precautions for user Special provisions Packaging exceptions Packaging non bulk Packaging bulk

IATA

UN number UN proper shipping name Transport hazard class(es)

Class

Subsidiary risk Packing group ERG Code Special precautions for user Other information

Passenger and cargo

aircraft

Cargo aircraft only

IMDG

UN number UN proper shipping name Transport hazard class(es)

Class

Subsidiary risk Packing group

UN1950 Aerosols, flammable, Limited Quantity

2.1

2.1 Not applicable. Read safety instructions, SDS and emergency procedures before handling. N82 306 None None

UN1950 Aerosols, flammable, Limited Quantity

2.1

Not applicable. 10L Read safety instructions, SDS and emergency procedures before handling.

Allowed with restrictions.

UN1950 AEROSOLS, Limited Quantity

2.1

Not applicable.

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

SDS US

7 / 10

Page 8

Environmental hazards

Marine pollutant EmS Special precautions for user

DOT; IMDG

IATA

No. Not available. Read safety instructions, SDS and emergency procedures before handling.

15. Regulatory information

US federal regulations

TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)

decafluoropentane (CAS 138495-42-8) 1.0 % One-Time Export Notification only.

SARA 304 Emergency release notification

Not regulated.

OSHA Specifically Regulated Substances (29 CFR 1910.1001-1052)

Not regulated.

US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance

methanol (CAS 67-56-1)

CERCLA Hazardous Substance List (40 CFR 302.4)

methanol (CAS 67-56-1) trans-1,2-dichloroethylene (CAS 156-60-5)

CERCLA Hazardous Substances: Reportable quantity

methanol (CAS 67-56-1) 5000 LBS trans-1,2-dichloroethylene (CAS 156-60-5) 1000 LBS

Spills or releases resulting in the loss of any ingredient at or above its RQ require immediate notification to the National

Response Center (800-424-8802) and to your Local Emergency Planning Committee.

Other federal regulations

Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List

methanol (CAS 67-56-1)

Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)

Not regulated.

Safe Drinking Water Act (SDWA)

Food and Drug Administration (FDA)

This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200.

Not regulated.

Material name: Contact Cleaner 2000® Precision Cleaner - 13 oz

No. 03150 (Item# 1003419) Version #: 01 Issue date: 11-20-2019

SDS US

8 / 10

Page 9

Superfund Amendments and Reauthorization Act of 1986 (SARA)

Not listed.

Classified hazard