SAFETY DATA SHEET
www.crcindustries.com
Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May be fatal if
1. Identification
Product identifier Heavy Duty Degreaser II
Other means of identification
Product code
Recommended use
Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Manufactured or sold by:
Company name
Address
Telephone
General Information
Technical
Assistance
Customer Service
24-Hour Emergency
(CHEMTREC)
Website
03120
General purpose degreaser
None known.
CRC Industries, Inc.
885 Louis Dr.
Warminster, PA 18974 US
215-674-4300
800-521-3168
800-272-4620
800-424-9300 (US)
703-527-3887 (International)
2. Hazard(s) identification
Physical hazards
Health hazards
Environmental hazards
OSHA defined hazards
Label elements
Signal word
Hazard statement
Precautionary statement
Prevention
Category 1Flammable aerosols
Compressed gasGases under pressure
Category 2Skin corrosion/irritation
Category 2ASerious eye damage/eye irritation
Category 3 narcotic effectsSpecific target organ toxicity, single exposure
Category 1Aspiration hazard
Not classified.
Not classified.
Danger
swallowed and enters airways. Causes skin irritation. Causes serious eye irritation. May cause
drowsiness or dizziness.
Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open
flame or other ignition source. Do not apply while equipment is energized. Pressurized container:
Do not pierce or burn, even after use. Extinguish all flames, pilot lights and heaters. Vapors will
accumulate readily and may ignite. Use only with adequate ventilation; maintain ventilation during
use and until all vapors are gone. Open doors and windows or use other means to ensure a fresh
air supply during use and while product is drying. If you experience any symptoms listed on this
label, increase ventilation or leave the area. Avoid breathing mist or vapor. Avoid breathing gas.
Wash thoroughly after handling. Wear protective gloves. Wear eye/face protection.
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
1 / 9
Response
with plenty of water. If skin irritation occurs: Get medical attention. Take off contaminated clothing
Storage
Disposal
Hazard(s) not otherwise
classified (HNOC)
If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If on skin: Wash
and wash before reuse. If inhaled: Remove person to fresh air and keep comfortable for
breathing. Call a poison center/doctor if you feel unwell. If in eyes: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye
irritation persists: Get medical attention.
Store in a well-ventilated place. Store locked up. Protect from sunlight. Do not expose to
temperatures exceeding 50°C/122°F. Exposure to high temperature may cause can to burst.
Dispose of contents/container in accordance with local/regional/national regulations.
None known.
3. Composition/information on ingredients
Mixtures
CAS number %Chemical name Common name and synonyms
64742-47-8Distillates (petroleum), hydrotreated
light
29911-27-1Dipropylene glycol monopropyl
ether (dpmp)
88917-22-0Dipropylene glycol monomethyl
ether acetate
124-38-9Carbon dioxide
Specific chemical identity and/or percentage of composition has been withheld as a trade secret.
50 - 60
20 - 30
5 - 10
3 - 5
4. First-aid measures
Inhalation
Skin contact
Eye contact
Ingestion
Most important
symptoms/effects, acute and
delayed
Indication of immediate
medical attention and special
treatment needed
General information
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Specific hazards arising from
the chemical
Special protective equipment
and precautions for firefighters
Fire-fighting
equipment/instructions
General fire hazards
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Oxygen or
artificial respiration if needed. Call a POISON CENTER or doctor/physician if you feel unwell.
Remove contaminated clothing. Rinse skin with water/shower. If skin irritation occurs: Get medical
advice/attention. Wash contaminated clothing before reuse.
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If
vomiting occurs, keep head low so that stomach content doesn't get into the lungs.
Diarrhea. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Irritation of nose
and throat. Aspiration may cause pulmonary edema and pneumonitis. Severe eye irritation.
Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Skin irritation. May
cause redness and pain.
Provide general supportive measures and treat symptomatically. Keep victim warm. Keep victim
under observation. Symptoms may be delayed.
Ensure that medical personnel are aware of the material(s) involved, and take precautions to
protect themselves.
Alcohol resistant foam. Water fog. Dry chemical powder. Dry chemicals. Carbon dioxide (CO2).
None known.
Contents under pressure. Pressurized container may explode when exposed to heat or flame.
During fire, gases hazardous to health may be formed.
Firefighters must use standard protective equipment including flame retardant coat, helmet with
face shield, gloves, rubber boots, and in enclosed spaces, SCBA.
In case of fire: Stop leak if safe to do so. Move containers from fire area if you can do so without
risk. Cool containers exposed to heat with water spray and remove container, if no risk is involved.
Containers should be cooled with water to prevent vapor pressure build up.
Extremely flammable aerosol. Contents under pressure. Pressurized container may explode when
exposed to heat or flame.
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
2 / 9
6. Accidental release measures
wearing appropriate protective clothing. Ventilate closed spaces before entering them. Local
while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind, or
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
US. ACGIH Threshold Limit Values
US. NIOSH: Pocket Guide to Chemical Hazards
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
Environmental precautions
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of
low areas. Many gases are heavier than air and will spread along ground and collect in low or
confined areas (sewers, basements, tanks). Wear appropriate protective equipment and clothing
during clean-up. Avoid breathing mist or vapor. Avoid breathing gas. Emergency personnel need
self-contained breathing equipment. Do not touch damaged containers or spilled material unless
authorities should be advised if significant spillages cannot be contained. For personal protection,
see section 8 of the SDS.
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep
combustibles (wood, paper, oil, etc.) away from spilled material. This product is miscible in water.
Stop the flow of material, if this is without risk. Wipe up with absorbent material (e.g. cloth, fleece).
Clean surface thoroughly to remove residual contamination. For waste disposal, see section 13 of
the SDS. Prevent entry into waterways, sewer, basements or confined areas.
Avoid discharge into drains, water courses or onto the ground.
7. Handling and storage
Precautions for safe handling
Conditions for safe storage,
including any incompatibilities
Pressurized container: Do not pierce or burn, even after use. Do not use if spray button is missing
or defective. Do not spray on a naked flame or any other incandescent material. Do not smoke
expose containers to heat, flame, sparks, or other sources of ignition. Use caution around
energized equipment. The metal container will conduct electricity if it contacts a live source. This
may result in injury to the user from electrical shock and/or flash fire. Avoid breathing mist or
vapor. Avoid breathing gas. Avoid contact with eyes, skin, and clothing. Avoid prolonged or
repeated contact with skin. Avoid prolonged exposure. Use only in well-ventilated areas. Wear
appropriate personal protective equipment. Wash hands thoroughly after handling. Observe good
industrial hygiene practices. For product usage instructions, please see the product label.
Level 2 Aerosol.
Pressurized container. Protect from sunlight and do not expose to temperatures exceeding
50°C/122 °F. Do not puncture, incinerate or crush. Do not handle or store near an open flame,
heat or other sources of ignition. This material can accumulate static charge which may cause
spark and become an ignition source. Secure cylinders in an upright position at all times, close all
valves when not in use. Store in a well-ventilated place. Store away from incompatible materials
(see Section 10 of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
PEL 9000 mg/m3Carbon dioxide (CAS
124-38-9)
STEL 30000 ppmCarbon dioxide (CAS
124-38-9)
TWA 5000 ppm
STEL 54000 mg/m3Carbon dioxide (CAS
124-38-9)
TWA 9000 mg/m3
TWA 100 mg/m3Distillates (petroleum),
hydrotreated light (CAS
64742-47-8)
Biological limit values
No biological exposure limits noted for the ingredient(s).
ValueComponents Type
5000 ppm
ValueComponents Type
ValueComponents Type
30000 ppm
5000 ppm
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
3 / 9
Appropriate engineering
wash facilities and emergency shower must be available when handling this product.
controls
Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates
should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation,
or other engineering controls to maintain airborne levels below recommended exposure limits. If
exposure limits have not been established, maintain airborne levels to an acceptable level. Eye
Individual protection measures, such as personal protective equipment
Eye/face protection
Wear safety glasses with side shields (or goggles).
Skin protection
Hand protection
Other
Respiratory protection
Wear protective gloves such as: Nitrile. Neoprene.
Wear appropriate chemical resistant clothing.
If engineering controls are not feasible or if exposure exceeds the applicable exposure limits, use a
NIOSH-approved cartridge respirator with an organic vapor cartridge. Use a self-contained
breathing apparatus in confined spaces and for emergencies. Air monitoring is needed to
determine actual employee exposure levels.
Thermal hazards
General hygiene
considerations
Wear appropriate thermal protective clothing, when necessary.
When using do not smoke. Always observe good personal hygiene measures, such as washing
after handling the material and before eating, drinking, and/or smoking. Routinely wash work
clothing and protective equipment to remove contaminants.
9. Physical and chemical properties
Appearance
Physical state
Form
Color
Odor
Odor threshold
pH
Melting point/freezing point
Initial boiling point and boiling
range
Flash point
Evaporation rate
Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit - lower
(%)
Flammability limit - upper
(%)
Vapor pressure
Vapor density
Relative density
Solubility (water)
Partition coefficient
(n-octanol/water)
Auto-ignition temperature
Decomposition temperature
Viscosity (kinematic)
Percent volatile
Liquid.
Aerosol.
Clear. Water-white.
Slight. Hydrocarbon-like.
Not available.
Not available.
-121 °F (-85 °C) estimated
392 °F (200 °C) estimated
185 °F (85 °C) Tag Closed Cup
Slow.
Not available.
0.6 % estimated
5.5 % estimated
2265.4 hPa estimated
> 1 (air = 1)
0.87 estimated
Slightly soluble.
Not available.
401 °F (205 °C) estimated
Not available.
Not available.
96 %
10. Stability and reactivity
Reactivity
Chemical stability
Possibility of hazardous
reactions
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
The product is stable and non-reactive under normal conditions of use, storage and transport.
Material is stable under normal conditions.
No dangerous reaction known under conditions of normal use.
SDS US
4 / 9
Conditions to avoid
Skin contact
Eye contact
cause redness and pain.
Acute toxicity
Respiratory sensitization
Carcinogenicity
Chronic effects
Heat, flames and sparks. Avoid temperatures exceeding the flash point. Contact with incompatible
materials.
Incompatible materials
Hazardous decomposition
Strong oxidizing agents.
No hazardous decomposition products are known.
products
11. Toxicological information
Information on likely routes of exposure
Ingestion
Inhalation
Symptoms related to the
physical, chemical and
toxicological characteristics
Information on toxicological effects
Heavy Duty Degreaser II
Acute
Dermal
LD50 Rabbit
Inhalation
LC50 Rat
Oral
LD50 Rat
Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious
chemical pneumonia.
May cause drowsiness and dizziness. Headache. Nausea, vomiting. Prolonged inhalation may be
harmful.
Causes skin irritation.
Causes serious eye irritation.
Diarrhea. May cause drowsiness and dizziness. Headache. Nausea, vomiting. Irritation of nose
and throat. Aspiration may cause pulmonary edema and pneumonitis. Severe eye irritation.
Symptoms may include stinging, tearing, redness, swelling, and blurred vision. Skin irritation. May
May be fatal if swallowed and enters airways. Narcotic effects.
Test ResultsProduct Species
> 2000 mg/kg
7.8325 mg/l, 4 hours estimated
3062.238 mg/kg estimated
* Estimates for product may be based on additional component data not shown.
Skin corrosion/irritation
Serious eye damage/eye
Causes skin irritation.
Causes serious eye irritation.
irritation
Not available.
Skin sensitization
Germ cell mutagenicity
This product is not expected to cause skin sensitization.
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
Reproductive toxicity
Specific target organ toxicity -
This product is not expected to cause reproductive or developmental effects.
May cause drowsiness and dizziness.
single exposure
Specific target organ toxicity -
Not classified.
repeated exposure
Aspiration hazard
May be fatal if swallowed and enters airways. If aspirated into lungs during swallowing or vomiting,
may cause chemical pneumonia, pulmonary injury or death.
Prolonged inhalation may be harmful.
12. Ecological information
Ecotoxicity
The product is not classified as environmentally hazardous. However, this does not exclude the
possibility that large or frequent spills can have a harmful or damaging effect on the environment.
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
5 / 9
Product Test ResultsSpecies
Acute
Acute
Acute
Acute
Partition coefficient n-octanol / water (log Kow)
Heavy Duty Degreaser II
Aquatic
EC50Crustacea 347.0535 mg/l, 48 hours estimatedDaphnia
LC50Fish 3.7656 mg/l, 96 hours estimatedFish
Components Test ResultsSpecies
Dipropylene glycol monomethyl ether acetate (CAS 88917-22-0)
Aquatic
LC50Crustacea 2701 mg/l, 48 hoursWater flea (Daphnia magna)
LC50Fish 151 mg/l, 96 hoursFathead minnow (Pimephales promelas)
(Oncorhynchus mykiss)
Dipropylene glycol monopropyl ether (dpmp) (CAS 29911-27-1)
Aquatic
EC50Crustacea > 100 mg/l, 48 hoursWater flea (Daphnia magna)
LC50Fish > 100 mg/l, 96 hoursRainbow trout,donaldson trout
(Oncorhynchus mykiss)
Distillates (petroleum), hydrotreated light (CAS 64742-47-8)
Aquatic
111 mg/l, 96 hoursRainbow trout,donaldson trout
LC50Fish 2.2 mg/l, 96 hoursBluegill (Lepomis macrochirus)
* Estimates for product may be based on additional component data not shown.
Persistence and degradability
Bioaccumulative potential
No data is available on the degradability of this product.
No data available.
Dipropylene glycol monomethyl ether acetate 0.61 OECD 107
Dipropylene glycol monopropyl ether (dpmp) 0.87 OECD 107
Mobility in soil
Other adverse effects
No data available.
No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation
potential, endocrine disruption, global warming potential) are expected from this component.
13. Disposal considerations
Disposal of waste from
residues / unused products
Hazardous waste code
Contaminated packaging
This product is not a RCRA hazardous waste (See 40 CFR Part 261.20 – 261.33). Empty
containers may be recycled. Collect and reclaim or dispose in sealed containers at licensed waste
disposal site. Contents under pressure. Do not puncture, incinerate or crush. Dispose in
accordance with all applicable regulations.
Not regulated.
Empty containers should be taken to an approved waste handling site for recycling or disposal.
Since emptied containers may retain product residue, follow label warnings even after container is
emptied.
14. Transport information
DOT
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Label(s)
Packing group
Special precautions for user
Special provisions
UN1950
Aerosols, flammable, Limited Quantity
2.1
-
2.1
Not applicable.
Read safety instructions, SDS and emergency procedures before handling.
N82
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
6 / 9
Packaging exceptions
Packaging non bulk
Packaging bulk
IATA
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
Environmental hazards
ERG Code
Special precautions for user
Other information
Passenger and cargo
aircraft
Cargo aircraft only
IMDG
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
Environmental hazards
Marine pollutant
EmS
Special precautions for user
306
None
None
UN1950
Aerosols, flammable, Limited Quanity
2.1
Not applicable.
No.
10L
Read safety instructions, SDS and emergency procedures before handling.
Allowed.
Allowed.
UN1950
AEROSOLS, LIMITED QUANTITY
2
Not applicable.
No.
F-D, S-U
Read safety instructions, SDS and emergency procedures before handling.
15. Regulatory information
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
SARA 304 Emergency release notification
Not regulated.
US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not listed.
US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance
Not listed.
CERCLA Hazardous Substance List (40 CFR 302.4)
Not listed.
CERCLA Hazardous Substances: Reportable quantity
Not listed.
Spills or releases resulting in the loss of any ingredient at or above its RQ require immediate notification to the National
Response Center (800-424-8802) and to your Local Emergency Planning Committee.
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
Not regulated.
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Safe Drinking Water Act
(SDWA)
Food and Drug
Administration (FDA)
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
All components are on the U.S. EPA TSCA Inventory List.
Not regulated.
Not regulated.
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
7 / 9
Superfund Amendments and Reauthorization Act of 1986 (SARA)
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
Section 311/312
Hazard categories
Immediate Hazard - Yes
Delayed Hazard - No
Fire Hazard - Yes
Pressure Hazard - Yes
Reactivity Hazard - No
SARA 302 Extremely
No
hazardous substance
US state regulations
US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100)
Not listed.
US. New Jersey Worker and Community Right-to-Know Act
Carbon dioxide (CAS 124-38-9)
Distillates (petroleum), hydrotreated light (CAS 64742-47-8)
US. Massachusetts RTK - Substance List
Carbon dioxide (CAS 124-38-9)
US. Rhode Island RTK
None.
US. Pennsylvania Worker and Community Right-to-Know Law
Carbon dioxide (CAS 124-38-9)
Distillates (petroleum), hydrotreated light (CAS 64742-47-8)
US. California Proposition 65
California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain
any chemicals currently listed as carcinogens or reproductive toxins.
Volatile organic compounds (VOC) regulations
EPA
VOC content (40 CFR
96 %
51.100(s))
Consumer products
Not regulated
(40 CFR 59, Subpt. C)
State
Consumer products
This product is regulated as a General Purpose Degreaser (aerosol). This product is compliant for
use in all 50 states.
VOC content (CA)
VOC content (OTC)
nternational Inventories
I
0 %
0 %
Country(s) or region Inventory name On inventory (yes/no)*
Substances (EINECS)
(PICCS)
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
YesAustralia Australian Inventory of Chemical Substances (AICS)
YesCanada Domestic Substances List (DSL)
NoCanada Non-Domestic Substances List (NDSL)
YesChina Inventory of Existing Chemical Substances in China (IECSC)
NoEurope European Inventory of Existing Commercial Chemical
YesEurope European List of Notified Chemical Substances (ELINCS)
NoJapan Inventory of Existing and New Chemical Substances (ENCS)
YesKorea Existing Chemicals List (ECL)
YesNew Zealand New Zealand Inventory
YesPhilippines Philippine Inventory of Chemicals and Chemical Substances
YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
country(s).
16. Other information, including date of preparation or last revision
Issue date
Prepared by
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
08-12-2014
Allison Cho
SDS US
8 / 9
Version #
Further information
HMIS® ratings
NFPA ratings
NFPA ratings
01
CRC # 490C
Health: 2
Flammability: 3
Physical hazard: 0
Personal protection: B
Health: 2
Flammability: 3
Instability: 0
3
02
Disclaimer
CRC cannot anticipate all conditions under which this information and its product, or the products
of other manufacturers in combination with its product, may be used. It is the user’s responsibility
to ensure safe conditions for handling, storage and disposal of the product, and to assume liability
for loss, injury, damage or expense due to improper use. The information contained in this
document applies to this specific material as supplied. It may not be valid for this material if it is
used in combination with any other materials. This information is accurate to the best of CRC
Industries' knowledge or obtained from sources believed by CRC to be accurate. Before using any
product, read all warnings and directions on the label. For further clarification of any information
contained on this (M)SDS consult your supervisor, a health & safety professional, or CRC
Industries.
Material name: Heavy Duty Degreaser II
03120 Version #: 01 Issue date: 08-12-2014
SDS US
9 / 9
Loading...