Page 1
SAFETY DATA SHEET
www.crcindustries.com
Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May be fatal if
1. Identification
Dielectric GreaseProduct identifier
Other means of identification
Product code
Recommended use
Recommended restrictions
Manufacturer/Importer/Supplier/Distributor information
Manufactured or sold by:
Company name
Address
Telephone
General Information
Technical Assistance
Customer Service
24-Hour Emergency
(CHEMTREC)
Website
No. 03082 (Item# 1003346)
Lubricating and insulating electrical components
None known.
CRC Industries, Inc.
885 Louis Dr.
Warminster, PA 18974 US
215-674-4300
800-521-3168
800-272-4620
800-424-9300 (US)
703-527-3887 (International)
2. Hazard(s) identification
Physical hazards
Health hazards
Environmental hazards
OSHA defined hazards
Label elements
Signal word
Hazard statement
Category 1Flammable aerosols
Liquefied gasGases under pressure
Category 2Skin corrosion/irritation
Category 2BSerious eye damage/eye irritation
Category 2Reproductive toxicity (fertility)
Category 3 narcotic effectsSpecific target organ toxicity, single exposure
Category 1Aspiration hazard
Category 1Hazardous to the aquatic environment, acute
hazard
Category 1Hazardous to the aquatic environment,
long-term hazard
Not classified.
Danger
swallowed and enters airways. Causes skin irritation. Causes eye irritation. May cause
drowsiness or dizziness. Suspected of damaging fertility. Very toxic to aquatic life. Very toxic to
aquatic life with long lasting effects.
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
1 / 12
Page 2
Precautionary statement
with plenty of water. If skin irritation occurs: Get medical advice/attention. Take off contaminated
CAS number
%
Chemical name
Common name and synonyms
Prevention
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not
spray on an open flame or other ignition source. Pressurized container: Do not pierce or burn,
even after use. Do not apply while equipment is energized. Extinguish all flames, pilot lights and
heaters. Vapors will accumulate readily and may ignite. Use only with adequate ventilation;
maintain ventilation during use and until all vapors are gone. Open doors and windows or use
other means to ensure a fresh air supply during use and while product is drying. If you experience
any symptoms listed on this label, increase ventilation or leave the area. Avoid breathing mist or
vapor. Wash thoroughly after handling. Wear protective gloves/protective clothing/eye
protection/face protection. Avoid release to the environment.
Response
If swallowed: Immediately call a poison center/doctor. Do NOT induce vomiting. If on skin: Wash
clothing and wash before reuse. If inhaled: Remove person to fresh air and keep comfortable for
breathing. Call a poison center/doctor if you feel unwell. If in eyes: Rinse cautiously with water for
several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye
irritation persists: Get medical advice/attention. If exposed or concerned: Get medical
advice/attention. Collect spillage.
Storage
Store in a well-ventilated place. Store locked up. Protect from sunlight. Do not expose to
temperatures exceeding 50°C/122°F. Exposure to high temperature may cause can to burst.
Disposal
Hazard(s) not otherwise
classified (HNOC)
Dispose of contents/container in accordance with local/regional/national regulations.
Static accumulating flammable liquid can become electrostatically charged even in bonded and
grounded equipment. Sparks may ignite liquid and vapor. May cause flash fire or explosion.
3. Composition/information on ingredients
Mixtures
68476-86-8liquefied petroleum gas 20 - 30
142-82-5n-heptane 10 - 20
107-83-52-methylpentane 5 - 10
68611-44-9fumed silica 5 - 10
64742-49-0naphtha (petroleum), hydrotreated
light
589-34-43-methylhexane 3 - 5
591-76-42-methylhexane 1 - 3
426260-76-6heptane, branched, cyclic and
linear
108-87-2methylcyclohexane 1 - 3
110-54-3n-hexane 1 - 3
64742-89-8solvent naphtha (petroleum), light
aliph.
617-78-73-ethylpentane < 1
562-49-23,3-dimethylpentane < 0.3
75-83-22,2-dimethylbutane < 0.2
79-29-82,3-dimethylbutane < 0.2
96-14-03-methylpentane < 0.2
Specific chemical identity and/or percentage of composition has been withheld as a trade secret.
4. First-aid measures
Inhalation
Skin contact
Eye contact
Ingestion
Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON
CENTER or doctor/physician if you feel unwell.
Remove contaminated clothing. Rinse skin with water/shower. If skin irritation occurs: Get medical
advice/attention. Wash contaminated clothing before reuse.
Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If
vomiting occurs, keep head low so that stomach content doesn't get into the lungs.
5 - 10
1 - 3
1 - 3
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
2 / 12
Page 3
Most important
symptoms/effects, acute and
delayed
Indication of immediate
medical attention and special
treatment needed
General information
5. Fire-fighting measures
Suitable extinguishing media
Unsuitable extinguishing
media
Specific hazards arising from
the chemical
Special protective equipment
and precautions for firefighters
Fire-fighting
equipment/instructions
General fire hazards
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness.
Headache. Nausea, vomiting. Irritation of eyes. Exposed individuals may experience eye tearing,
redness, and discomfort. Skin irritation. May cause redness and pain.
Provide general supportive measures and treat symptomatically. Keep victim under observation.
Symptoms may be delayed.
IF exposed or concerned: Get medical advice/attention. Ensure that medical personnel are aware
of the material(s) involved, and take precautions to protect themselves. Show this safety data
sheet to the doctor in attendance.
Water fog. Foam. Carbon dioxide (CO2). Dry chemical powder, carbon dioxide, sand or earth may
be used for small fires only.
Do not use water jet as an extinguisher, as this will spread the fire.
Contents under pressure. Pressurized container may rupture when exposed to heat or flame. This
product is a poor conductor of electricity and can become electrostatically charged. If sufficient
charge is accumulated, ignition of flammable mixtures can occur. Static electricity accumulation
may be significantly increased by the presence of small quantities of water or other contaminants.
Material will float and may ignite on surface of water. During fire, gases hazardous to health may
be formed.
Firefighters must use standard protective equipment including flame retardant coat, helmet with
face shield, gloves, rubber boots, and in enclosed spaces, SCBA.
In case of fire: Stop leak if safe to do so. Move containers from fire area if you can do so without
risk. Containers should be cooled with water to prevent vapor pressure build up.
Extremely flammable aerosol. Contents under pressure. Pressurized container may rupture when
exposed to heat or flame.
6. Accidental release measures
Personal precautions,
protective equipment and
emergency procedures
Methods and materials for
containment and cleaning up
Environmental precautions
Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Remove all
possible sources of ignition in the surrounding area. Keep out of low areas. Many gases are
heavier than air and will spread along ground and collect in low or confined areas (sewers,
basements, tanks). Wear appropriate protective equipment and clothing during clean-up. Avoid
breathing mist or vapor. Emergency personnel need self-contained breathing equipment. Do not
touch damaged containers or spilled material unless wearing appropriate protective clothing.
Ventilate closed spaces before entering them. Use appropriate containment to avoid
environmental contamination. Local authorities should be advised if significant spillages cannot be
contained. For personal protection, see section 8 of the SDS.
Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Keep
combustibles (wood, paper, oil, etc.) away from spilled material. This product is miscible in water.
Prevent product from entering drains. Stop the flow of material, if this is without risk. Wipe up with
absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination.
For waste disposal, see section 13 of the SDS.
Avoid release to the environment. Inform appropriate managerial or supervisory personnel of all
environmental releases. Prevent further leakage or spillage if safe to do so. Avoid discharge into
drains, water courses or onto the ground. Use appropriate containment to avoid environmental
contamination.
7. Handling and storage
Precautions for safe handling
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Minimize fire risks from flammable and combustible materials (including
combustible dust and static accumulating liquids) or dangerous reactions with incompatible
materials. Pressurized container: Do not pierce or burn, even after use. Do not use if spray button
is missing or defective. Do not spray on a naked flame or any other incandescent material. Do not
smoke while using or until sprayed surface is thoroughly dry. Do not cut, weld, solder, drill, grind,
or expose containers to heat, flame, sparks, or other sources of ignition. Use caution around
energized equipment. The metal container will conduct electricity if it contacts a live source. This
may result in injury to the user from electrical shock and/or flash fire. Avoid breathing mist or
vapor. Avoid contact with eyes, skin, and clothing. Pregnant or breastfeeding women must not
handle this product. Should be handled in closed systems, if possible. Use only in well-ventilated
areas. Wear appropriate personal protective equipment. Wash hands thoroughly after handling.
Avoid release to the environment. Observe good industrial hygiene practices. For product usage
instructions, see the product label.
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
3 / 12
Page 4
Conditions for safe storage,
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
US. OSHA Table Z-3 (29 CFR 1910.1000)
US. ACGIH Threshold Limit Values
Level 3 Aerosol.
including any incompatibilities
Pressurized container. Protect from sunlight and do not expose to temperatures exceeding
50°C/122 °F. Do not puncture, incinerate or crush. Do not handle or store near an open flame,
heat or other sources of ignition. This material can accumulate static charge which may cause
spark and become an ignition source. Avoid spark promoters. These alone may be insufficient to
remove static electricity. Store in a well-ventilated place. Store away from incompatible materials
(see Section 10 of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
PEL 2000 mg/m3methylcyclohexane (CAS
108-87-2)
PEL 400 mg/m3naphtha (petroleum),
hydrotreated light (CAS
64742-49-0)
PEL 2000 mg/m3n-heptane (CAS 142-82-5)
PEL 1800 mg/m3n-hexane (CAS 110-54-3)
PEL 400 mg/m3solvent naphtha
(petroleum), light aliph.
(CAS 64742-89-8)
ValueComponents Type
500 ppm
100 ppm
500 ppm
500 ppm
100 ppm
TWA 0.8 mg/m3fumed silica (CAS
68611-44-9)
STEL 1000 ppm2,2-dimethylbutane (CAS
75-83-2)
TWA 500 ppm
STEL 1000 ppm2,3-dimethylbutane (CAS
79-29-8)
TWA 500 ppm
STEL 500 ppm2-methylhexane (CAS
591-76-4)
TWA 400 ppm
STEL 1000 ppm2-methylpentane (CAS
107-83-5)
TWA 500 ppm
STEL 500 ppm3,3-dimethylpentane (CAS
562-49-2)
TWA 400 ppm
STEL 500 ppm3-ethylpentane (CAS
617-78-7)
TWA 400 ppm
STEL 500 ppm3-methylhexane (CAS
589-34-4)
TWA 400 ppm
STEL 1000 ppm3-methylpentane (CAS
96-14-0)
TWA 500 ppm
STEL 500 ppmmethylcyclohexane (CAS
108-87-2)
TWA 400 ppm
STEL 500 ppmn-heptane (CAS 142-82-5)
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
ValueComponents Type
20 mppcf
ValueComponents Type
SDS US
4 / 12
Page 5
US. ACGIH Threshold Limit Values
US. NIOSH: Pocket Guide to Chemical Hazards
75-83-2)
ACGIH Biological Exposure Indices
wash facilities and emergency shower should be available when handling this product.
79-29-8)
107-83-5)
96-14-0)
108-87-2)
hydrotreated light (CAS
64742-49-0)
(petroleum), light aliph.
(CAS 64742-89-8)
Biological limit values
ValueComponents Type
TWA 400 ppm
TWA 50 ppmn-hexane (CAS 110-54-3)
ValueComponents Type
Ceiling 1800 mg/m32,2-dimethylbutane (CAS
510 ppm
TWA 350 mg/m3
100 ppm
Ceiling 1800 mg/m32,3-dimethylbutane (CAS
510 ppm
TWA 350 mg/m3
100 ppm
Ceiling 1800 mg/m32-methylpentane (CAS
510 ppm
TWA 350 mg/m3
100 ppm
Ceiling 1800 mg/m33-methylpentane (CAS
510 ppm
TWA 350 mg/m3
100 ppm
TWA 1600 mg/m3methylcyclohexane (CAS
400 ppm
TWA 400 mg/m3naphtha (petroleum),
100 ppm
Ceiling 1800 mg/m3n-heptane (CAS 142-82-5)
440 ppm
TWA 350 mg/m3
85 ppm
TWA 180 mg/m3n-hexane (CAS 110-54-3)
50 ppm
TWA 400 mg/m3solvent naphtha
100 ppm
ValueComponents Determinant Specimen Sampling Time
n-hexane (CAS 110-54-3)
0.4 mg/l 2,5-Hexanedio
n,
without
hydrolysis
* - For sampling details, please see the source document.
Exposure guidelines
US - California OELs: Skin designation
n-hexane (CAS 110-54-3) Can be absorbed through the skin.
US ACGIH Threshold Limit Values: Skin designation
n-hexane (CAS 110-54-3) Can be absorbed through the skin.
Appropriate engineering
controls
Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates
should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation,
or other engineering controls to maintain airborne levels below recommended exposure limits. If
exposure limits have not been established, maintain airborne levels to an acceptable level. Eye
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
Urine
*
SDS US
5 / 12
Page 6
Individual protection measures, such as personal protective equipment
wash work clothing and protective equipment to remove contaminants.
Eye/face protection
Wear safety glasses with side shields (or goggles).
Skin protection
Hand protection
Other
Respiratory protection
Wear protective gloves such as: Nitrile. Polyvinyl alcohol (PVA). Viton/butyl.
Wear appropriate chemical resistant clothing.
If engineering controls are not feasible or if exposure exceeds the applicable exposure limits, use a
NIOSH-approved cartridge respirator with an organic vapor cartridge. Use a self-contained
breathing apparatus in confined spaces and for emergencies. Air monitoring is needed to
determine actual employee exposure levels.
Thermal hazards
General hygiene
considerations
Wear appropriate thermal protective clothing, when necessary.
When using, do not eat, drink or smoke. Always observe good personal hygiene measures, such
as washing after handling the material and before eating, drinking, and/or smoking. Routinely
9. Physical and chemical properties
Appearance
Physical state
Form
Color
Odor
Odor threshold
pH
Melting point/freezing point
Initial boiling point and boiling
range
Flash point
Evaporation rate
Flammability (solid, gas)
Upper/lower flammability or explosive limits
Flammability limit - lower
(%)
Flammability limit - upper
(%)
Vapor pressure
Vapor density
Relative density
Solubility (water)
Partition coefficient
(n-octanol/water)
Auto-ignition temperature
Decomposition temperature
Viscosity (kinematic)
Percent volatile
Liquid.
Aerosol.
Translucent. Opaque.
Solvent.
Not available.
Not available.
-244.7 °F (-153.7 °C) estimated
118.4 °F (48 °C) estimated
< 20 °F (< -6.7 °C) Tag Closed Cup
Fast.
Not available.
1 % estimated
8 % estimated
1528.1 hPa estimated
> 1 (air = 1)
0.66 estimated
Negligible.
Not available.
489.2 °F (254 °C) estimated
Not available.
Not available.
90.1 %
10. Stability and reactivity
Reactivity
Chemical stability
Possibility of hazardous
reactions
Conditions to avoid
Incompatible materials
Hazardous decomposition
products
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
The product is stable and non-reactive under normal conditions of use, storage and transport.
Material is stable under normal conditions.
No dangerous reaction known under conditions of normal use.
Heat, flames and sparks. Contact with incompatible materials.
Strong oxidizing agents. Strong reducing agents. Strong acids. Strong bases. Halogens.
Peroxides.
Carbon oxides. Hydrocarbons.
SDS US
6 / 12
Page 7
11. Toxicological information
Inhalation
Skin contact
Eye contact
Acute toxicity
Information on likely routes of exposure
May cause drowsiness and dizziness. Headache. Nausea, vomiting.
Causes skin irritation.
Causes eye irritation.
Ingestion
Symptoms related to the
physical, chemical and
toxicological characteristics
Information on toxicological effects
3-methylhexane (CAS 589-34-4)
Acute
Dermal
LD50 Rabbit > 2000 mg/kg
Oral
LD50 Rat > 2000 mg/kg
heptane, branched, cyclic and linear (CAS 426260-76-6)
Acute
Dermal
LD50 Rabbit > 2000 mg/kg
Inhalation
LC50 Rat > 60 mg/l, 4 hours
Oral
LD50 Rat > 5000 mg/kg
methylcyclohexane (CAS 108-87-2)
Acute
Dermal
LD50 Rabbit > 2000 mg/kg
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
Acute
Dermal
LD50 Rabbit > 2000 mg/kg
n-heptane (CAS 142-82-5)
Acute
Dermal
LD50 Rabbit 3000 mg/kg
n-hexane (CAS 110-54-3)
Acute
Dermal
LD50 Rabbit > 1300 mg/kg
Oral
LD50 Rat 15840 mg/kg
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
Acute
Dermal
LD50 Rabbit > 2000 mg/kg
Droplets of the product aspirated into the lungs through ingestion or vomiting may cause a serious
chemical pneumonia.
Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness.
Headache. Nausea, vomiting. Irritation of eyes. Exposed individuals may experience eye tearing,
redness, and discomfort. Skin irritation. May cause redness and pain.
May be fatal if swallowed and enters airways.
Test ResultsComponents Species
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
* Estimates for product may be based on additional component data not shown.
SDS US
7 / 12
Page 8
Skin corrosion/irritation
Respiratory sensitization
Carcinogenicity
Acute
Acute
Acute
Acute
Serious eye damage/eye
Causes skin irritation.
Causes eye irritation.
irritation
Not a respiratory sensitizer.
Skin sensitization
Germ cell mutagenicity
This product is not expected to cause skin sensitization.
No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
IARC Monographs. Overall Evaluation of Carcinogenicity
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not regulated.
US. National Toxicology Program (NTP) Report on Carcinogens
Not listed.
Reproductive toxicity
Specific target organ toxicity -
Suspected of damaging fertility.
May cause drowsiness and dizziness.
single exposure
Specific target organ toxicity -
Not classified.
repeated exposure
Aspiration hazard
May be fatal if swallowed and enters airways. If aspirated into lungs during swallowing or vomiting,
may cause chemical pneumonia, pulmonary injury or death.
12. Ecological information
Ecotoxicity
Components Test ResultsSpecies
2-methylpentane (CAS 107-83-5)
Aquatic
Very toxic to aquatic life with long lasting effects.
EC50Crustacea 1 - 10 mg/l, 48 hoursDaphnia
LC50Fish 1 - 10 mg/l, 96 hoursFish
heptane, branched, cyclic and linear (CAS 426260-76-6)
Aquatic
EC50Crustacea 1.5 mg/l, 48 hoursWater flea (Daphnia magna)
methylcyclohexane (CAS 108-87-2)
Aquatic
LC50Fish 5.8 mg/l, 96 hoursStriped bass (Morone saxatilis)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
Aquatic
EC50Crustacea 1 - 10 mg/l, 48 hoursDaphnia
LC50Fish 1 - 10 mg/l, 96 hoursFish
n-heptane (CAS 142-82-5)
Aquatic
EC50Crustacea 1.5 mg/l, 48 hoursWater flea (Daphnia magna)
LC50Fish 2.1 - 2.98 mg/l, 96 hoursFathead minnow (Pimephales promelas)
n-hexane (CAS 110-54-3)
Aquatic
LC50Fish 2.101 - 2.981 mg/l, 96 hoursFathead minnow (Pimephales promelas)
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
8 / 12
Page 9
Components Test ResultsSpecies
Acute
Partition coefficient n-octanol / water (log Kow)
Bioconcentration factor (BCF)
with all applicable regulations.
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
Aquatic
LC50Fish 8.8 mg/l, 96 hoursRainbow trout,donaldson trout
(Oncorhynchus mykiss)
EC50Crustacea 1.5 mg/l, 48 hoursWater flea (Daphnia magna)
* Estimates for product may be based on additional component data not shown.
Persistence and degradability
Bioaccumulative potential
No data is available on the degradability of this product.
2,2-dimethylbutane 3.82
2,3-dimethylbutane 3.42
2-methylpentane 3.74
3-methylpentane 3.6
methylcyclohexane 3.61
n-heptane 4.66
n-hexane 3.9
naphtha (petroleum), hydrotreated light 10 - 25000
Mobility in soil
Other adverse effects
No data available.
The product contains volatile organic compounds which have a photochemical ozone creation
potential.
8.8 mg/l, 96 hours
13. Disposal considerations
Disposal of waste from
residues / unused products
Hazardous waste code
Contaminated packaging
If discarded, this product is considered a RCRA ignitable waste, D001. Collect and reclaim or
dispose in sealed containers at licensed waste disposal site. Contents under pressure. Do not
puncture, incinerate or crush. Do not allow this material to drain into sewers/water supplies. Do not
contaminate ponds, waterways or ditches with chemical or used container. Dispose in accordance
D001: Waste Flammable material with a flash point <140 F
Since emptied containers may retain product residue, follow label warnings even after container is
emptied. Empty containers should be taken to an approved waste handling site for recycling or
disposal.
14. Transport information
DOT
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Label(s)
Packing group
Special precautions for user
Special provisions
Packaging exceptions
Packaging non bulk
Packaging bulk
IATA
UN number
UN proper shipping name
Transport hazard class(es)
Class
Subsidiary risk
Packing group
ERG Code
Special precautions for user
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
UN1950
Aerosols, flammable, Limited Quantity
2.1
-
2.1
Not applicable.
Read safety instructions, SDS and emergency procedures before handling.
N82
306
None
None
UN1950
Aerosols, flammable, Limited Quantity
2.1
Not applicable.
10L
Read safety instructions, SDS and emergency procedures before handling.
SDS US
9 / 12
Page 10
Other information
Passenger and cargo
Allowed with restrictions.
aircraft
Cargo aircraft only
Allowed with restrictions.
IMDG
UN number
UN proper shipping name
UN1950
AEROSOLS, Limited Quantity
Transport hazard class(es)
Class
Subsidiary risk
Packing group
2.1
Not applicable.
Environmental hazards
Marine pollutant
EmS
Special precautions for user
No.
Not available.
Read safety instructions, SDS and emergency procedures before handling.
15. Regulatory information
US federal regulations
TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D)
Not regulated.
SARA 304 Emergency release notification
Not regulated.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not regulated.
US EPCRA (SARA Title III) Section 313 - Toxic Chemical: Listed substance
n-hexane (CAS 110-54-3)
CERCLA Hazardous Substance List (40 CFR 302.4)
3,3-dimethylpentane (CAS 562-49-2) Listed.
n-hexane (CAS 110-54-3) Listed.
CERCLA Hazardous Substances: Reportable quantity
3,3-dimethylpentane (CAS 562-49-2) 100 LBS
n-hexane (CAS 110-54-3) 5000 LBS
Spills or releases resulting in the loss of any ingredient at or above its RQ require immediate notification to the National
Response Center (800-424-8802) and to your Local Emergency Planning Committee.
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List
n-hexane (CAS 110-54-3)
Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130)
Not regulated.
Safe Drinking Water Act
(SDWA)
Food and Drug
Administration (FDA)
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Section 311/312
Hazard categories
SARA 302 Extremely
hazardous substance
US state regulations
US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, 69502.3, subd.
(a))
liquefied petroleum gas (CAS 68476-86-8)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
n-hexane (CAS 110-54-3)
This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication
Standard, 29 CFR 1910.1200.
Not regulated.
Not regulated.
Immediate Hazard - Yes
Delayed Hazard - Yes
Fire Hazard - Yes
Pressure Hazard - Yes
Reactivity Hazard - No
No
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
10 / 12
Page 11
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
US. New Jersey Worker and Community Right-to-Know Act
2,2-dimethylbutane (CAS 75-83-2)
2,3-dimethylbutane (CAS 79-29-8)
2-methylpentane (CAS 107-83-5)
3-methylhexane (CAS 589-34-4)
methylcyclohexane (CAS 108-87-2)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
n-heptane (CAS 142-82-5)
n-hexane (CAS 110-54-3)
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
US. Massachusetts RTK - Substance List
2,2-dimethylbutane (CAS 75-83-2)
2,3-dimethylbutane (CAS 79-29-8)
2-methylhexane (CAS 591-76-4)
2-methylpentane (CAS 107-83-5)
3-methylhexane (CAS 589-34-4)
3-methylpentane (CAS 96-14-0)
methylcyclohexane (CAS 108-87-2)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
n-heptane (CAS 142-82-5)
n-hexane (CAS 110-54-3)
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
US. Pennsylvania Worker and Community Right-to-Know Law
2,2-dimethylbutane (CAS 75-83-2)
2,3-dimethylbutane (CAS 79-29-8)
2-methylhexane (CAS 591-76-4)
2-methylpentane (CAS 107-83-5)
3,3-dimethylpentane (CAS 562-49-2)
3-methylhexane (CAS 589-34-4)
3-methylpentane (CAS 96-14-0)
methylcyclohexane (CAS 108-87-2)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
n-heptane (CAS 142-82-5)
n-hexane (CAS 110-54-3)
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
US. Rhode Island RTK
methylcyclohexane (CAS 108-87-2)
naphtha (petroleum), hydrotreated light (CAS 64742-49-0)
n-heptane (CAS 142-82-5)
n-hexane (CAS 110-54-3)
solvent naphtha (petroleum), light aliph. (CAS 64742-89-8)
US. California Proposition 65
WARNING: This product contains a chemical known to the State of California to cause cancer and birth defects or other
reproductive harm.
US - California Proposition 65 - CRT: Listed date/Carcinogenic substance
benzene (CAS 71-43-2) Listed: February 27, 1987
cumene (CAS 98-82-8) Listed: April 6, 2010
ethylbenzene (CAS 100-41-4) Listed: June 11, 2004
naphthalene (CAS 91-20-3) Listed: April 19, 2002
US - California Proposition 65 - CRT: Listed date/Developmental toxin
benzene (CAS 71-43-2) Listed: December 26, 1997
toluene (CAS 108-88-3) Listed: January 1, 1991
US - California Proposition 65 - CRT: Listed date/Male reproductive toxin
benzene (CAS 71-43-2) Listed: December 26, 1997
Volatile organic compounds (VOC) regulations
EPA
VOC content (40 CFR
90.1 %
51.100(s))
Consumer products
Not regulated
(40 CFR 59, Subpt. C)
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
11 / 12
Page 12
State
A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing
Consumer products
VOC content (CA)
VOC content (OTC)
Not regulated
90.1 %
90.1 %
International Inventories
Country(s) or region Inventory name On inventory (yes/no)*
Substances (EINECS)
(PICCS)
*A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s)
country(s).
NoAustralia Australian Inventory of Chemical Substances (AICS)
NoCanada Domestic Substances List (DSL)
YesCanada Non-Domestic Substances List (NDSL)
NoChina Inventory of Existing Chemical Substances in China (IECSC)
NoEurope European Inventory of Existing Commercial Chemical
NoEurope European List of Notified Chemical Substances (ELINCS)
NoJapan Inventory of Existing and New Chemical Substances (ENCS)
YesKorea Existing Chemicals List (ECL)
NoNew Zealand New Zealand Inventory
YesPhilippines Philippine Inventory of Chemicals and Chemical Substances
YesUnited States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory
16. Other information, including date of preparation or last revision
Issue date
Revision date
Prepared by
Version #
Further information
HMIS® ratings
NFPA ratings
NFPA ratings
Disclaimer
Revision Information
12-20-2016
08-29-2017
Allison Yoon
02
CRC # 438A-B/1002424-1002425
Health: 2*
Flammability: 4
Physical hazard: 0
Personal protection: B
Health: 2
Flammability: 4
Instability: 0
4
02
The information contained in this document applies to this specific material as supplied. It may not
be valid for this material if it is used in combination with any other materials. This information is
accurate to the best of CRC's knowledge or obtained from sources believed by CRC to be
accurate. Before using any product, read all warnings and directions on the label. For further
clarification of any information contained on this (M)SDS consult your supervisor, a health & safety
professional, or CRC Industries, Inc..
Product and Company Identification: Product Codes
Hazard(s) identification: Prevention
Composition/information on ingredients: Component information
Accidental release measures: Personal precautions, protective equipment and emergency
procedures
Handling and storage: Precautions for safe handling
Exposure controls/personal protection: Hand protection
Physical & Chemical Properties: Multiple Properties
Transport Information: Proper Shipping Name/Packing Group
Other information, including date of preparation or last revision: Further information
GHS: Classification
Material name: Dielectric Grease
No. 03082 (Item# 1003346) Version #: 02 Revision date: 08-29-2017 Issue date: 12-20-2016
SDS US
12 / 12
Loading...