Craftsman 919152141 Owner’s Manual

Owner's Manual

Permanently Lubricated

Tank Mounted

AIR COMPRESSOR

Model No.

919.152141

• Safety Guidelines

• Assembly

• Operation

• Maintenance

• Service and Adjustments

• Troubleshooting

• Repair Parts

CAUTION: Read the Saf_y Guidelines
and All Instructions Carefully Before

Opsr_ing.

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

Visit our Cre_tsmanwebslte: www.sears.com/craftsman

026336 R_. O 4/17/Q2

h_=Tml_ [_[_o_ui=_--_

WARRANTY ............................................. 2

SPECIFICATION CHART .................................... 3

SAFETY GUIDELINES .................................... 3-8

GLOSSARY ...................................... 9

ACCESSORIES ......................................... 9

DUTY CYCLE ...................................... 9

INSTALLATION ...................................... 10 11

OPERATION ........................................ 12-14

MAINTENANCE ................................... 15

SERVICE AND ADJUSTMENTS ........................ 16-17

STORAGE .............................................. q8

TROUBLESHOOTING GUIDE ............................ 19-21

REPAIR PARTS ...................................... 22-25

ESPANOL .......................................... 26-48

NOTESINOTAS .................................... 47

HOW TO ORDER REPAIR PAP_I'S ..................... back cover

IIIII ,,,I.__=!=_',.,._i,_"

FULL ONE YEAR WARRANTY AIR COMPRESSOR

If this air compressor fails due to a defect in material or workmanship within
one year from the date of purchase, RETURN ITTO THE NEAREST SEARS

REPAIR CENTER THROUGHOUT THE UNITED STATESAND SEARS WILL
REPAIR IT, FREE OF CHARGE. If purchased from Orchard Supply Hardware,

return to the nearest Orchard Stone and Orchard will repair it, free of charge.
]f this air compressor is used for commercial or rental purposes, the warranty

wi_lapply for ninety days from the date of purchase,
This warranfy glve_ you specific legat rights and you may ha'Je other rights

which vary from state to state.

Sears, Roebuck and Co,, Dept, 817WA, Hoffman Estates, II 60179

D26336 2-ENG

Model No. 919-162141
Max. Developed HP 2

Bore 47-625
Stroke 31.7S

Voltage-Single Phase 120V

Minimum Br_nch Circuit Requirement 10 amps
Fuse Type Time Delay

Air Tal_k Capacity 4
Appro× Cutqn 120
Approx Cut-out 150

SCFM @ 40 psig 3.7
SCFM @ 90 pgi9 2.6

[_-Y±I.1:t_ [_lJl.J=l_l_lm .] =laLl_li[.]O_-']

Thls manuaL contains information that is important for you to know and understand This _nformation

rel_Ie_ t_ protecting YOUR .&&FET'f and PREVENTING EQUIPMENT PROBLI_.IvIs. To h_lp you
roco_'l;Zl! thi_: iritOrmLLtiorl. WCUr=ethe _ymbol_ berow Please fe_ld _he m_nu_l _rlcl p3y _lention th

th_'se sections

situation which, if not avoided, will
result in ._h_ojr_._._.

_lndlcates a potentially

f_azardous situation

which, if not avoided, _ result in

death oJ's_rlous iniurv.

F_,_1_l_lndicates a potentially

which, if not avoided, _ result in
minor or modera'ie iniurv,

I_'_lIUsed without the

indicates a potentially hazardous
situation which, if not avoided, may

hazardous situation

safety alert symbol

result in Droner_ damaae.

SAVE THESE NS__FJUCT ONS _l

IMPROPER OPERATION OR MAINTENANCE OF THIS PRODUCT COULD RESULT IN
SERIOUS INJURY AND PROPERTY DAMAGE, READ AND UNDERSTAND ALL

WARNINGS AND OPERATING iNSTRUCTIONS BEFORE USING THIS EQUIPMEN'_,

Some dust created by power sanding, _awing, grinding, drilling, and other

cause c_r_ _i_birth dB_e¢_ or other I_produc_tlv_ hsrrtl. Sore@_(ampIe of the_e chemical_ sn9:

i_ad from _ead-base_l paints
c_/st_ll)ne _iLica [tom bricke snd cement and other rnasol_ry ptoduc_
_rsenic and chromium from chemically-treated lumber

Your dsk Irem thesa expoaures vari_=, d_pendii_g on how often you do this type of work "re raduce
yoer e_posum _o these chomical_: w_r_ in a well v_ntilated area, _nd work with approved safety
e_qulprnor_t, =lWi=ys wear M,_I'M_/NIO_H eppr_ved, properly fitting face mask or respirator when uain_

sUCh tool&
When using air tools, basic smf_y preaaution_ _hould alw_y_ be followed to reduce the tisl¢ of of

p_rson_l injury.

construction nctivitJB_contains chemic_l_ known (to _he Slale o_ California) _o

3-ENG D26_6

Save these instructions

Improper oporatlon or maintenance of this product could resuEt in serloua injury snd

ptop_y damage, Read _nd understand al_ warnings and operation instructions before
using thig equipment.

II 1 2%IiD

WARNING: Risk of explosion or fire

What Could Happen How To Prevent it

It is normal for electrlcal contacts within Always operate the compressor _na w_ll
th_ motor _nd pressure _wlfch to spark, ventilated area free of combustlble

If electrical sparks from compressor It spraying flammable materi_ls, locate
come Into €onfect with fl_mrnable €ompreesor at least 20 feet away from

vapors, they may ignite, causing fir_ or spray area. An additional length of hose
explosion, may be required.

Restricting any o_ the compreE;_or
ventilation openings w_ll cause serious
overhearing and cou)d cause fire.

Unattended operation ofthia product
could result in persona] injury or

property damage. To reduce _he rlak of

fire, do not allow th_ compressor to

operate unattended.

rnaterlals, gasoline, or solvent vapors.

Store flammable materials in a se;ure
location away from compressor.

Never place objects against or on top

of €ompressor. Operate compressor it_
an open area at least 1:_Inches away
from any wall or obstruction that would

restrict the flow of fre=h air to the
ventilation openings,

Operate compressor in o clean, dry waif

ventilated ar_a Do not operalle unit
indoors or in Bny confined area.

Alwaye remain in attendance with the

)mduct when it is operating,

Alwaya dla¢oi_nect electrical powur by

moving pressure switch I_ver to the off

)osition and drain tank daily or after

each Use.

D?6336 4- LeNG

iri_"i_iff

WARNING: Risk of Bursting

in a violent tank explosion and could cause property damage or serious injury.

1. Failure to properly drain

2. Modifications or attempted repairs Never drill into,weld,or make any

3. Unauthorized modifications to the attachments.

4. Excessive vibration can weaken

The following conditions could lead to a weakening of the tank, and result

What Could Happen

condensed water from tank.

causing rust and thinning of the
=teel tank.

to the tank. modifications to the tank or its

unloader valve, safety va]ve, or any
other components which control

tank pressure.

Draln tank daily or a_ler each use, If
lank deve]aps _ leak, replace it

immediately with a new tank nr replace
the entire compressor.

Hqw To, Pr.even_ i_

The lank ]_desigrled lo wi[hstand specific

the air tank and cause rupture or

explosion

operating pressures, Never make
adjustments or parts substitutions to

alter the fButow sat operating

pressures.

ATTACHMENTS & "_CCESSORI_S;

Exceeding the pressure rating of air

tools, 3pr_y gun_, _llr operated
=_ceseories, tires and other inflatables
can cause them to ezplode or fly apart,

and could result in serious ]nJui_

For essential control of air pressure, you

must install a pressure regulator and
pressure gauge to the air outlet (if not

equipped) of your compressor. Follow the
equipment manufacturers

recommendation and never exceed the
maximum allowable pressure rating of

at'_achments. Never use _ompressor to
inflate small low pressure objects such
as children's toys, footballs,

basketballs, etc.

:FzY,#-,1;].•

II I

WARNING: Risk from Flying Objects

WHAT CAN HAPPEN HOW To pREVENTIT

The Gompressad air stream can _auee
soft tissue damage to exposed skin and

can propel dirt, chips, loose particles,
and smell objeGts at high speed,
resultlng in property damage or personal

Iniu_.

Alway8 Wear ANSI Z87.1 approved safety
glaegea with side shields when using the

Gotripf_ssor,
Never poJilt any no/JEIo or sprayer

toward any part of the body or at other
people or enirl_ale.

Always turn the compressor off end
bleed pressure from the air hose and tank

before attempting maintenance, attaching
tools or eocesaoriee.

5- ENG D2633e

WARNING; Risk of Burns

WHAT CAN HAPPEN

Touching e_poEed mats{ such as _hc

compressor head or outlettube_,man

result in serious burn_.

II ir:% iP

WARNING: Risk from Moving Parts

WHAT CAN HAPPEN

Moving parts such es the pulley, flu/wheel,
and belt can cause serious injury if they

corn into contact with you or your

_lothlng,

At(erupting to operate compressor wiLh

damaged or rniaslng parts or attempting

to repair compressor with protective

shrouds removed oan e_pose you Io
moving parts and can result in serious

injuw.

III E&vailil'

HOW TO PREVENT IT

Novcr touch any exposed metal par_s
on compressor during ar immediately

after operation. Compressor will remain
hot for saveral mlnute_ after operation,

Do not reach around proteotlve shrouds
or attempt malntenance until unit has
been allowed to ¢o01.

HOW TO PREVENT IT

Never operate the ©ompr_msor with
guardo or covers which are damaged or

removed.

Any repairs rOClLJiredon this product

should be portormed by authorized

service center personnel.

WARNING: Risk or Serious Injury or Property Damage

When TransPorting Compressor

(Ftre, Inhatae_n, Damage to Vehicle surfaces)

WHAT CAN HAPPEN

Oil can leak or spill and could result in
fire or breathing hazard: sedous injury or

death can result. Oil leaks will damage
carpet, paint or other surfaces in vehicles

or trailers

Always place comprQ_sor on a
protecl_iv_ mat when transporting to

protect against d_mage to vehicle from
leaks. Remove compressor from vehicle
immediately upon arrival at your

destination,

7- ENG D28336

HOW TO PREVFNT IT

if2" i il'l ""' ' '111II =

WARNING: Risk Unsafe Operation [_

WHAT CAN HAPPEN HOW TO PR_VF-NT TT

UNsafe operation Of your air compressor
could Igad to serious injury or death to

you or others,

Rcview and understand all Jnstruc{ians
and warnings in this manual.
Become familiar with the operation and

controls of _hc air compre,_,,r,
Keep opera_in@ are_ alger of el! persons.

pets, and ot_stacles.
Keep children away from the a_r

compressor at all times.
Do not operate the product when

fatigued or under the influence ot

alcohol or drugs, Stay atert at alt times.
Never defeat the safety features of this

product.
Equip area of operation with a flr_

cxtinguisher
Oo not oper,lte m,_chinc with mi_ing,

broken, or unauthorized parts.

DZ63_ 8- ENG